Very nice vid but you have missed a few steps: - using block-off plates on the bottom of the EGR and on the exhaust manifold - fill up with 2K epoxy the 2 breathing holes on the EGR (they are leaking all the time...) - put a steel bearing ball in the vacuum hoe before reconnecting with the EGR - use a new O-ring between the EGR and intake manifold +1: it's nice idea to remove the whole intake manifold, clean it as well and reassemble it with new gasket.
@andrewknight68533 жыл бұрын
best engine audi made
@niko56463 жыл бұрын
You mean vw made
@sealgamech Жыл бұрын
You are close, it is in the top 3, but the best was the 1.9 tdi 1Z in E.g Audi 80, i had one, sold with 600.000+ km 10 years ago and still running 🙂
@kostelcioby19368 ай бұрын
Daca aratai si cum face motorul inainte si dupa, ne ajutai
@bulgarianpower2302 Жыл бұрын
Did the check light was on before you clean your egr?
@ricardoamorimrodriguescard56313 жыл бұрын
Como limpar a valvula EGR com parei especial será bom e para um Ford 1300cm a gasolina
@mariusdan50063 жыл бұрын
What head was he using to unscrew the bottom screws on egr
@adrianmihnea49213 ай бұрын
Salut mie imi face um zgomot cand accelerez in mers asa un fel haraiala
@ashleysimkin28104 жыл бұрын
Noticed ya didnt remove ya rubber gaskets when using chemical solvents on the egr 🥺. Not sure if thats good for them 🧐 crakin vid tho bro 👊🏻
@benmediahdstudio4 жыл бұрын
Thanks for your comment, actually it's not really a chemical solvent, it's just a light cleaning solution that's not affecting the rubber 😉
@mustang19424 жыл бұрын
Hi, is it possible that EGR valve can cause a car to just shut down while driving at low speed so I have to start again and to drop revolutions sometimes?
@benmediahdstudio4 жыл бұрын
Hi, I am sorry but I can't answer to your question. I like to make some things with passion, but I don't have to much knowledge about mechanics, and when there are big problems I go to the mechanic.
@tylerdurden2234 жыл бұрын
Have you a lot if smoke when it happens ?
@mustang19424 жыл бұрын
@@tylerdurden223 no there is no smoke anywhere, everything looks Fine from outside
@tylerdurden2234 жыл бұрын
@@mustang1942 check your crankshaft sensor and your camshaft sensor. When crankshaft signal is lost, engine automaticly shut down. Have you any engine fault with an ODB reader ?
@mustang19424 жыл бұрын
@@tylerdurden223 no there was no problem showing up when I connected the OBD reader, but Iam gonna look after those things you wrote
@jekistolica48082 жыл бұрын
Bonjour. Alors la elle va plu perde la puissance,ou bien koi.
@INFEKTO4402 жыл бұрын
What is, or why oil is leaking from those small air vent holes under that vacuum silver element? Blocked or damaged or old egr valve? I got audi a4 b6 1.9 tdi 74kw engine?
@leonbraun3632 жыл бұрын
Hey, I have a 1.9tdi 96kw. A minor oil leak is always possible and not terrible (usually caused by just having an old EGR). A larger leak is usually associated to a broken unit though