How To Remove NP231J Transfer Case Jeep TJ

Рет қаралды 42,293

5 жыл бұрын

Get a NP231 Rebuild Kit Here amzn.to/2EyQ7DT
In Canada get the NP231 Rebuild Kit here amzn.to/2SItj9J
Todays video is how to remove the Transfer Case np231j from your Jeep tj Wrangler. You may want to remove the NP231j transfercase for rebuilding or other modifications.

Пікірлер: 26

@SpudKai 4 жыл бұрын

So helpful as i'm new to working on vehicles. Thank you so much. Nice to see exactly how you jacked up the tcase :)

@77NWH 8 ай бұрын

Thanks for posting this video. I have the same year 03’ Sahara with the auto transmission as well. Your video is the only one with automatic. Saved me a lot of time!

@tristenkaiserlik5085 3 жыл бұрын

I have an 86 K30. Totally different transfer case but this video did help

@brycemaggio6144 3 жыл бұрын

Awesome, thank you

@jeremy8715 4 жыл бұрын

Would I need to do this if I’m only doing a SYE?

@richharp2729 4 жыл бұрын

So I have a 95 wrangler 4cy 2.5 with the 231 transfer case it's bad what other jeeps would be interchangeable

@ryansremark6983 2 жыл бұрын

Would the manual and auto trans be the same if it were the 241OR

@Hellwolf501 4 жыл бұрын

Why didn't you drain the transfer case first? Or is that just leftover fluid?

@theashrook6129 2 жыл бұрын

So, is it true on all Jeeps that the skid plate isn’t the only thing holding the transmission and transfer case up? There’s another bracket underneath? I need to replace my transfer case and was wondering about how to do it

@shamroccsher 3 жыл бұрын

Loved ur camera angles, quick and to the point. So many ppl dont get good pictures, but yours was very clear. Sadly, I stripped one of my top bolts, now stuck on that. Not sure if putting the other nuts back on, may help relieve pressure on the nut up top? Or does it matter?

@TestDontguess 3 жыл бұрын

get a helicoil and that will fix it

@murphtahoe1 5 жыл бұрын

Totally off subject of your video, but do you recommend redoing all of the power and ground leads with 2 gauge wire? By the way, your early videos on removing/installing the transmission mount and transfer case were super helpful when I worked on my TJ. I went with the Novak upgrade as well. This LS swap is going to be bad-ass when complete!

@TestDontguess 5 жыл бұрын

I would personally wire the vehicle according to the current being used.

@murphtahoe1 5 жыл бұрын

BSK Garage Thanks Jerry.

@ryzeds5016 2 жыл бұрын

So I have a 95 jeep Cherokee and a np231J transfer case , and we found a hole in the bottom of it kinda near where the chain is and was wondering what your thoughts was about it

@TestDontguess 2 жыл бұрын

Hard to say without physically seeing it or taking it apart. But if the chain is loose enough it will wear though the case

@danfeerst615 9 ай бұрын

I'm stuck on the last two bolts blocked by the catalytic converter. Hard to get any leverage and I can't break them free. Any recommended tricks or should I just remove the exhaust?

@ryanmullany8724 9 ай бұрын

me to no one talks about how fking hard they are to get to

@77NWH 8 ай бұрын

I used 1/4 ratchet with 9/16 socket. It’s tight but if you line it up just right you can break it loose

@larrynoname9340 2 жыл бұрын

Excellent video - thank you very much. Getting ready to drop my transfer case for some maintenance. I do have one question though and that is about the fluid (ATF) you show draining out between the transmission and the transfer case. I do not believe the two share fluids so this should pretty much indicate a bad seal correct - either bad transmission output seal or bad transfer case input seal. I hope that all makes since and look forward to hearing your opinion

@marcosderosa8492 Жыл бұрын

did you maybe figure out which fluid it was? i’m about to do mine soon and wondering if i should worry about my transfer case or transmission leaking fluid and which to refill

@larrynoname9340 Жыл бұрын

@@marcosderosa8492 on mine - my auto transmission output shaft seal was bad when I dropped my transfer case so I had to replace it as well