Fiat Panda '11 gearbox transmission fluid change

Рет қаралды 93,384

7 жыл бұрын

This is a video demonstration that digs into a manual gearbox oil change on a Fiat Panda 1.2 petrol 2011 model.
Be extra careful on how you lift and stabilize your car!
As you see,
there are 2 bolts.
1 one is a female 12mm screw so you need a 12mm Allen or a ratchet with a male 12mm nut.
This is the fill screw.
Your car needs 1.65L of 75W-80 synthetic lubricant.
My manual suggests TUTELA ZC 75 SYNTH, but I couldn't find locally. So I bought another brand BUT at the specified 75W-80 viscosity. So check your car manual before you buy...
The 2nd screw is a small 8mm female screw that is located on the bottom & back of the fill screw. This is the empty screw and it may be tricky to find. You need an 8mm Allen or a ratchet with an 8mm MALE nut.
To pump the lubricant into the gearbox, you will also need a special hand pump.
*****
TEST results after change:
There is a big difference during shifts. It is like you have butter between the gears. Also some small but annoying sounds have gone away. My car has 37.000kms but as I bought it used I'd like to do a change just to be sure. Fiat suggests that you do a change at 40.000kms

Пікірлер: 43

@tasosyzf 7 жыл бұрын

thanks men after 1hour search i find the tap with your video

@helpingsociety4447 4 жыл бұрын

Thank you. that was good.

@dreamwisperer 4 жыл бұрын

thanks a lot my friend!

@michaelaustria75 6 жыл бұрын

Good job thanks so much

@dreamwisperer 6 жыл бұрын

you are welcome!

@SlowRb20s13 3 жыл бұрын

This is also the same for USA Version 2016 Fiat 500 Sport 5 speed Manual

@pdtech4524 2 жыл бұрын

Best to warm engine and gearbox first so a short drive helps, check it's not too hot before you drain it You can fill from above using a longer pipe and funnel, allow gravity to fill it if you have no pump.👍

@GCP81 2 жыл бұрын

very good video..i have Fiat Panda 2008 1.2. what brand is the new oil that you use ?

@freespirit3624 3 жыл бұрын

Hi! This is the same with Fiat Panda 2003.

@ThorRavnsborg 6 жыл бұрын

Thanks, that was helpful. I only needed to make sure where to fill and drain and that was very clearly shown but I guess you could have done that in a little less than 10 minutes. :o)

@dreamwisperer 6 жыл бұрын

thanks for your comment...its a great DIY and you'll be happy with the result!

@airman64 2 жыл бұрын

You seem to know what the job entails I wondering do you also need an additive?

@ThorRavnsborg 2 жыл бұрын

@@airman64 No additives needed. Just use a transmission oil with the right specifications.

@airman64 2 жыл бұрын

@@ThorRavnsborg Thanks

@beni1167 2 жыл бұрын

What oil was poured. Is the TUTELA 75W85?

@massimilianotamborrino8938 3 жыл бұрын

How much does it cost change on a panda the fluid

@nihonkokusai 5 жыл бұрын

Its 75w85 but, 75w80 will also work.

@Chris-xc3xz 3 жыл бұрын

That oil looked clean no need to change

@bluegreenish3394 3 жыл бұрын

True but remember oil can loose it's proprieties and you should change it every 100000km plus gearbox material piles up

@antagonistalion 5 жыл бұрын

Good video. Can you tell me the location of the fuel filter in this car and how to replace. Many thanks.

@dreamwisperer 5 жыл бұрын

not really sure.maybe inside the tank?make a search..

@Simon-rl5vz 3 жыл бұрын

Hi. What is the screw bellow the filling screw ?

@myapplemusic6760 Жыл бұрын

Yea can someone plz tell me?😢 bcz this screw is missing in my car just now admitted to a workshop. What can I do for this ? Plz plz help mee soon 😢

@efrenjrvaldriz569 4 жыл бұрын

hello sir.. is it the same also to fiat punto ii 1.2?

@dreamwisperer 4 жыл бұрын

I can't say that.maybe you should search the web

@selmighaith1831 6 жыл бұрын

Oil transfert Gear 75w80 or 80w90 ?

@nihonkokusai 5 жыл бұрын

75w80,85 or 75w90

@zigzag7194 4 жыл бұрын

Popped up as recommendation. watching this and my thoughts. What the hell are they doing. From all the years I've been servicing cars I've never known anyone to pump oil from the bottom of the car into a transmission box. 🤔🙈

@dreamwisperer 4 жыл бұрын

are you serious now or joking? How is it possible to pour the new fluid into the gearbox?the fill-in screw is on a very difficult to reach spot,under the car!

@michaelrich5501 4 жыл бұрын

There is a fill cap at the top of the gearbox but you have to strip out the battery to get access to it, if you have the pump may as well do it this way

@jannopilt7198 4 жыл бұрын

:D Why You trying add oil using "backdoor"? just remove batter and 3 screw bolt battery holder and You can see a gearbox oil cap!

@dreamwisperer 4 жыл бұрын

this is transmission and not engine oil change.the transmission is filled via the hole you see in the video!

@zigzag7194 4 жыл бұрын

I bet they had a look after you told them where the plug was. I've never seen anything like that in my life. They've got about 23 people going to do the same thing. Plus they'll have to buy a pump. When they should be buying a funnel. 🤣

@STRUCTURESPILOT 3 жыл бұрын

This is true, I found the plastic cap under the battery. Careful, it breaks easily. Its pressed in and the plastic gets brittle over time. Easy to fill with a long funnel. Or you could buy a 12mm allen socket, as shown in the video.

@cliffwoodthorpe7900 2 жыл бұрын

ANY car which has had its gerbox oil topped up should be left on a level surface, not on jacks, to allow excess oil to drain from the filling point. Otherwise, the gearbox oil seal may blow. New clutch time...