Smashing video, pointed out all the common problems whereas garages would never tell ya otherwise.

One more thing I’ve come across on a few of these cars (My Dads old e60 530d and my e65 730d) is the vibration damper or crank shaft pulley. They tend to go out so checking the rubber centre for cracking or wear periodically may also be a recommended.

Yet another professional, accurate detailed video Doc showing just why your a cut above the so called "competition". LONG LIVE THE BMW DOCTOR. 💎💎💎💎

Hey man im working over my uncles e61 525d 2005 and he has been running with the burned up throttlebody for a while and he pulled over and stopped driving when he saw massive amounts of white smoke from the tailpipe. i fixed the throttle body and cleared the DTC's but now he has pressure and smoke coming from the top cover when i remove the oil cap. but strangely not from the oil level dip stick. engine runs well and no power lack . Thanks, Cheerz!

When should you chain its chain and. Do you need to mess with valve slack?

Man thx thx alot for that exelent tips, God protect you.. i normaly do my mecânic work but i am learning about new Cars and i have a 525d and i Need to know all of this.

THANK YOU ! 2000 e38 730d here that was neglected for years by its 12 (that's the real number) previous owners 😁

I have e90 m57n2 (231) My car has a complete exhaust system, egr is canceled.. big turbo and intercooler.. my problem is this... my car runs with 2.5 bar pressure.. but the pressure suddenly drops to 0.8 at very frequent intervals without any warning light on.. when I stand aside and turn the car off and on, it gets better. But it does this very often. My map sensor is working properly

Only problems I've ever had, and there have been very few, with the M57s in my two 530D E39s have been caused by poor maintenance. Crankcase filters not changed when they should be, they've now been changed for the later washable filters and a blown turbo because one had sat for 12 months or more and hadn't been serviced properly when the (non-BMW) dealer sold it to me. Other than that injectors, EGR etc are all in fine condition after 170,000 miles. The only other failure has been the water pump, both of them had the water pump fail at approx 165,000 miles. According to a number of videos listing common/inevitable failures both of the engines should be completely wrecked by now. Be interested to know what a common failure is 1in4, 1in100, 1in 1000...

Hi Doc I have an issue with my 530d 2004, it vibrates on idle and even more on acceleration particularly around 1500rpm, my mechanic suggests that a piece of the aluminium flaps is stuck in or around one of the cylinders. He went on to say I'll need a new engine if I want to keep driving the car... Please what do you think is the issue and what can I do to fix it without replacing the engine? Many thanks in advance for your reply, I really appreciate your informative videos.

Aup fella! Been watching your videos for a while and your videos are mint👍🏼 My mates got a 03 530d He got the car of a recently passed away family member. The car smokes from the engine bay white smoke near the turbo. We left it running for 30 mins and it cut out now it starts but cuts out at 2k revs cant figure it out.

Hi BMW Doctor. Great knowledge you have with bmw wips 😎 keep it up brother. asking for your advise please. Have a E46 330D msport 54reg 204bhp remap 224bhp. smoking & rough idle on cold start. HAD GLOW PLUGS COME UP ON SCAN a few months back and Swirl flap actuator? not sure if it was deleted from remap the swirl flaps activator. believed glow plugs and stats was causing white smoke when flooring it in dark and being winter and cold in rear view mirror smoke. also not being up to temp bad main stat and egr stat. sorted now. I know my turbo has play. back and forth not side to side.? resently had exhaust manifold done as i could smell fumes in cabin had a split in it was original tin ONE swapped for cast iron one. swirl flaps done from remap years bk EGR blank. from remap now iv had glow plugs done as 5 where gone, replaced 6 working yesterday, had low temp so main thermostat done and EGR THERMOSTAT all's fine with temp now. also even changed crankcase breather from a vortex bk to a new vortex breather. I no they can be cleaned up but was trying to make sure it's new when put back. since having the Exghust manifold change car has rough idel And smokes bad only on cold start could it be a bad injector after it being removed caused damage?smoking on cold start ups or when left for hours. before I had the exhaust manifold done it wasent smoking on cold start up or rough idol could this be A leaky injector, turbo, or swirl flaps actuator? only smokes on cold start up then gose after 30 seconds a white blue colour. a bit smelly any clues please . sorry for the long message BMW DOCTOR

730d m57, after driving, locking the car, going to a store and when I come back and press the unlock button on the key fob - it unlocks and sound starts going off, actually it kind of sounds like a long 10-30sec fart, it seems it comes from the right side of the engine (under intake manifold), any ideas? Oh, and also when driving above 1k rpm - drives great, has great power ant torque, but if left on idle - rpms start to jump up and down +-100 rpms. Injectors are tested, filters changed, any ideas? Maybe these 2 problems are caused by the same thing that makes that sound?

Great vids m8 , got oil coming through turbo intercooler pipe going into intercooler, noticed as it leaks , any ideas? Would appreciate your expert opinion, thanks

Thank you for the video. Was wondering if you have an idea on the following issue. I have a 2011 E90 316d N47 engine. The engine has been running rough on idle (it revs up and down at less 1000rpm) and feels like loss of power in low gears between 1000-2000 rpm, especially on cold starts. There is no black smoke though and I'm not sure whether it is a dpf or egr issue. I also have the following fault codes: 1. 4B05 Zero-Quantity Adaptation, Injector, Cylinder 4 2. 4AFB Brake Vacuum Sensor, Signal 3. 4AFA Brake Vacuum Sensor, Signal Thank you

Hi, Great video.👌😉 Can you please advise about black smoke please? I do have BMW E93 330D November 2007 M57N2. All filter have been done,oil change ,fuel lines going into injectors,all seals but car still smoke black/blueish and you can smell like burnt diesel? Can you please point me into direction? Car been stood for about 6 months before Full service been done.

Mine is running a little rough on start up. I’ve changed the glow plugs, egr delete, swirl flap delete and oil change. It’s slightly misfiring on idle, but disappears when hot. Anything I should check? Great video!! 👍

I need some help man my 2004 e60 525d had a bad starter so I’ve replaced it now it turns over but won’t fire up but when I tried a spray of easy start and it stumbled and tried to start

Dean, I just bought BMW e46 Coupe, motor is M47 from 2004, from my gopd friend. He maintained it pretty good, oil changes and filters were regular every single year, BUT do you suggest to me to take away swirl flaps and block EGR completely anyway, or I should keep them? I checked trillion forums, videos, etc and its 70% to take em off, and 30% to keep em, and both of these people have good arguments. What should I do? Or if i decide to just clean EGR valve and intake manifold, and remove swirl flaps, will that be a good idea?

Hi mate from your experience is m47 blow by normal? Changed to the vortex style but there is still blowby. I have not changed the diaphragm.

Do you know what would cause multiple injector errors in the span of a few days?

My bmw 2004 530d e60 makes a squeak sound when I accelerate at low rpm any ideas

Hello wanna ask for e46 330d 2005 204hp the car is being drive in city but with 20 30 kmh when accelerating heavy it smokes blue for 2 3 seconds and then is gone is it normal only when heavy accelerating

Hi,I have same engine on x5 2012,starts good,idles good,no smoke comes out,but while driving heavy white smoke comes out,can’t even see the cars behind,while idling everything seems good,no codes,can you suggest me something,what should I check or what can cause that.thank you!

Do you get any fault codes coming up with the HP fuel pump being faulty. (525D E61. ) I have an egr blanked but no shudder valve fitted, (previous owner) plug is just tucked away. Im guessing it was coded to ignore that fault code. Engine is running very rough, misfiring (its not a constant misfire like an injector, seems to be erratic which cylinder misfires) and cant get any rpm when i press accelerator just shudders and gets rougher. not always but sometimes it smokes white. smells chemical. Im thinking it may be trying to regen when the smoke happens. Ive replaced the MAF, no change. Im scratching my head over this now

Great video, my e46 330d manual m57n 2003 204hp runs stationary pretty rough. But when cold is runs as smooth as can be. Only with warm up engine is runs rough. What should i check? Vacuum lines? Car has 550.000 km btw. And is stage 2 remapped

I'm currently having issues with my e39 530d, car turns off when acceleration pedal is hard pressed to 3000 rpms, could you please give me advise on DMs so we can have more complicated talk.

2013 lci 730d has smoke at back of engine... cant see anywhere its sitting on the tray? also power is down... no idea what it is but wish you were in QLD

hi, looking for advice. have an 07 530d m57. last night the hose from intercooler steel pipe vertical next to radiator to the plastic elbow on the throttle body blew off with a loud pop, the top hise clamp looked like it wasnt tight enough, i refitted the hose and also fitted a new clamp. took it for a test and within 3 minutes when i accelerated it popped again, this time it wasnt the hose that let go, the plastic elbow wgere the metal clio slips in, cracked right off and went into limp mode. im thinking wastegate as something is obviously building geps of pressure. where do i start to look at. also has oil getting through the system as inside of pipe and intercooler is oily. cheers

Hi. old video but I'm trying to ask here and hope for an answer. I have a 530D e39 that won't start when it's hot or when it's too cold outside. kag must use start gas then it starts immediately. it runs fine in the engine when it starts no misfires or anything strange. What could be wrong? 😐

Dean hope you keeping well? 2008 BMW E93 330Msport Quick question my breather is the old type and someone has removed the filter and then refitted, Will this affect the running, I know the filter is there for a reason and should be fitted so I'm going to order one. I have removed my swirl flaps and left the actuator connected, I just removed the Control rod, but my boost solenoid is quacking like a duck so gotta do that next. Manifold off again.. inpa mass air flow shows cylinder 2 over pressured on tick over and 5 is low red of the scale, when revved they all level off.. car runs ok but engine rock is bad and tick over is lumpy, inpa gives me fault for egr throttle control adjustment error, but i disconnect the vacuum hose on the egr and the boost solenoid /pressure converter shuts up, so i feel teh egr fault codes will go once i have replaced it. Still think Ive got and injector issue too. This car has been not loved at all. bit like your mates 5 series bud.

Hi mate thanks for your video very helpful, I just have question I got noise round my turbo like whistling or jet engine when I push my foot down, I change viscous fan but noise still there it’s coming after when my friend change glow plugs and I have exhaust fumes smell for long time on the same place of my turbo or manifold too , if you can advice me where to look for the problem will be great-full , my car it’s 530d E39’s 2002 , thanks very much for your Chanel on KZfaq

Hi have a 525d 2008 lci its got always rough start and somthimes wen cold need toi give it bit gas too even start it please waiting for answers what could be

Hi I have a X5 e70 I get a slight flicker on then idle needle on cold start up last about 3/5 seconds, if I switch on and try again it’s fine even if it’s cold , it happens once a day after sitting over a cold night

Hello Bmw Doctor, i have a problem I'm from Romania and i have a problem with my bmw e39 525d m57 engine! When is hot outside and when the ac is on the engine has a rough idle, when i accelerate the car it pulls ok no problem! I Inpa tested it no erorr! Please give an advice! The injectors have good values from -0.3 to0.4!

Hallo Mate i have a 325d 2008 and hi won't rev pass 4000 rpm... engine and gearbox run smoothly..it's automatic btw. And as soon i push the gas down... hi will shift to lower gear and it will loss all of the power and it will stay on 4000 rpm... any advice?

Hi plse help! My 530d only smokes (greyish diesel smell) after about 4/5 mins when sitting idling? And then moderate amout of black smoke when i boot it, its mapped but it never smoked when map was changed, it started months after so ive ruled out the map, i have no dpf or egr so a mate said the maf might of gone bad , so got an oem maf but havnt fitted it yet, could it be maf or have got any other ideas with the symptoms ive given. Its also a bit down on power when flooring it…apreciate any help, oh i changed the breather you mentioned but where can i get the better loo roll type you spoke of, rgds rob

Ive got an '09 635d, its misfiring and putting out a lot of white smoke - oil and water levels are ok and no codes - where should i be looking?

Would you know what would be causing the car to go into 'limp' mode? I have a feeling that it is the turbo actuator or MAP sensor maybe? It's a 05 525d, the car when usually 3 gear upwards would cut the power from the turbo at around 2 - 2.5k revs and this would cause it to run under power for the duration of the engine running. Once the car is turned off an on again it works normally until it goes into this mode, when in this mode no smoke is produced, got a fault code (3F57 - boost pressure plate (1272)) sorry for the long winded comment but thought you might know if it's the actuator for sure etc ( it has started to make the noise where it sounds like a alarm from the turbo area when car is off)

Boss you have to link up and recommend a garage that will check and change all the things you recommend for a price. It will be very helpful.

You do need a timing tool to lock up the timing chain to change pump I have the tool if you need it 😁

Can you help me with my car over teams/zoom? Alot of turbo sounds before 3k and loss of power. On 3000rpm the car goes as it should

Keep up the good work Dean. Very informative good quality video. You go through all the problems one by one, showing them perfectly. What can I say, man, I learned from you a lot!

Hi mate have a problem with my bmw. today when I was going suddenly the i-drive started to turn off/on the car no firing/power and gave me an error in the gearbox and abs. I know I have a 5th gear error but when I stopped the car and started it the codes were erased and the car was working fine. But today she did not want to start after this, and I put the tester and no errors came out only ibs. The oil in the Gearbox box has been changed because I see the new screws and filter if you can help whit an idea thanks I don't know what to do , because ibs , dde relay , transmission modul ...

Hi mate wondering if could help me I just plugged car in as was running abit rough on idle and got these codes 41AA and 4B10 the car is 330d e91 any advise Would be much appreciated

I have just purchased a 535d e60 as a project car, I have a lot of black smoke upon acceleration, it’s had an egr delete , swirlflap delete, and a downpipe so I’m guessing no dpf, previous keeper said it’s just had new small turbo and vacuum lines. My issue is the smoke and it’s very slow in low revs but does move when I’m higher revs, oil is black so obvs needs a service, anyone have any ideas what it could be causing this! Tia

My 535D has runaway symptoms is There anyway to come in contact ?

My 535d e61 2005 have loss of power when going warmer. It could also misfiring around 70mph... What could it be?

Where did you get that EGR replacement thing?

How reliable is the M57 high pressure pump

Great Video mate, i just watched it again!

You are so helpful and I greatly thank you 🙏

Black smoke on idle, black dust on tail pipe. Why is that on bmw x5 e70 3.0D

Hi my e39 530d have hard start when it’s engine hot .i change can sensor but noting different now garage told me I need to change high pressure fuel pomp

HI IV JUST BOUGHT A L322 LANDROVER 2004 TD6 IVE FOUND THAT THERE IS OIL LYING ON THE LEFT HAND SIDE OF ENGINE I WAS TOLD BY PREVOUS OWNER THAT IT IS A BREATHER PIE IS THIS TRUE

Hello mate just found your channel and it’s great to finally see someone that really knows there stuff. I have an e60 525d auto 54plate, had the dreaded broken exhaust manifold and nothing but running issues ever since!! I changed manifold and the car pulls off like a rocket... until you come to a stop or run at idling speed for any amount of time then the car loses nearly all boost and struggles to change up to the next gear??? Any ideas on what it could be?? Thanks

I see smoke sometimes when i push the pedal to the floor in my 530

Great video mate 👍was you going to do a live stream yesterday?

hello i have white smoke on start on 525d e39 2003 year and rought start about 5 esk.

I have a x5 e70 2008 3.0sd twin turbo I tried everything you suggested but still got rough idling and when I'm just ticking over it will start to smoke but no codes come up no lights on dashboard really would like advice don't kn where else or who to trust as been told so many things. Tried glow plugs and warmer, injectors, vacuum hoses, blanked Egr and swirl flaps, breather on engine, when your driving its fine just when you stop it's rough and when you start in the mornings if you turn full lock to drive it will cut out. Can you please suggest what I can try next.

What oil or grade do you rec? Of course I understand ll04 is best then as manual states ll01, 98 or acea a3/b4 but someone said c1 you can use or c something I read briefly. Also weight wise with these getting on a bit thinner oil like 0/5w or thicker as some people say bigger or older engines appreciate the heavier side like 10w40 or similiar to help with noise or heat? Newly subbed!

Would u know where the fuel pump relay is on 530d e61

Top vid doc having some of these issues myself I'm led to believe I have a fuel pump issue my gauge reads fuel but I end up running out could u spread any light on the issue cheers

Is the vortex oil breather if it’s blocked will it cause alot of blue smoke under revs and idle?

Good work, keep up the videos💪🏻🔧

Hey Doc, thanks for another great video resource to these engines. It really helps. I have a 2007 730D with the M57N2 engine. My car smokes a lot when idling only. When driving normally it has no issues but as it sits on idle again, like in traffic, it smokes again. The smoke is whitish gray in colour and there's a strong fuel smell outside the car. The car idles and starts up perfectly fine. Any ideas on what the problem could be?

I have a 2010 335d m57, car runs sluggish till about 3k rmps and then boost kicks in perfectly, vac lines are all new, charge pipes are new, still having the issue, I read something about the pressure converters. Do I have to fix the egr converter or the on above the turbo?

Hi everyone and the Owner of this channel :) I have Bmw M57 engine, model 525 M Sport with 3.0 L 197 HP/145 Kw. I give you all the details because i need to know what type of oil is for this engine..the car has 155.000 mileage on clock. Some people propose thick oil and others thin oil, therefore i would like to keep this engine as much as i can...so i need to know what kind of oil is the best for this engine. Thanks in advance and have a great day everyone :)

Hi there, my m57 sounds like a tractor and runs awful, is this something you have come across before?

Whats your thoughts on auto gearbox software..xHP flash map or bmw gearbox update? Thinking of trying the stage 3 xHP flash

White Smoking (Witthaut cooling issues) + Thinned oil = bad compression Black Smoking = Air leeks between MAF end intake valves such faults were in my m57n2 231 ps engine

I have a2007 335d just had white smoke from the exhaust could you help diagnose the problem ?

spot on mate, awesome heads up video

Awesome video

Hey Dean hope you're good. At 3:30 in the video you mentioned about the injector testing by unplugging them. Do you have any more information on how to do that. I've got a funky injector just not sure which one.

I have a x5 e53 and it will not start turnover ok

Hellow Beemer Doctor Sir, please advice I have a similar issue at around 5mins 17seconds of your video. Fuel leaks out of the return line! As a result the car cranks only and wont start, resulting in a code 4B90 Rail Pressure monitoring at engine start. Car also has Glow Plug Cylinder 1 up to 6 NOT PRESENT fault code which keeps reapearing along with 4B90. So please advice what could be wrong for the car to only crank and not start? Could it be fuel pump at fuel tank, fuel filter or the faulty glow plugs?? Car model BMW E60 530D 2004 year.

Hiya Dean great video your very knowledgeable. Do you have a garage to look over my e53 3.0d think you will identify problems very quickly thanks mate .....Dean

What size vacuum pipe are they

Hello, how can i contact you, i have a strange running issue with my e60 530d ? I'll pay for your time.

Hi dean how can I contact you?

Can I bring car to you man

You don't need the shudder valve as you map it out its useless

My bmw 320d is powerless

SORRY I MEANT PIPE

That intro music is 🤮love the vid tho.