3 ways to make Bio diesel from waste veg oil ! Making easy Bio diesel at home ! Making cheap fuel !

No video

3 ways to make Bio diesel from waste veg oil ! Making easy Bio diesel at home ! Making cheap fuel !

Рет қаралды 236,931

Field to Farm

Күн бұрын

Пікірлер: 435

@tinderboxcreations 2 жыл бұрын

I have to jump in here. "Biodiesel" is a specific fraction of vegetable based oils. Because veg oil is a triglyceride (3 glycerine molecules to every oil chain) it requires cracking or cleaving using methoxide. That's a compound made mixing potassium hydroxide and methanol. This sets up a m exothermic reaction to create the methoxide. This is then introduced into the veg oil where the reaction begins to cleave the glycerine from the oil molecule. At the end you will be left with glycerine and carbohydrate oil chains or biodiesel. This is the same stuff used in white diesel up to 10% nowadays. Usually shown as 'B10' on the forecourt pump. Just adding veg oil to another oil is not biodiesel. Its a blend of oils and the veg oil still contains the glycerine. Call me pedantic but it's important people understand the distinction.

@thatsmysidehustle4261 Жыл бұрын

Would it hurt anything though

@tinderboxcreations Жыл бұрын

@@thatsmysidehustle4261 It's all about viscosity. Blend your veg oil with atleast 50% deisel or kerosene during summer and mild months. Down to 30% in the colder months. Any conditions below approaching freezing and below and the fats will wax up so don't use a drop of veg oil in these temps. I've been running my Sprinter on 50/50 for years in the summer. No ill effects at all. Engine loves it.

@kylebutler1101 Жыл бұрын

You got it the wrong way around. A triglyceride is 3 fatty acid chains to 1 glycerol molecule.

@tinderboxcreations Жыл бұрын

@@kylebutler1101 Correct. I did get it wrong way round. Cheers.

@bbbbhj9177 Жыл бұрын

Any idea to turn it into b100 For low speed engine ??? For high speed engine b100 may not be possible for low speed bulky engine for agriculture pump, b100 is possible??

@johngoodwin6800 Жыл бұрын

Thanks for the inspiration. I'm an old age pensioner, who partied his life away, and never saved. Fuel is second to food, cost wise each week, as I live in the bush, and it's a 40km (25 miles) to go to a supermarket. Have pump, ordering filter bags now. Again, thanks.

@slothypunk Жыл бұрын

did you still party?

@daniellapain1576 Жыл бұрын

New method of filtering was found. Just use gelatin powder and mix it up into warm vegetable oil and what happens is the oil will separate naturally while the impurities like a magnet, stick to the gelatin as it settles out. You do need to refrigerate for the process to speed up but if it's winter stuff it outside for a bit. Pour it out into a container and on the bottom should be gel. That's your waste material.

@Rural_racer Жыл бұрын

Saw that, tbh I thought it sounded more of a faff than using some filters

@daniellapain1576 Жыл бұрын

@@Rural_racer sounds like it but it's cheap enough to test out so why not 🤷🏻‍♂️

@csabizih9195 10 ай бұрын

The oil-gelatin mixing ratio can be known?

@obduliocerceno4984 8 ай бұрын

Such a clever idea!!! Wow I will try. I live in a tropical climate year around: Panama. Thank you for the tip!!

@AmericanRustWorker3369 2 жыл бұрын

Thank you very much, I was thinking about the methanol alternative but I like the kerosene idea much better! No waste and it’s cheaper than methanol and no mess

@jcdragon77 Жыл бұрын

I've seen a guy here using Metholated spirits and lye, and then silica gel.

@gregs_garage Жыл бұрын

It's easier but it's not Biodiesel. It's mixing flammable goop together that may burn in a diesel motor.

@ninjaandmousesadventure4035 2 жыл бұрын

I can't wait to try this on my f250 I'm have dreamed of running biodesiel for a decade!

@j.manning2759 Ай бұрын

Did you try it?

@jacktherack9551 Жыл бұрын

I ran my old Ford transit on vegetable oil and diesel. Mix for years,,no problems other than having to change my oil filter more often, friends used to say it smelled like a chipper 😎

@RaimeThePurebloodGoyim Жыл бұрын

Need this vid for our survival thank you Time to fill up our Toyota Diesel SUV

@mazdaman1286 2 жыл бұрын

When I had an old Citroen with the 1.9 TDI engine, I used to take old veggie oil gravity filter it overnight by putting a 25 litre barrel on step ladders and let it trickle through two diesel filters and then into another barrel , then into the car. The fuel filter sat on top of the thermostat housing so got almost instant heat from start up. I was running a Bosche fuel pump and injectors. The Lucas CAV pump was the better pump but not robust enough for the viscosity of veggie oil. In the winter months I would mix in diesel , if I did not put enough in the car would still run but roughly and would have to idle for a few mins until the thermostat/filter housing warmed up then it was fine. I normally added 25% diesel summer no problems . Great engine ran up 400k miles, body and back axle bearings gave out eventually although I believe the engine was transplanted into a Pug 306. A friend worked out it was costing me around 6 to 8 pence a litre... happy days. A later HDi was too fragile and would involve a lot more work.

@WorivpuqloDMogh Жыл бұрын

Got the same engine, but the soft turbo version, the 1.9SD. I am thinking about running a 50 50 mix of veg and diesel, and i have the lucas one. I heard on pure veg it will wear down fast, but do you think this mixture will work well?

@mazdaman1286 Жыл бұрын

@@WorivpuqloDMogh be very wary when it gets cold and the viscosity increases it can go quite thick and the lucas pump cannot handle that. I got my car at a bargain price because the main pump drive had sheared when the temperature fell down toward freezing. I swapped over to the Bosch pump and injectors which ran fine. If you live some where warm should be no problem but if the winter temps fall low mix with diesel or go full diesel, it a PIA to swap out pumps.. try putting a sample of veggie oil or bio diesel in your freezer and see what happens.Most places swap over to winter diesel in the colder months. best of luck. Wear can be an issue so I would go 50/50 and hopefully it will run fine, i believe the lucas pump has finer tolerances than the bosch pump.

@WorivpuqloDMogh Жыл бұрын

@@mazdaman1286 perhaps i should swap a Bosch instead lol. But it is a hassle i read somewhere. And i dont dare to touch the timing belt

@mazdaman1286 Жыл бұрын

@@WorivpuqloDMogh yes ideally a pump matching injectors and pipework. I did cambelt and waterpump change when i fitted mine. had to fine time the pump by trial and error the normal timing pins in the engine are usually close enough , but I advanced the pump until it started to knock under hard load then backed it off until it was not present left it at that. I often wondered how it would have gone in the little Peugeot model . all that torque, a real flying machine and economy to boot .

@WorivpuqloDMogh Жыл бұрын

@@mazdaman1286 yeah. Sounds like a hassle though. The Xantia has a really tight space to take off the timing belt. Still, i believe it will be worth it. Mine has less than 100.000 miles on it, at 133.000 kms. Bought it for 1000 euros, form a car dealer that told me they got it from an old man who passed away in 2020. The service record is there too. Well maintained, looked almost brand new inside. Only drawback is the power. Its turbocharged with a low pressure turbo (already turned it up, but at the cost of some fuel economy) and a pump without boost membrane and no intercooler. I plan on fitting an intercooler to it, which will increase power and maybe fuel economy too. I will look into it. Right now financially i dont have it very well because of everything going on in the world right now. And the timingbelt was replaced at 132.000 kms

@leeisenberg 2 жыл бұрын

I wish kerosene was cheap here in the USA, it's close to $5/gallon here. Thanks for sharing, good video man. - take care

@dinogenus3783 2 жыл бұрын

Very good method after looking thes vedo I am full of enger thanks thanks thanks

@KuyaHandyKap 2 жыл бұрын

The original diesel engine was actually designed to burn peanut oil. So older diesel engine models without the electronics should be good running kerosene-thinned cooking oil.

@jregamey Жыл бұрын

Finally doing wvo. It's been filtered to one micron and spun in heated centerfuge I added liter or 2 of gasoline and some acetone. Burning it now in my diesel heater What I'll do differently tomorrow is stick the tank inside so it's not freezing and spin the fuel line once around exhaust pipe before going to the heater.

@rushymoto 2 жыл бұрын

If you save virgin glycerol and put it in the next load of veg oil and pump it round it will pre wash the oil by using the remaining methanol and caustic in the glycerol. It will also help to dry the oil to reduce materials needed to process it. The glycerol from that pre washed batch can then wash the batch after that.

@stephenspreckley8219 2 жыл бұрын

Yes, I do this every batch. Funnily, different batches yield various glycerol types, and sometimes the 20 liters I mix in with the "raw" oil doesn't all come back out.About half or only 10 liters. Does it get re-absorbed into the oil I wonder?

@rushymoto 2 жыл бұрын

@@stephenspreckley8219 the free methanol in the gliserol will to into the oil. I did a 300L batch and got 70L gliserol from its 2 reactions and put that in the next load of oil and only lost 5 L of it on draining. It's variable.

@henrinaths1 Жыл бұрын

OK to reiterate the obvious the methanol scrubs the glycerol out?

@rushymoto Жыл бұрын

@@henrinaths1 glycerol is not scrubbed out. It is part of a reaction that breaks down the oil molecule in to 2 parts and liberates the glycerol and replaces it with a bit of methanol to make a methyl ester. A new different molecule.

@donjohnson7189 2 жыл бұрын

Kerosene is diesel simply more refined in aviation it is known as JET-A.

@tinderboxcreations 2 жыл бұрын

Wrong. Diesel is a different fraction of crude oil. It contains less BTU's and less aromatics even though it smells stronger to our noses. Kerosene is not the same as diesel although it can be used in diesel engines with an added lubricant.

@rosscopeeco69 2 жыл бұрын

@@tinderboxcreations could I use kero on an 11 plate Audi a6

@patrickday4206 Жыл бұрын

All 6.2 and 6.5 chevy diesel engines were made to run on kerosene for the military vehicles.

@tomstulc9143 Жыл бұрын

Kerosene is a lighter molecule than Diesel. Kerosene vaporizes easier than diesel has a little less BTU per unit. It was used in 1920 and thirties farm tractors. It was cheaper than gas. Warm the engine on gas them switch to the dissolete tank.. A metal box was heated by engine heat and vaporized the dissolete. . oops the first entry got away without being completed I just noticed that .

@donjohnson7189 Жыл бұрын

@@tomstulc9143 Exactly....amazing what can be accomplished with refinement. 😉

@rushymoto 2 жыл бұрын

I don't filter anything until the fuel is reacted and washed and dried and then I dispense through a 30 micron racor. Most of the rubbish will drop out with the glycerol and wash water.

@tonyloechte9994 2 жыл бұрын

I used half kerosene and half veg oil runs great But Keep an eye on the engine oil it’s going to foul faster than normal and you might loose your savings in fuel on extra engine oil changes.

@Pusse1978 Жыл бұрын

Very interesting video and discussion! I have just secured a source for a small but steady flow of frier oil and now i'm looking into the best way for me to run my old Audi A4 1.9 tdi on this stuff. I'd rather do mechanics than chemistry, so i would prefer to skip the methanol process if possible. As kerosene starts at about €6 per litre here thats not an option either. 10% petrol seems very appealing (and cheap) though. I'm thinking i should mount a separate tank with a preheater and run it's own line with pump/filter and a manual return shut off so oil and regular diesel dont mix, as if i where to run it on straight veggie oil. Most people here seem to go that way here and run the first and last kilometer on regular diesel.

@DailySoundsBoi Жыл бұрын

straight up

@detroitgarage9430 2 жыл бұрын

Great video, I've recently started running 80/20% wvo and petrol in my truck. Runs very well, only draw back is fuel filter changes every 5000 kms.:) I keep a spare set just in case I have to change them on a trip.:)

@artofnoly9754 2 жыл бұрын

Hi DetroitGarage. I heard from a guy in Germany recently, who runs a petrol/WVO mix for his Mercedes. He, and several other sources too, said not to go past 10% petrol, because it thins the veg oil too much, which in turn begins to cause micro-wear within the injector pump's moving parts. (It will cost you less as well). Don't forget to put in a small purge tank to run pure diesel through your engine daily. Very important to do this, for shut down, and start up. Not very complex either. I'm converting an old 20 liter veg oil drum. Have a look at a youtube video by a guy named Craig, called "Driving on vegetable oil". Some really good tips there, and also a good basic schematic, if you ever do a full conversion.

@detroitgarage9430 2 жыл бұрын

@@artofnoly9754 Thanks, I'll definitely keep an eye on that.:)

@noahclouse1830 Жыл бұрын

@@artofnoly9754 great info thank you

@artofnoly9754 Жыл бұрын

@@noahclouse1830 No worries Noah. Hope you get some good results. Ultimately I'll be using a heat exchanger to thin out the WVO so it will flow thru the system without any issues. So, even cheaper again because there are no additives required, only one upfront cost and setup. Have a look at Scintex heat exchangers. Out of Australia.

@johanndejesus9186 2 жыл бұрын

Hi sir, im from the philippines, thank u for this enviro friendly info, ill try this one. More power to u sir

@elijah8402 Жыл бұрын

Started using 50/50 Gasoline and used veggetable oil - 7.3 idi sounds happy.

@abedmarachli7345 2 жыл бұрын

Thank you dear it was very helpful to me especially in lebanon deisel is expensive

@jeffwalsh4373 2 жыл бұрын

55 gallon drum 2 ribs on drum,fill to first rib with cooking oil,add off road diesel and top off drum..run it daily.

@FieldtoFarm_UK 2 жыл бұрын

What you running?

@mechanic1098 2 жыл бұрын

This system work with oil engine oil as well. I find Kerosene works the best with old engine oil 60% Kerosene and filter down to to .5 of a micron.

@mazigerobert4718 2 жыл бұрын

Good idea, if I want to make petrol, what is the the ratio and the process of making it. Thanks

@cogboy302 Жыл бұрын

I've run 50% veg oil, 45% diesel and 5% petrol in a 2.5 litre 6 pot rotary injection pump '95 BMW turbodiesel car without any problems. Plus it smells like someone is cooking. Lovely. - modern common rail diesels don't like veg oil as they run at much higher pressures, up to 5000psi.

@noway7476 6 ай бұрын

Amazing. The sun was peeking its way thru the clouds. Good video. Nuff said

@fredinhisshed5235 2 жыл бұрын

Cheers glad to see things are still going well!!! Awesome Channel and remember watching you planning out the road 👍🏻👍🏻 Always pushing forward 💜

@colinevans1663 2 жыл бұрын

Will the veg oil/ pariffin run OK in the winter in the UK?

@HillSummitHomestead 10 күн бұрын

You can het "contaminated diesel/fuel" from mechanics for FREE. All too often people accidentally fill up a newer diesel car with petrol and then have to get the car fixed. Which means the tank has to be cleaned out. That fuel is an excellent dilutant for veggie oi. Personally I add it to my filtered veggie oil/sump oil and still donthe 50/50 mix as you've shown here. Works fine for me. One extra preventive measure I've taken is to install a marine grade water extractor/fuel filter before the original fuel filter. Just in case there is a drop of water in there, better safe than sorry. idk what is good or bad about the chemistry, so far I'm not complaining.

@TROUROCKS Жыл бұрын

to make the veg oil thinner .. you just heat it . ur engine makes heat .... use that . ive driven millions of miles on straight heated veg .. just use diesel to start and finnish .

@UKsystems 21 күн бұрын

If you want to run something like a generator with very short fuel lines, it is possible to install that heating systems so that you could run this fuel but it does require a bit of modification

@DJ-uk5mm 2 жыл бұрын

Love your presentation style. - there’s always a hint in your tone of voice that says “here’s the secret they don’t want you to know - easy”

@thesetruths1404 11 ай бұрын

All of the used oils and hydraulic fluids I collect at home I catch as clean as possible in a catch can I keep sealed in double trash bags. When full, I pour the 15 qts into 5-qt oil jugs I save from new oil/fluid changes. I let the jugs sit for at least 90 days and then slowly pour off the top 4 quarts. The last quart has the settled solids or contamination in it. I mix 3 gal of the clean used oil with gasoline nearly 1:1 in 5 gallon fuel cans and shake for 1 minute, and put two 5-gallons cans into a 3/4 full tank of diesel. My 2005 Ram diesel has a 40 gallon tank. This makes a mix of about 15% used oils. It seems to run fine Winter and Summer. I do change my fuel filter a little sooner than typical, about every 10,000 miles, rather than 15,000. The dirty oil left in each jug i combine again and let settle another 90 days and repeat. The 2nd time I pour off the top and use the remainder as chain-lube and make two-cycle fuel for my chainsaw, and some start my wood boiler at night. It's a cheap and easy way to get rid of collected fluids, have a little free fuel, and not waste anything either.

@nixonsmateruby1 Жыл бұрын

To anyone crying about this not being Bio-fuel, technically oil in any form is a "bio-oil" as it isn't made from fresh air, it a biological product, and the diesel engine when made was run on coconut oil.

@thelegendsofgaming27 Жыл бұрын

In all processes, we are simply adding an inflammable liquid in the vegetable oil

@lusiscus Жыл бұрын

I have a 2010 focus 1.6 TDCI and have been putting Kerosene in my tank for the last 3 years. I fill up to 3/4 real diesel from empty and top it up to the brim with Kerosene. No problems whatsoever. I borrow the kerosen from my redundant heating tank where I work so it costs me nothing.

@browndatuwwedu 2 жыл бұрын

petrol works as well, some where around 4 or 5 to 1 mix depending on ambient temps

@funkyprepper 2 жыл бұрын

No way, paraffin and veg oil. Amazing lol. Nice job

@KeithOlson Жыл бұрын

FWIW, it is *VERY* simple and inexpensive to recover the methanol using vacuum distillation, leaving just glycerol/glycerin behind, which has a hundred different uses and can even be sold. (...and if you are going to be using WVO/WPO a lot, it pays off in the long run to get a heated centrifuge, as that can remove *ALL* of the particles *and* water.)

@Shakingstevesallotment Жыл бұрын

Thanks for the heads up on filtering, wanting to make for a Chinese diesel heater to heat my home

@karldingbat 2 жыл бұрын

Methanol doesnt thin it, it removes soap (glycerol) and it must be washed out as methanol will bugger your engine

@artofnoly9754 2 жыл бұрын

Yes, very useful info. Thanks Man. Keep it coming. Hope you're all doing well over there. (I'm in Oz a.k.a. Australia). Quite hot here, so viscosity is not so much of a problem, especially in the north. Have you looked into using a heat exchanger to pre-heat you veg oil before it hits the first filter? No expense at all after the initial setup. Basically you can run hot water from your engine block to do the heating of the veg oil. It only needs to come up to 60 degrees Celsius to be thin enough to inject without issue. I'm referring to cotton seed oil, by the way. The most common deep frier oil now used in Australia. Very low in trans fats, making it an excellent easy-to-use biofuel. Just filter it down to 1 micron, pour into tank, and away you go.

@victoriavongate7208 2 жыл бұрын

All you would need is just a diesel gas tank heater with a plug and you just warm it up before you leave

@charlesabc1239 2 жыл бұрын

I agree heat exchanger is the most efficient because you already have the energy source/heat available to tap into, and divert it 👌

@dantuel Жыл бұрын

Most people that are seriously into the biodiesel thing here in the States use a preheater that works off the hot water from the radiator. Biodiesel was a big thing here about 12 years ago when the price of Diesel skyrocketed. You don't hear so much about it now. Another thing that slowed it down was the big companies that are buying the used veg oil from the restraunts now so it's harder to find. They use it in the production of dog food i'm told. BTW, Old Dodge 12 valve diesels and Old Mercedes Benz diesels are some of the best vehicles for Bio diesel / veg oil use. I sometimes believe those old Mercedes would run on water LOL

@bigtrippy4970 9 ай бұрын

Any updates on this mate ? I'm in NSW

@artofnoly9754 9 ай бұрын

Hey Dude, I've come to decide that the cheapest quickest way into the bio-fuel arena is to simply add the filtered deep frier oil (filtered down to 2 microns, as per the vehicle manufacturers standards) to your fuel tank using a ratio of no more than 50/50 WVO (Waste Vegetable Oil) to Bowser diesel. What this will do is subsidise your fuel costs without the need to fit a second fuel system (which is costly in its own right, and it has hidden problems as well). By mixing 50/50 (at a max), this should, in a warm climate, have the viscosity problem remaining under control for your vehicle's injector pump to work normally and without issue. However, I would also recommend running every third or fourth tank full on pure bowser diesel only. This will ensure that the engine is cleaned from within regularly (bowser diesel has solvents) whilst still cutting your fuel bill considerably. I also run a full bottle of injector cleaner thru my bus engine twice a year. I also change the fuel filter once a year (easy job, look it up on youtube) and change the engine oil at the same time. I hope this has been of some use to you. @@bigtrippy4970

@weofnjieofing 7 ай бұрын

Your filter set up is mint👌🏻

@darrenmurray861 2 ай бұрын

Also option 4: use petrol/gasoline at a 20% mix, which is what I do with my WVO. A little acetone helps further with the viscosity also, though I’m talking only 10mL acetone to the petrol-wvo mix as the active can do damage to housing if in too high a concentration.

@dustinpurden7693 2 жыл бұрын

I'm in Canada caracine is expensive here I use gasoline to thin my veg oil for my 2003 1.9 TDI Volkswagen ratio depends on temperature summertime maybe 10% Gas or petrol as you call it. Winter time up to 30-40% Gas

@Typical_Garage Жыл бұрын

What temps were you seeing in the winter? I want to run a healthy wvo/gasoline mix through my powerstroke but 30% gasoline seems like a lot to me.

@dennis-s 2 жыл бұрын

Using the kerosene veg oil mix the glycerol remain in the mix right and olny mixing the oil with the methanol you could eliminate it, so, with the kerosene this separation doesn't happend so it remains in the mix and should burns all sprayed in the chamber am i right? I don't understand if this grycerol would cause some sort of problem to the engine, or the injector or whatever. Any experience using white spirit? An old top gear video shows how you can mix 97 part of oil and 3 part of white spirit to get yourself a well mixed biodiesel, i mean, olny 3% instead of 30 would be even cheaper.

@williammakupa5896 2 жыл бұрын

I read sometimes ago that the double bonds in the carboxylic acid chains cause polymerization in the combustion chamber, forming a gummy substance in cases of dilution approach for biodieseal..

@setoman1 Жыл бұрын

Methanol really really loves water. I’d go with propanol. Burns cleaner too.

@MarriedToTheKGB Жыл бұрын

really useful info, not too click baitey and just perfectly presented. Bravo

@johannesegenolf 2 жыл бұрын

well what you are talking about is not BioDiesel, its WVO/Diesel blends! People be careful as most common rails will not work with that fuel for long and you will harm your engines. It only works with older IDI diesel engines!

@herschelgates 2 жыл бұрын

98 Cummins old enough

@AB-C1 2 жыл бұрын

Excellent video, cheers! 👍🏴󠁧󠁢󠁥󠁮󠁧󠁿

@alexa795 2 жыл бұрын

The are also one more way to make biodiesel from wvo even cheaper. First off all you need to clean wvo very well. I see that you use sock filters but you can use also old jeans to clean it(it’s cheaper). Another thing, water in wvo it’s big no no, so clean it well from water. What it’s the best mix ratuo for my car, it’s the next thing. Mix wvo with rug(regular unloaded gas) in ratio 90% wvo - 10 rug in the summer. In the winter 70% wvo - 30% rug. Here in Sweden winters it very cold and I never jave any off problem with that mix even in -25C. One more thing never ever drive wvo in any common rail diesel car with dpf because that filter will be clogged up very fast. My first wvo car was old Wv Bora 1.9 tdi. I have never any of problem’s to drive that car with wvo mix. But second car was Volvo S60 D5. After only 5.000 km dpf filter was clogged up on wvo mix. Even if your Bosch pump it’s stop to work in some older WV, Peugeot, Mercedes cars you can find cheap replacement on eBay for 50-60 euros. One more thing, from time to time drive your car on full tank diesel fuel, about one time in 2 months.

@sckennedy54 2 жыл бұрын

Great advice thanks so much

@UnCoLouRed01 2 жыл бұрын

whats wvo

@nikolajeftic387 2 жыл бұрын

@@UnCoLouRed01 wvo-waste vegetable oil

@chrisandrew74 2 жыл бұрын

Thinning out the veg oil does not prevent cav injector pumps from seizing though.

@Smittyschannel Жыл бұрын

The Law of Supply & Demand has always fleshed out that if more ppl are buying an item (like kerosene), the price goes up, not down. If no one is buying, demand is down so the price goes down

@daz6637 2 ай бұрын

Very interesting, thanks for sharing 👍🏻

@healthymixzemason1397 2 жыл бұрын

I have to watch this again

@dinogenus3783 2 жыл бұрын

Does it realy work

@setoman1 Жыл бұрын

You can also... add a heater to the system. But it does take some technical knowledge.

@richardsandwell2285 6 ай бұрын

With Methanol you have to have a pump and heater in a reaction tank and expensive Sodium Hydroxide catalyst

@cetate93 2 жыл бұрын

You can also do up a mix of 80% oil and 20% pure gum turpentine. Best to let it settle and filter it after just in case.

@staric4863 2 жыл бұрын

Some good info here. Many thanks for the share.

@SypherSeven 5 күн бұрын

Thank you.

@mattleonard5268 Жыл бұрын

I always mixed my veggie oil 50/50 with regular unleaded gasoline (rug)

@danielrisk5731 2 жыл бұрын

Great video and great information; God Bless and Romans 10; 9 and 10 the Bible Gods Word !

@kevinkruger6233 2 жыл бұрын

With the price out diesel right now. Might be a good idea to learn.

@SweetyVoltyy 8 ай бұрын

2:14 I smacked my screen hard when the mosquito gets in it lol

@luckyphil_01 Жыл бұрын

Great video, easy to follow. Question - what type of generator is that and also type of car/truck you are running - is the car’s motor indirect diesel injection (pre 2000)?

@Ulysses37 Жыл бұрын

Question... Who the hell fitted that featherboard?!

@zodd0001 5 ай бұрын

Take care, burning not regenerated waste cooking oil is crime in many european countries, please check the regulations before.

@vyla2581 2 жыл бұрын

filtration can be used agro film which is used to protect plants from frost it is the cheapest filter. The film comes in 17g; 30g; For 50g / M2 thickness standards, density can be selected or a double layer can be used. It is possible to filter not only during fuel production but also before filling into the fuel tank.

@lagunafishing Жыл бұрын

Is agro film a brand name or something? Never heard of it.

@dama054 Жыл бұрын

I use turps, so 80%oil 20%turps runs lovely

@nwairehsamuel4378 6 ай бұрын

What is turps please

@dama054 6 ай бұрын

@@nwairehsamuel4378 it's turpentine a white spirit alternative

@unnikrishnannairkrishnannair. 2 жыл бұрын

Boil oil and add 2% caustic soda of 5%and separate glycerine and mix with diesel

@johnpartridge7623 2 жыл бұрын

Very good Video full of the right information 👍

@FieldtoFarm_UK 2 жыл бұрын

Thanks :-)

@hunkenpunken Жыл бұрын

Hi Soo...weres the glycerol going in the kerosine and dieselmix? I mean is that not getting sticky or something in filters?

@RaimeThePurebloodGoyim Жыл бұрын

Need your video as my survival guide Need to feed also our Toyota Diesel SUV

@roders97 2 жыл бұрын

I used to run landrover discovery on cooking oil 25/75% winter 50/50% summer until I discovered put a verry little petrol in and it stops waxing that happens in low temperatures and blocks filter.

@milanperovic3592 2 жыл бұрын

How much petrol?

@niuginibricksandbrickmachines Жыл бұрын

Please kindly provide me the ratios for kerosene to vegetable oil. Thankyou

@Smittyschannel Жыл бұрын

he says it in the video

@willwade1101 Жыл бұрын

You can always sell the glycerol to soap makers

@montneymon-ta-knee6810 Жыл бұрын

if you have a small airport near you you can get sump fuel

@frenchenstein Жыл бұрын

Excellent video. Many thanks 👌🏽

@richardoakley8800 Жыл бұрын

Kerosene isn't taxed as a road fuel so you will get a nice fine if caught.

@apspogiMyMerMories_A1-610N 2 жыл бұрын

WOW!!! Thanks for this tip!

@Blaze_1221 10 ай бұрын

Where did you get that water filter thing???

@AngloSaxon449 Жыл бұрын

Any forms of biodiesel has the potential to cause what's known as a "diesel bug" which is a build up of bacteria starting in the tank and ending at the injectors, requiring the entire fuel system being replaced. I know this from experience of using red diesel in a loading shovel with 15% bio diesel, I dred to think the hassle vegetable oil will cause

@kylesherman9903 2 жыл бұрын

I've got a smaller farming operation in the US. I burn about 3500 gallons a year of red diesel. If I were to mix up a batch of say 500 gallons and stored it in tanks like I do with regular diesel will the kerosene separate from the oil or does it stay mixed. Need to know if I need to figure out a agitator system or not. Never done my own fuel before. Thanks

@5thGenNativeTexan Жыл бұрын

Not knocking these methods for using waste vegetable oil, but just to be clear, this is NOT biodiesel. Biodiesel requires a specific processing method using both methanol and a catalyzer such as potassium hydroxide or sodium hydroxide. Again, I'm not downplaying the methods he shows in the video, as depending on the equipment you are trying to run, they can work. But before someone does this and thinks they can go run it in their modern car, they can't, at least not without serious consequences. I would greatly urge anyone thinking about doing this to do a modicum of research on biodiesel, what it takes to make it, as opposed to just manipulating waste oil to get it to run through certain engines.

@arthurdavidfrench-stgeorge1001 Жыл бұрын

You are a very good presenter. Does it effect seals or pipes of engine. 😊 Thanks.

@paulbrown521 Жыл бұрын

Very informative , Thank you .

@Termiic Жыл бұрын

In at least some countries it is impossible to obtain methanol as an individual, only if under a companys name, which puts first two options out of reach.

@brentsmith5647 Жыл бұрын

Brilliant video thank you 👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍👍😎😃👏

@tadghmaw7013 2 жыл бұрын

Great video and channel my man! Subscribed!!

@FieldtoFarm_UK 2 жыл бұрын

Ledgend thanks 😊

@dalevodden1359 2 жыл бұрын

You forgot to mention something I'm using the methanol you add lie to the methanol to make methoxide then you add that to the waist veggie oil and it pulls all that gunk out of it that is still left and creates the glycerin you pour off the glycerin and save it cuz you can use it for stuff just saying but using kerosene and not getting that glycerin it's a pretty decent idea God bless

@rehoboth_farm 2 жыл бұрын

When you mix 50/50 does it fall out of suspension? If so then how quickly?

@tinderboxcreations 2 жыл бұрын

No. It does not because veg oil is miscible with kero or diesel.

@afdcomposer Жыл бұрын

This is a really good video however if I’m trying to get 250000 more miles out of my excursion I’m more concerned about the long term impact of your 50/50 mix if you can possibly speak to that. Thanks!

@hunkenpunken Жыл бұрын

Were did you find those filters and filterholders for filtering?

@HDDynalowrider Жыл бұрын

Amazon has them

@clydepool4010 2 жыл бұрын

Years ago when fuel was high,i had a mix that included gasoline, diesel clean in the silver bottle,cooking oil,,but I lost the book of the measurements. I have not been able to find it. Hope you can or someone can respond with that recipe.

@higamitakaro Жыл бұрын

they say governments add tax to fuel cost. Used oil makes you drive tax-free ahahahha!

@atrumluminarium 3 ай бұрын

Depends... Here in Malta for example fuel costs are actually heavily subsidised.

@sploogehouse5302 2 жыл бұрын

Thank you for the video! How much would you say a liter cost to produce? Thanks!

@unnikrishnannairkrishnannair. 2 жыл бұрын

Mix methanol and sodium carbonate and water. Get glecerine and inflammable oil

@markusdombois464 2 жыл бұрын

This is brilliant. Thanks!

@FieldtoFarm_UK 2 жыл бұрын

👍

@mikelacross Жыл бұрын

How much did the water filter cost. Do you have a link to said filter & how much oil can you filter through one set of filter pads??? Great vidio BTW 😁

@Smittyschannel Жыл бұрын

it's easier just to buy a 1 micron sock filter & pour the oil in- gravity feed into your container without having to pump it & use water filters. Stack the 10 micron filter inside the 1 micron filter & pour away- fully filtered once it's in the jug, & you're ready to go