Audi Q7, crank no start

Рет қаралды 41,352

Kennedy’s garage

2 жыл бұрын

Пікірлер: 129

@yhshah21 2 жыл бұрын

That was 10% computer diagnosis, 90% pure experience and knowledge

@kennedysgarage3281 2 жыл бұрын

Every so often you just know what’s wrong without a scantool, nice percentage break down KANOMAN 😉👍

@mikeberry304 2 жыл бұрын

Another top job Peter, great diagnosis there , good job the other guys didnt fit a high pressure pump on it , love the fuel pipe blanks, I've seen Dave use his on one before , tight Sandy uses ball bearings , spends his money on Iron Bru 🤣🤣🤣

@kennedysgarage3281 2 жыл бұрын

Poor Sandy 😬😬 Cheers Mike 👍

@mechanicmatt871 2 жыл бұрын

Great diag and good job getting that washer out. Cheers mate

@kennedysgarage3281 2 жыл бұрын

I’m not much of a fisherman Matt but I done alright on this occasion 💪💪👍

@calm4477 2 жыл бұрын

That was epic, nice job I really enjoyed that. You must have some patience after your fishing expedition 🤣 Top man, content is spot on 👍

@kennedysgarage3281 2 жыл бұрын

Thanks Cal M, it was teeth clenched stuff there for a few moments 😬 I’m glad I got it out somewhat easy, I wouldn’t have been happy if I needed to remove the rocker cover 💪👍

@wackey3455 2 жыл бұрын

That was a genius of a job to diagnose a car that fast lovley piece of work I say you have a very happy customer well done ✔️ 👍🏻 👌

@kennedysgarage3281 2 жыл бұрын

I was happy enough that I found the problem relatively fast. It had been previously diagnosed as high pressure pump at €3000 to do, so the customer should have been fairly happy. Cheers Paddy 😉👍

@korobuildschannel597 Жыл бұрын

You are a genious... thank you for these videos.

@kennedysgarage3281 Жыл бұрын

I wouldn’t think I’m a genius but if this video helps you someday I’m delighted 😁 🙏🙏👍

@alansmith4974 6 ай бұрын

You are genius sir, good old school mechanics

@kennedysgarage3281 6 ай бұрын

Thank you for your nice comment 🙏🙏🙏

@markholian3506 2 жыл бұрын

You done well to get all those glow plugs out Peter - snapped 3 this week 😤 great diag 👍🏻👍🏻

@kennedysgarage3281 2 жыл бұрын

I hate when that happens 😬, I didn’t even think about it when removing them. I got lucky on the glow plugs but unlucky on the injector washer. Good luck on removing your 3 snapped one’s 🤞🤞

@seismictuning1881 11 ай бұрын

Absolutely spot on mate !

@kennedysgarage3281 11 ай бұрын

Thanks mate 🙏🙏👍

@leecox2853 9 ай бұрын

Great video and good job 👏

@kennedysgarage3281 9 ай бұрын

Thank you Lee, I’m glad you enjoyed it 😉🙏🙏🙏

@Seaside33 Жыл бұрын

Our 2013 Touareg has exactly the symptoms.... I bet its the same trouble.... :( great video, very informative

@kennedysgarage3281 Жыл бұрын

Thank you Nathan, fingers crossed it will help with your issue 🤞🤞🤞

@MrCountryhead 2 жыл бұрын

Nice bit of diagnosis but your experience and hearing is something a computer hasn’t got so well done

@kennedysgarage3281 2 жыл бұрын

Well put MrCountryhead, sometimes we have to trust our gut instinct’s & go with it 🙏🙏👍

@kmatamoro Жыл бұрын

Excellent work

@kennedysgarage3281 Жыл бұрын

Thank you Kendall 🙏🙏

@xegro 2 жыл бұрын

Nicely diagnosed 👍

@kennedysgarage3281 2 жыл бұрын

Thank you Xegro 🙏👍

@moisturisedgnome1181 7 ай бұрын

Thanks for this vid man. Very helpful cheers

@kennedysgarage3281 7 ай бұрын

You are most welcome mate, injectors seem quite common on these. I’ll paste a video on a Touareg no start, you might enjoy it 😉👍👍👍

@kennedysgarage3281 7 ай бұрын

Volkswagen Touareg, crank no start kinda (barely runs on 3 cylinders) Part 1 kzfaq.info/get/bejne/btOkm9iTxLHFk6s.html

@kennedysgarage3281 7 ай бұрын

And part 2, interesting on this Volkswagen Touareg, crank no start. Part 2. kzfaq.info/get/bejne/Y9mPlreJv8m0mXk.html

@larrysimon1 Жыл бұрын

Good Job

@kennedysgarage3281 Жыл бұрын

Thanks Larry 🙏🙏

@omarmohmedom Жыл бұрын

Legend

@johnrobinson6221 Жыл бұрын

Easy to understand, very clear for the car numpty like me. i have an issue wher my Q7 cylinder 6 on your vid injector keeps blowing out. would be clear out but bonnet in way. It pulled the bolt down clip out at the side with the star head on it diesel eveywhere, no bang just warning light and instant limp mode. this is the second time in just undr a year. 85k on the clock 61 plate. everyone keeps tellin me its a common problem. If it is what is the fix and why can't I find an answer to the problem. I learned more by watchng this vid than anything else but I'm still in the dark as to why it keeps happening on cylinder number 6. Can you or anybody out there help? I'm not a mechanic so keep it simple please.

@kennedysgarage3281 Жыл бұрын

I think that you must focus on the detail here. 1. Ream/ grind the injector hole 2. Fit a new Audi washer 3. Fit a new Audi stretch bolt 4. Tighten the bolt to the exact torque setting All of these details will be carried out by a suitably qualified garage & if so you shouldn’t have any more issues 🤞🤞

@briankotze57 2 жыл бұрын

Awesome diag

@kennedysgarage3281 2 жыл бұрын

Thank you Brian. Sometimes you gut instinct or experience beats technology 💪💪👍

@trevormansfield6740 2 жыл бұрын

Really good video Peter. Well diagnosed. What make are those blanking plugs? I need to buy them. Thanks

@kennedysgarage3281 2 жыл бұрын

Hi Trevor, this is a link to eBay for the injector blanking plugs. They are very handy for isolating 1 or all the injectors to test the fuel pumps ability to build pressure. I’m glad you liked the video 🙏🙏👍 www.ebay.ie/itm/174156541209?mkcid=16&mkevt=1&mkrid=5282-175127-2357-0&ssspo=0RbtY2feRfS&sssrc=2349624&ssuid=bjxxf8trsrm&var=&widget_ver=artemis&media=COPY

@trevormansfield6740 2 жыл бұрын

@@kennedysgarage3281 Thanks 👍

@Drakesy 7 ай бұрын

I found the best way to get the washer out was a j bend bicycle spoke, snagged it first go

@kennedysgarage3281 7 ай бұрын

Wow, that sounds like a fantastic idea 🙏🙏🙏

@khakalethumbete5269 Жыл бұрын

Great video, did you manage to see the actual pressure reading to that of specified pressure after managing to start the vehicle?

@kennedysgarage3281 Жыл бұрын

No, unfortunately once it started & ram I didn’t look at any data afterwards 😔😔

@khakalethumbete5269 Жыл бұрын

Would have loved to see if it matches that specified. Thanks for the great content though

@remotaurog 2 жыл бұрын

Nice work Peter, if all jobs were that handy ,what bait did you use for fishing .

@kennedysgarage3281 2 жыл бұрын

I think ‘experience’ was the bait on this one 😬

@hobo1704 Жыл бұрын

Legend 👏. Do you need to change the engine oil due to the leaking diesel into the cylinder? Cheers

@kennedysgarage3281 Жыл бұрын

It depends on how long it was leaking. Smell the oil on the end of the dipstick or just change it if you want to be cautious 👍👍

@hobo1704 Жыл бұрын

@@kennedysgarage3281 thanks for that mate, cheers

@michaelnorval6247 2 жыл бұрын

My Audi A6 with the same engine cut out on me today and won’t start done the same test as you have done on cylinder 3 it is chucking fuel out the rest are dry have a ordered a new one here in the morning hopefully this will sort it 😀👍

@kennedysgarage3281 2 жыл бұрын

I’ll keep my fingers crossed for you, let me know how you get on 🤞🤞

@michaelnorval6247 2 жыл бұрын

My injector turned up today couldn’t find the old injector seal had to take the the rocker cover off looked everywhere for it still couldn’t find it could of feel out when I took cover off any way put it all back together it started and runs like a dream am so glad you put this video you saved me loads of time and money thank you so much 😊

@kennedysgarage3281 2 жыл бұрын

@@michaelnorval6247 brilliant & well done man. It’s all worth doing when you get a good result 👏👏👏 Spread the word & ask your friends to subscribe for various hints & tips, please & thanks 🙏 🙏🙏

@michaelnorval6247 2 жыл бұрын

No problems will do thank you again 👍👍

@lovepreetsinghhanjra1997 2 жыл бұрын

Nic video sir 👍🙂

@kennedysgarage3281 2 жыл бұрын

I’m glad you enjoyed it 🙏🙏

@lovepreetsinghhanjra1997 2 жыл бұрын

Where are you from sir

@kennedysgarage3281 2 жыл бұрын

@@lovepreetsinghhanjra1997 I’m from Ireland 🇮🇪 & where are you from ??

@lovepreetsinghhanjra1997 2 жыл бұрын

sir I'm from India (punjab)

@kennedysgarage3281 2 жыл бұрын

@@lovepreetsinghhanjra1997 thank you for watching from so far away 🙏🙏🙏🙏

@AgustinLee-s2g 15 күн бұрын

Hello I’m having this issue however there is no diesel being shot out whenever the glow plugs are all out. Do you think the high pressure fuel pump is bad?

@xonykmind 4 ай бұрын

Very Great Video 👍🏾

@kennedysgarage3281 4 ай бұрын

Thank you sir 🙏🙏🙏

@Isac2003 Ай бұрын

Yes his good mechanic but please don’t rev de car on P mod you can break the gearbox 😊

@kennedysgarage3281 Ай бұрын

@AhmedAli-hu8ng 2 жыл бұрын

Great job boss but ihave one question ihave Chevrolet 2.8crd engine show me p0087 low fuel pressure ican cheng injectors ican cheng low pressure fuel pump but fualtcode still they car start fine but when ican go around 3000 rpm car shutoff himself

@kennedysgarage3281 2 жыл бұрын

Unfortunately there is no straight forward answer to this problem ☹️ You must check the following items, 1. The low pressure pump & line’s 2. The high pressure pump 3. Last but not least the injector’s Have you changed the fuel filter?? It’s a cheap & easy place to start 🤔

@timbo19751975 Жыл бұрын

before connecting any scan tool, spin the motor and listen to it. Tells you alot.

@kennedysgarage3281 Жыл бұрын

Correct. My colleague was trying to fix it before me with a scantool & I nearly knew what was wrong from the sound of it cranking 👍👍👍

@masterichigo6206 7 ай бұрын

sorry mate, did you replace the glow pugs? or did i miss that bit.

@kennedysgarage3281 7 ай бұрын

Hi, no I didn’t renew the glow plugs. I only refitted the old ones, diesel won’t bother them 😉👍👍👍

@zmx363 Жыл бұрын

B7 3.0 tdi - 233 hp My cars having the issue where it will start up but on occasion it won’t. Or if it is idling the revs will drop and the power will cut out. Just now I was driving home and in 3rd gear at roughly 35/36 mph the glow plug lights started flashing and the power cut off. Now waiting for recovery, if they aren’t here in an hour I should be able to start up again and get back home. Would this be the same issue as diagnosed in this video? I have a feeling I need a new hpfp or maybe just need to change the belt

@kennedysgarage3281 Жыл бұрын

Has the recovery guy done a fault code scan?? It would be nice to know what direction to go 🤔🤔

@barrymcmahon469 10 ай бұрын

Having a somewhat similar issue with my 07 q7. Fault P1063 low fuel pressure. Seems like very low fuel rail pressure. Replaced fuel filter, was full of gunk. replaced fuel pressure regulator valve, cleaned fuel pressure sensor. Checked flow from low pressure pump, looks ok. Crank but no start, though it will start when I spray easy start into it. Was thinking it might be loss of fuel pressure through leaking injector, but the fact it starts with a spray of easy start has me confused. Any thoughts? Thanks, and great work!

@kennedysgarage3281 10 ай бұрын

They injectors won’t be commanded to open if the fuel pressure doesn’t reach 200 bar. So you really need a high pressure fuel gauge to see what the high pressure pump can do. This would be a good place to start anyway Barry 😉

@barrymcmahon469 10 ай бұрын

@@kennedysgarage3281 High pressure pump all good, figured out losing fuel pressure through excessive leak back on four of the injectors.👍

@kennedysgarage3281 10 ай бұрын

@@barrymcmahon469 well done Barry, fair play to you 💪💪💪

@powera85 2 жыл бұрын

Be lucky if she ain't after diesel washing herself also. Nice kit of injector blanks where ya get em? 🤣

@kennedysgarage3281 2 жыл бұрын

Hi Adrian, this is a link below for the injector blanking set on eBay 😉 www.ebay.ie/itm/174156541209?mkcid=16&mkevt=1&mkrid=5282-175127-2357-0&ssspo=0RbtY2feRfS&sssrc=2349624&ssuid=bjxxf8trsrm&var=&widget_ver=artemis&media=COPY

@jpgnade1077 6 күн бұрын

About to be diagnosing the same issue but I can’t find the block off caps anywhere, do you know what size I need?

@kennedysgarage3281 2 күн бұрын

@@jpgnade1077 is it the block off caps for the injectors?? If so unfortunately not. But they can be bought carrying the bigger and smaller ones in a set.

@mikesoja 7 ай бұрын

Any idea why sometimes my engine cranks and sometimes it doesnt when i turn the key it makes a clicke sound but no start? Would this be a bad starting motor? I already put a new battery and a new ground cable

@kennedysgarage3281 7 ай бұрын

It sounds like the starter motor. The click signifies control to the starter solenoid. Ruling out most wiring issues 😉👍👍👍

@davesterl 2 жыл бұрын

Nice Borescope. Side camera for the win

@kennedysgarage3281 2 жыл бұрын

A wise man once recommended it to me 😊 It definitely did save the day on this one Dave 🙏😉

@marquescmadhimba7742 Жыл бұрын

My Audi Q7 2007 doing the same, not starting

@kennedysgarage3281 Жыл бұрын

It would be worth looking at the injectors & fuel pressure live data 👍👍

@mixvideosnorway481 7 ай бұрын

Hi i have the same problem, have a audi q7 2011 mod. Nor starting, how can we find out the problem with injectores, the car stopd when i was deiving in lik 20-30 km it just stopd.it cold be the injector og the dieselpumpe says the mechanic, and both of them r epenxive parts. Is it pisible to find if it is the injectores? Crank bit no start.

@kennedysgarage3281 7 ай бұрын

Have you tried removing the glow plugs like I did and look for fuel spraying from a cylinder???

@mixvideosnorway481 7 ай бұрын

@@kennedysgarage3281 hi no i wil remove them and see😊 thanx

@kkk-wp1kv 2 жыл бұрын

2 quick questions peter as a d.i.y.e.r. Is a leak off test the quickest way to find a bad injector without a posh scanner🤔 Are bahco socket sets any good? .what tool brand do you buy ?cheers

@kennedysgarage3281 2 жыл бұрын

An injector can leak in 2 place. 1 is up through the injector body and out the leak back pipe, 2 is into the cylinder through the nozzle. A leak off test will find the first but not the 2nd . Bahco are a good brand, I’m not too fussy with my brands. Tengtool , sealey, draper or any of the known brands are ok. Snap on can be very expensive but are possibly the best 😬👍

@danielpantazescu7720 Жыл бұрын

I know it's been some time since you've asked, but still Bahco tools are top quality, no matter what I've used from them. A bit pricy but worth it

@jamesward5721 Жыл бұрын

Pump - high has a rupture - or an injector/rail solonoid is leaking. My guess after seeing the data but no fix. :-)

@jamesward5721 Жыл бұрын

Yup - leaking injector. :-) Thar she blows! Vags do love doing that. My kinda Lad. Subscribed. :-)

@kennedysgarage3281 Жыл бұрын

I’m sorry James, I don’t quite understand 🤔🤔

@jamesward5721 Жыл бұрын

@@kennedysgarage3281 Must be my accent - I'm Kildare. Nobody understands us. :-)

@kennedysgarage3281 Жыл бұрын

@@jamesward5721 I’m worse 😂😂😂 It’s is an injector that failed in it anyway. Fair play to you for watching & commenting James 🙏🙏👍

@jamesward5721 Жыл бұрын

@@kennedysgarage3281 I said injector - that or the rail moderator... either or.. it turned out to be an injector - predictable on Q7's - they do that a lot. :-) We may need to hire a translator here.. Ye down there speak funny. :-)

@El_companero_7 6 ай бұрын

What may have caused the SAFE?

@kennedysgarage3281 6 ай бұрын

SAFE on the instrument cluster was caused by a previous workshop removing the immobiliser. It was showing up for the last 2 years, I was told by the owner so paid no attention to it 😉👍👍👍

@El_companero_7 6 ай бұрын

@@kennedysgarage3281 mine has it and car won’t start only cranks

@kennedysgarage3281 6 ай бұрын

@@El_companero_7 it is most likely an immobiliser issue you have so 🤔🤔🤔

@catalinmazilu4196 Жыл бұрын

Hi mate I have an Audi A7 and I have this problem p2146 ,fuel injector group A supply voltage Circuit open .Can you help me ?Thank you

@kennedysgarage3281 Жыл бұрын

I think we were talking on messenger or WhatsApp 🤔🤔

@quincybattle9458 11 ай бұрын

What end being the problem?

@catalinmazilu4196 11 ай бұрын

Hi ,Injector number 2 was stock open

@sajidnajim9498 Жыл бұрын

I have audi Q7 4.2 tdi crank but no start can you help me

@kennedysgarage3281 Жыл бұрын

Possibly not, I would need to see the car to fix it 😞👍👍

@grunastramen2178 8 ай бұрын

My audi q7 2007 3.0 TDI is starting well 80% of the time, but sometimes it won't start on first, on second/third try it starts in 99%. Only one time I needed start spray because it just doesn't want to start, at first it was totally dead and after I tried cables it had enough power for this sound of turning on(i dont know to translate it), but it was just impossible to turn it on. It was close to turn on but nothing, and after start spray it turned on immediately. I visited lot of mechanics and electrics, but noone could find problem with diagnostic, even special Audi diagnostic didn't find anything. They just say drive it's fine but I know it isn't fine because I'm never 100% sure car will be good. Only thing they told me that I should buy this better battery 🔋 but that probably is not the problem. Can you please help me, what do you think?

@kennedysgarage3281 7 ай бұрын

These symptoms do sound very much like an injector starting to fail. You look at some injector live data on a scan tool. Look at injector balance or injector compensation. The other option is to remove all 6 and get them tested by a diesel shop. I believe this would answer your problem 😉🙏🙏🙏

@grunastramen2178 7 ай бұрын

@@kennedysgarage3281 bro I was searching and it was earth cable problem can you believe. Now almost a month everything is fine, turning on without problem.

@kennedysgarage3281 7 ай бұрын

@@grunastramen2178 well done mate 💪💪💪 happy new year 🍻😩

@justinfufun5483 2 ай бұрын

@@grunastramen2178 Which one? sounds familiar symptoms.

@grunastramen2178 2 ай бұрын

@@justinfufun5483 q7 2007 3.0 tdi 233 hp, it was earth cable problem with my car

@shakkhan6075 Жыл бұрын

Mate i am having the exact problem all the mechanics i have called have not mentioned what you said and done…… its been 4 days now the car is just parked on a corner HELPP……

@kennedysgarage3281 Жыл бұрын

What help would you like??? Are you in Ireland?

@shakkhan6075 Жыл бұрын

@@kennedysgarage3281 unfortunately no i am in Birmingham my car has exact symptoms I don’t know what to do….

@kennedysgarage3281 Жыл бұрын

@@shakkhan6075 if you are anyway handy with cars do exactly what I did, remove the glow plugs & crank it over. Then see if any fuel blows out ??

@shakkhan6075 Жыл бұрын

@@kennedysgarage3281 ok i will tell my mechanic thanks a lot 🙏🏼🙏🏼

@BigUche Жыл бұрын

@@shakkhan6075How did it go ?