EZ Go Fixed Weak Motor
Рет қаралды 19,181
3 жыл бұрынProblems with this EZ Go Marathon since purchased a few months ago. It turned out to be motor issues.
@Lj-ni9vt Жыл бұрын
Great job on the fix. Sometimes you just have to know how to make do with what you got.
@danielfarrell6661 2 жыл бұрын
the potentiometer is the switch for the gas pedal the reading is not from 0 to 5 ohms it is 0 to 5000 ohms
@tsrwakemaster Жыл бұрын
You have to use 2 wrenches on motor connections. If stud very corroded cut it off as soon as it gets tight
@OurClan100 Жыл бұрын
I'm no expert, but here's what the Internet says. "dielectric grease is an insulator and doesn't conduct electricity"
@ericstyer2890 2 жыл бұрын
We have same cart, same symptoms. I’ve replaced the FNR, Solenoid, no luck. Gonna check motor terminals and see how she does.
@justtinkering6054 2 жыл бұрын
Check my other videos. We ended up replacing the motor controller a few months after this video. It's been fine for over a year now.
@ericstyer2890 2 жыл бұрын
@@justtinkering6054 so you think it was the controller all along? What troubleshooting reference for the controller did your BIL have? Buggies Unlimited?
@justtinkering6054 2 жыл бұрын
@@ericstyer2890 I do think most of the problem was the controller all along. I think the motor stud was a minor issue. I'm glad we checked it and I'm really glad we fixed it. It could have turned into a major problem. I'm not sure what my BIL used for reference for the controller. I would start with cleaning and checking all electrical connections first. Do the simple and cheap things first. Then try to eliminate the expensive components before spending any money.
@tsrwakemaster Жыл бұрын
First step is check voltage to motor when throttle full
@macknumber9 Жыл бұрын
On a 36 volt system what should I see at the motor studs at full throttle? 36 volts at all 4 studs? Or is it split 18 on one and 18 on other? I have a1 a2 f1 and f2 terminals
@tsrwakemaster Жыл бұрын
Motor could be brushes, it’s a series motor
@tsrwakemaster Жыл бұрын
0-5K ohm (5000 ohms) It’s 0-5K not 5K to 0
@Ckktopa 3 жыл бұрын
Is it a thingamajig or a whatchamacallit....;-)
@justtinkering6054 3 жыл бұрын
Exactly!!
@normknott9676 Жыл бұрын
Invest on a LIGHT
Immersed
Рет қаралды 58 МЛН
JB Golf Carts
Рет қаралды 40 М.
Jack of All Master of None
Рет қаралды 127 М.
jamoloniy
Рет қаралды 903 М.
Kamaz tv
Рет қаралды 1,1 МЛН
Music HD
Рет қаралды 4 МЛН