Adding to the above information it should be noted that being a 2t or 4t can also be significant when choosing a CDI. So an AC or DC 2t once determined will have timing issues if a 4t CDI is fitted .
@michaelthomas7884 жыл бұрын
All your information sucks that blue CDI box will go right into that rubber stretch mount
@michaelthomas7884 жыл бұрын
Some of your information is not accurate at all on the AC system the light will not turn on unless it's running because the stator has to be creating power in order for the lights to work so if you kick over your scooter and your headlights turn on and flicker it's an AC system and also your light will be very dim on idle and when you rev up your engine the light will increase in brightness also a Telltale sign that you are running an AC CDI also will run without a battery because it creates its own electricity to run Battery is for lights and other options alarm radio what have you they use the same concept on Dragsters that's why they don't have to have a battery or starter they started externally and once it's running it doesn't turn off unless you kill the fuel
@JasonBohl3 жыл бұрын
Not entirely true. My bike is an AC system and right away I replaced the cdi with the blue ac one. Later I installed an ignition switch, battery, regulator/rectifier, and a whole lighting system. The way I hooked the system up (made my own harness) all the lights work with ignition switch turned on without bike running because the power goes from the stator-coil-cdi-rectifier-battery. From there fuse box to lights. The rectifier charges the battery still and of course if I leave the headlight on for too long I lose juice in the battery and my system dies. However I can still kick it over.
@haroldgoodwin83922 жыл бұрын
@@JasonBohl same with my ac cdi gy6 go kart. I used a wire harness from a scooter and the head light circuit to power my starter relay. I ran a push button to the steering wheel and then to the starter relay. So if the headlights are not turned on the kart won't start. Its to keep the kids from taking it with out permission. Little simple trick
@SegaDisneyUniverse6 жыл бұрын
I had switched my stock for the orange CDI on my Peace Sports scooter about a year ago and when I hold the ignition and it starts right up with no hesitation. Not sure how long these last though, as it does take slightly longer to start up now. But it could be my battery, which I may need to replace soon. Edit 4/09/19: My orange CDI Still going strong, and had to install a bigger battery since I had a big bore kit installed a few months ago. I also recently bought the blue CDI, seems to not start my scooter as easily as my orange one, but I seem to get slightly better acceleration on the blue one. I'll have to see how long it holds up though.
@fernandovanderwatt26954 жыл бұрын
'm
@SegaDisneyUniverse4 жыл бұрын
@@fernandovanderwatt2695 Just so you know, I got rid of my scooter ages ago and got a new one lol.
@oldstyleanalog645910 ай бұрын
Bro throw all ur cdi.on the trash.ISE THE STOCK ONE
@gullahgeechee26996 ай бұрын
@@oldstyleanalog6459yea the stock last the longest! I had 2 blue CDI boxes and they blew under 3mths
@niloantonio3661 Жыл бұрын
all the 6 pin cdi on the table are all either AC and DC cdi, the power source makes them ac source(stator) or dc source (battery) ,
@jamieleigh53894 жыл бұрын
They say your headlights only come on when the bike is running if its ac, my headlights come on when I turn the key. There dim and brighten up when I start the bike. I replaced my cdi with a ac cdi and haven't had any issues. Its identical to the stock.
@JasonBohl3 жыл бұрын
Same with mine. I already had the AC cdi hooked up but later added a regulator/rectifier, battery, fuse box, ignition switch and a headlight and it doesnt need to be running but the key does need to be on.
@michaelthomas7884 жыл бұрын
the information on your headlights and scooters it will run the headlights because you're not creating power from the stator to power the headlights they don't run off the battery batteries just cranks the starter
@RellyOhBoy4 жыл бұрын
Fast forward to 2020...They are all half that price. My scooter is brand new 2020 BMS Prestige 150 and it has a DC CDI.
@DJeimaXe10 жыл бұрын
That blue CDI had made my 1st gear to feel like a 3rd gear. But I am of course; using a 3 electrode spark plug to a 93 octane gasoline. I weigh at 198 lbs on this 155 lbs 125cc bike. I believe that I was reaching 25 mph at a 1 second acceleration. ... Sigh, this strong @$$ CDI had destroyed my cheap ass plastic gas cap LOL;;; It was asking for too much air suction at a time.
@michaelthomas7884 жыл бұрын
CDI box has nothing to do with air suction through the motor you better go down and take a Small Engine class or something
@michaelthomas7884 жыл бұрын
CDI stands for capacitor discharge ignition
@shinigami117s86 ай бұрын
Have you ever seen a cdi cause excessive advance timing where it pings an engine when cranking?
@michaelhudson34453 ай бұрын
great video thanks for this.
@esmeben7 жыл бұрын
Very informative, thanks.
@michaelthomas7884 жыл бұрын
How much mechanic time do you have on a bike the some of your information sure does suck
@alllivesmatter57509 ай бұрын
GY6-125 ECU flashing 8 times along with my engine management light flashing 8 times.. Does and one know what the codes are and what fault it could be. Is the emu knackered. Cheers
@smartphonegamer67723 жыл бұрын
How much can the yellow DC one rev
@robertcarmona92128 жыл бұрын
Thanks for great info. Would you happen to know if Kymco's Super 8X 150cc is an "AC" or "DC"? I'm getting one and would like would like to upgrade as soon as possible.
@xXFinatotonneXx Жыл бұрын
I have a Mash bipop Scooter Gen1 2T, but my CDI is dead Where is this CDI today ? Generic ?
@michaelthomas7884 жыл бұрын
Enough to wear it if somebody can't get something to run to bring it to me
@KitchenCartel5 жыл бұрын
Can you connect a 6 pin bike with a 5 pin racing cdi
@michael-en4kq5 жыл бұрын
I have the same question cant find an answer anywhere
@its_that_1savage726 жыл бұрын
What’s the different between the different color cdi like red,blue,green,yellow
@dayanarodriguez61526 жыл бұрын
AC , DC or plugs
@michaelthomas7884 жыл бұрын
I've only been working on dirt bikes and motorcycles since 1991 I mean I'm no expert I know a little bit
@williamhaskellhaskell3162 Жыл бұрын
Do they have a timing curve checked with a timing light
@outmansahmaoui6323 Жыл бұрын
Thx for this video
@robertpc10010 жыл бұрын
I HAVE AN E-TON 50CC.I have read so much about how to tell difference between ac an dc.my scooter will run with battery unplugged.not totally true,it will not crank start without battery and light does not come on when i turn it on.but regardless when i crank it without battery headlight tries to cokm on even with switch off.weird.where can i get the link to where to get a dc high perforance on.thanks
@jseden5 жыл бұрын
Robert Andrews obviously it wouldn't estart without a battery.. what do you think powers the starter? He meant that it won't die if you disconnected the battery when running and you'll still be able to Kickstart if you have one. The headlight usually runs by default on these.. your light switch is probably for the high beam. What motor do you have?
@shawngixxer10 жыл бұрын
Hi. I own a 1984 riva 125cc 4 stroke,, would a high proformamce CDI help this scoot and could it hurt the motor? And do they make them or older scoots? Thanks
@carlosvillarreal64699 жыл бұрын
Saying the same shit everyone said already! I'm trying to find out how to adjust the DC cdi? How much should I turn the little screw on it, I heard it comes at 6° I want mine at 4° how left do I go? Anybody?
@nickkkthanks74067 жыл бұрын
is the blue cdi 5 pin worth using for my 140 stomp or should I use somthing differnt cheers
@guidosamson6825 жыл бұрын
We need to see the difference of all tge boxes on a scooter dyno test and compare the graphs and readings. To. My knowlege all boxen are about the same. Difference is just some fancy design and a rev limmiter. No advance
@jseden5 жыл бұрын
Yep.. mostly just hype bs. I got an orange one to try on my taotao and noticed no difference from the stock black one. Also from my understanding, there is no CDI that truly offers advancement.. in reality, it might retard by 350 deg and call it a 10deg advance.
@michael-en4kq5 жыл бұрын
i think i accidently ordered a 5pin cdi to replace a 6 pin is there a work around or buy a new one?
@rpdigital174 жыл бұрын
I believe 5-pin CDI-s are without restricting pin and will work fine.
@barryrodgers20672 жыл бұрын
Can a new cdi work once then not work?
@michaelthomas7884 жыл бұрын
On your information on the DC CDI is not accurate the wire that is disconnect is your kill switch trx300ex has 2 CDI 1 that is ac one reverse that is DC one for forward
@themtrider65307 жыл бұрын
I have a 6 Pin DC with rev limiter my Friends say that i have to cut a wire but i dont know wich one
@piercebenton71577 жыл бұрын
Generic on 2 Wheel's _ it should be a pink wire but I don't know about your scooter. I cut the pink wire on my scooter and it revs up in the 10,000 rpms but results may vary
@lancekippenbrock53076 жыл бұрын
I pulled a wire out on mine it still seams like it has a rev limiter but it goes a little faster especially down hill
@moultriemanicmechani6 жыл бұрын
Rev limiting is built in pink wire if there is one is for your tach
@ParwezAlam-ek8tn6 жыл бұрын
THE MtRider
@NathanKirby20016 жыл бұрын
You can cut the drestrict wire
@jobertcadag15188 жыл бұрын
Hi! If I have a DC CDI and my battery is drained I will not be able to run the engine even if i kick start it ? And how about my DC CDI motorcycle is running then the battery charging system fail will the engine stop and not be able to start after the battery becomes empty because the charging system suddenly failed?
@69buffaloriders10 жыл бұрын
how do you unplug the CDI unit for a 50cc Roketa scooter
@aA-lg1se4 жыл бұрын
Hi can I use blue cdi in 2 stroke 50cc moped thanks
@carlossanchez81354 жыл бұрын
Which I use for 50cc bt I put 72cc on it
@chriscruzjr92718 жыл бұрын
can i use the dc cdi for 150 cc in 250 cc motorbike?
@FuskyTheHusky818 жыл бұрын
niooooooooooooooooooooooooooooooooo
@AssaultOffroad8 жыл бұрын
I bought the yellow adjustable DC cdi for a 50cc atv but it won't start when it's plugged in. I tried messing with the timing but it still won't fire. Any ideas?
@zaelking7867 жыл бұрын
send it to me i will try it on my 200cc :D
@DrLove9114 жыл бұрын
Is your scooter DC fired?
@mikescomedyspecials68597 жыл бұрын
I have a 50 cc tao tao 2015,I looked at my cdi it doesnt have a pink wire to cut.what do I do
@SuperDaan106 жыл бұрын
michael ferriole blue wire?
@mxrider2strokebraaap547 жыл бұрын
Does these fit on a pitbike with 5 pins but square plastic clips?
@lancekippenbrock53076 жыл бұрын
Mxrider2stroke Braaap no
@bazookabharath7 жыл бұрын
hey can u please tell me how to wire a 6 pin cdi to my 7 pin yamaha ybr/ybx/yd 125 it has a 4 pin connector a 2 pin connector and a seperate black wire
@lancekippenbrock53076 жыл бұрын
BHARATH.V Kumar you can't if it has 7 pin
@gmplays26674 жыл бұрын
i think that the black wire could be ground xD it was 3 yrs ago but ok xD
@bazookabharath4 жыл бұрын
@@gmplays2667 thank you... was worth the wait I guess
@bullionbouncer50808 жыл бұрын
I recently bought the blue racing cdi but the 5 pin anyways my 110cc pit bike ran good for like five minutes and now wont start at all green light was on and attempts to light up when I kick it over I dont have electric start is this a problem or am I missing something?????
@static77337 жыл бұрын
cdi died
@jseden5 жыл бұрын
Is your stock one still good? If so, try it.. it not, just get a couple different one. They're like $6 on Amazon
@tuliszkam23937 жыл бұрын
Blue "New Racing CDI TZR50 is a shit. Inside is almost nothing. Look at photos from disassembly: postimg.org/gallery/3fzgi5moy/
@static77337 жыл бұрын
mine died xD
@lancekippenbrock53076 жыл бұрын
I agree I had two brand new ones and neither of them worked
@soydiana18366 жыл бұрын
Sera que pueden hacer un video sobre los cdi racin pero en español .por favor.
@syxxwilliams7 жыл бұрын
what happen if you use a dc cdi on a ac running scooter i did it by mistake an blow my head lights an gusge lights out is that normal
@roran-san7 жыл бұрын
lol i have the same issue, hows your scooter doing? :p
@syxxwilliams7 жыл бұрын
oh the wires was touching so i cut them an capped them together now its working finecheck the wires inside the connectors my was fray an touching so i cut them an capped them together an it works fine
@tebeardenkahboom16 жыл бұрын
You did not post the link where to purchase that adjustable CDI
@dayanarodriguez61526 жыл бұрын
ebay com you will find them for less than 10 dollars
@joshuaharrison93313 жыл бұрын
lol thing guy has no idea about electronics what a waste of my time
@jaysonburrows96196 жыл бұрын
I HAVE A DC KYMCO SUPER 9 50 AND A STOCK CDI BOX I BOUGHT IT WITH WIRES HACKED UP BUT THE BOX CONNECTERS WERE UPSIDE DOWN AND I DONT SEEM TO BE WIREING IT UP RIGHT ITS A BROWN CDI BOX WITH TWO GREEN WIRE COMMING OUT THE BOTTEM OF IT ........IF SOME ONE KNOWS WHAT IM TALKING ABOUT PLEASE REPLY
@Cjohn314 жыл бұрын
I have same super 9, sorry your comment is a couple years old but I can help if you still need
@silversniper42022 жыл бұрын
@@Cjohn31 i have a super 8 and yellow worded greate but wires was on one by one few fell out now i cant wire it back the same way wish there was a dia that was right to follow
@Cjohn312 жыл бұрын
@@silversniper4202 I found a diagram online somewhere it took alot of digging, i had my super at 50 mph on flat ground and never drop below 30 on hills, dude offered me 650.00 for it i sold it, i really miss that thing tho
@protectork98314 жыл бұрын
get a multimeter and test the cdi to tell if it is AC OR DC. all else is stupid
@jamest.50013 жыл бұрын
You can connect a bulb to the power supply while running, and put a strong magnet next to the bulb, if the filimen moves it's ac, if not it is DC😜 just in case you don't have any means to test for ac or DC,. If it moves back and forth, it's ac, it could be pulsed DC it would move only one way!
@christiehefferon41436 жыл бұрын
What would be the best AC box for a 1983 atc250r.
@realtundratrash6 жыл бұрын
Christopher Mcauley the stock one haha..... sorry I wouldn't trust much of what this guy says.... he doesn't appear to know much. BTW that's a cool machine, I have an 84
@christiehefferon41436 жыл бұрын
atc500x aye mate I got a cheap orange AC box of eBay and got a Ricks source coil for £18 of Amazon and she ran the best lad.
@muhamedajdini24317 жыл бұрын
who is the best and where are difference
@dayanarodriguez61526 жыл бұрын
if you scooter runs on AC the best is the no rev CDI, the orange, But be careful on reving your scooter to high, it can burn the oil fast due to excess of heat.. the blue one has limitations on rev maps to not force your engine.
@yashvendrasinghrajawat94815 жыл бұрын
I have 4 pin cdi I have 6 pin cdi how to install it
@kingtangy18709 жыл бұрын
someon help i got kymco agility 4t i bought the racing cdi and i have only 4 wires in total how do i connect it ??
@ROFLCOPTERS929 жыл бұрын
i have a pitbike with no battery, because its kickstart. no headlights or nothing. would that be AC or DC?
@salmanovable9 жыл бұрын
it's AC cdi , because it's supplid from the alternator
@ROFLCOPTERS929 жыл бұрын
Salmen Messaoudi ok thanks!
@diabolikberzebubu5 жыл бұрын
Ok one question i have big box cdi and i think its dc but the lights come on even if the engine its stop but also if i dissconect the battery the engine its not stopping all little cdi i plug in distroy the fuse...what in the hell its my cdi? Hahaha
@tdupcoco54485 жыл бұрын
U have a Dc
@bingisrinivas10924 жыл бұрын
AC CDI unit DC change hona hai
@stevenbuchholz54216 жыл бұрын
why not bouth i do
@tdupcoco54485 жыл бұрын
Bull shit I have a DC and I can take out my battery and the scooter still runs
@karirautio3 жыл бұрын
Of course, because the generator provides electricity. Or do you think, that you could run on battery power forever. You can not start the engine without battery.
@gnxtrem10 жыл бұрын
www.amazon.com/gp/product/B007IK1VWG/ref=oh_details_o07_s00_i00?ie=UTF8&psc=1 le sirve a un keeway rkv 200cc???????????
@try.again.82608 жыл бұрын
The "racing" shit is most stupid and funny product that I see!! Because it have FIXED advance curve, "maybe" working only for 2-stroke engines.
@feriddzajic91686 жыл бұрын
scooters have rectifier maaaan,so curent from alternator goes trough rectifier,then from rectifier in to electric system vhich is DC in every scooter,so CDI Must be Dc in every scooter...
@qwerto155 жыл бұрын
😂😂😂😂. Wow dude. Short circuits Volume 1 might help you buddy...
@qwerto155 жыл бұрын
Oh incase your too lazy, scooters have an AC generator for... the... cdi..... Yes the electric system it uses is 12volt DC (direct current), but you are wrong about all scooters being DC CDI.