Alternator Problems Finally Resolved After 3 Burn Outs

Рет қаралды 8,903

2 жыл бұрын

The one and only major problem of our luxury van build has been the alternator burning out repeatedly. We made a lot of changes and finally success! Hopefully others can learn from our changes.

Пікірлер: 24

@OneLeggedTarantula Жыл бұрын

Thanks for the update!

@johnmedina6473 2 жыл бұрын

If it burns out, take dual alternator bracket and alternator ,go back to stock alternator, all you need is victory dc to dc and it works with your stock alternator without anything extra. GOOD LUCK HOPE YOUR PROBLEM STAYS SOLVED

@chuckanddebbie 2 жыл бұрын

A Dc to Dc charger would not come close to the amount of charging we need to replenish the amp usage we use each day. We typically use 500-600 amp hours overnight and only drive about 4 hours per day. The Nations alternator is working great now!

@garrettgiuffre7298 8 ай бұрын

I bet he's really good at removing it 😅

@RVTraveler 2 жыл бұрын

I had nations install a high output alternator in my RV van. I had electric demon’s from then on. Just saying. Eventually purchased a new van and stuck with the OEM alternator. Works fine.

@chuckanddebbie 2 жыл бұрын

Hopefully we excised our demons!

@vteccured Жыл бұрын

Hello, Can you specify what part was recommended by your local alternator person to prevent alternator damage?

@chuckanddebbie Жыл бұрын

balmar.net/product/apm-12/

@MarineHowTo 23 күн бұрын

BEL 3 is nowhere near enough for LFP batts..

@seccat Жыл бұрын

I’m guessing that your DC-DC charger is set incorrectly. It’s allowing too large of an Amp draw (see Victron’s video).

@chuckanddebbie Жыл бұрын

No Dc-Dc charger. It has a Balmar regulator programmed for lithium. Lithium can except a .5c charge which would be over 550 amps so not a problem at all.

@azteca8037 Жыл бұрын

What is the new part called to protect the alternator?

@chuckanddebbie Жыл бұрын

balmar.net/product/apm-12/

@chuckanddebbie Жыл бұрын

balmar.net/product/apm-12/

@user9b2 2 жыл бұрын

Why install the alternator so low to the ground, wouldn’t debris get into the wires and short the whole thing?

@chuckanddebbie 2 жыл бұрын

It is about 17” above grade and that is 4” above the frame cross member. This is where the Nation’s alternator kit mounts it.

@debawallce4124 6 ай бұрын

have u checked the starter wiring or change your starter

@chuckanddebbie 6 ай бұрын

Wiring checked numerous times. Unrelated to the starter as the hours wiring is completely separate from the chassis side.

@thomasjefferson8629 Жыл бұрын

Why in the holy dogshit is that alternator mounted in the mud zone... Who designed this damn van

@chuckanddebbie Жыл бұрын

That is where the Nations alternator kit puts it. It is 14” above the ground. Doubt it will ever see mud that high.

@thomasjefferson8629 Жыл бұрын

@@chuckanddebbie You're going to see mud that high the next time you drive on a wet road! Any dirt mixed with water, it's going in those louvres, it's going to shred the bearings and commutator bar and seize the brushes in their sliders. Starters go on bottom; starters don't need louvres. This is Silicon Valley engineering at is finest.

@chuckanddebbie Жыл бұрын

Already been on wet dirt roads several times. Not sure what Silicon Valley comment is about. I live in Florida and Nations Alternator is in Missouri. Hundreds, if not thousands of these alternator kits have been installed and I have not heard one story of mud destroying it. I’ll continue to take my chances.

@johnmedina6473 2 жыл бұрын

Victron dc to dc charger. See rv with Tito renogy or victron dc to dc charger for lithium LiFePO4?/ off grid rv solar / rv diy KZfaq published Aug. 15, 2021.

@chuckanddebbie Жыл бұрын

Dc-Dc chargers do not supply enough amps to charge 1,120 amp hour lithium bank. They are used to charge from the factory alternator not a second dedicated alternator.