The dreaded flashing injector light symbol - some solutions
Пікірлер: 90
@telboyofpeckham3 жыл бұрын
A bit of a tip from my mechanic mate. While you're driving & moving, turn the ignition off for a couple of seconds, then turn it on again, light goes out, limp stops & turbo comes back on. Then be really gentle with the accelerator. It will come back on again, usually when going up hill on mine.
@Motorhead2you2 жыл бұрын
My 2005 35C S13 2.8L started the dreaded flashing injector light after a rough kickback startup after refueling, Trouble for the next 180ks with intermittent periods of no flashing .Cut to the chase I TOOK THE SIDE COVER OFF THE ROCKER COVER to investigate the injectors,this is easy and no Tools are required .I started unpluging the cable /plug from the number 4 ,the engine didn't change its rough idle, then pushec it back on,then took off number 3 no change either in rough idle, However when I pushed it back on, the engine ran nicely. CONCLUSION/Solution it was just a poor physical connection to the pins of number 3 injector..I pulled it off 2 more times and pushed it home to challenge its connection.NO PROBLEMS. This vehicle has only done 168,000ks (I used a test lamp grounded at one end to test signal to each injector all were without fault ) .
@nigelfielder73682 жыл бұрын
Thanks for this video very helpful I purchased a 02 plate 2.8 yesterday from a auction in Norfolk with a 4 hr journey back to Yorkshire I checked over the van everything checked out fine and off we set . By the end of the industrial est the dreaded red diesel injection light came on and went into limp went i took my foot off the revs .I started to gear down steadily trying to use the momentum to try and drag fuel thru this seemed to work as the engine would fire back up fine and set off again. This happened every time I took my foot off the revs fast . So to combat this I had to keep some revs on while changing gear . Once in top gear the van drove fine most of the way back . Its obviously this is why it was put in the auction . But overall I am happy with my purchase its the chance you take buying over the Internet the engine and running gear are all fine so its just this teething problem ive got to sort out . I will reply with how I get on Any update comments on your attempts to sort this issue would be appreciated
@khushbushah51402 жыл бұрын
How did you fix Nigel? I have the same problem. Did you manage to fix it?
@thomaskulpa82857 жыл бұрын
Yes they are worth money. You need one serviced regularly. I had one 2002 with 165k I had gear box and clutch check and only seal on gearbox replaced. Rear axle seal may leakbut you can buy o-rings for 5 a pair. Cambelt with water pump replaced and diesel tank & injectors cleaned.Common problem are brakes ... you need to bleed it and make sure no piston seized (all brake pads holders lubrificated where needed)... they tend to collect sand and water so corrosion is blocking movement. Some parts are not expensive (non original). Cheaper to replace than Mercedes... and I have very little rust only behind each wheel arch compare to rusty Mercedes.
@trevorbyron94482 жыл бұрын
Try this as it may be a likely cause of injector dash light flashing. Bleed you fuel line ( metal pipes), as they have air in them. Get someone to turn over ignition whilst you go through every line leading to injector. As they start you open( with spanner) and quickly close. Keep doing until diesel spills through each pipe ( till you find the culprit). Your engine will start
@doughambone60292 жыл бұрын
thanks heaps for the wisdom, I will apply all of these common faults, fingers crossed.
@garthrichert52562 жыл бұрын
A late comment indeed, but thank you twenty tons for your helpful video.
@richardbaines98703 жыл бұрын
Many thanks ...similar problems up big hills. Thanks Richard Newcastle NSW.
@svroysjoy55383 жыл бұрын
just got this problem myself
@daveleeparry36033 жыл бұрын
Big help I will check these things out thanks DLP
@oldnick9232 Жыл бұрын
My 2002 daily 13 injection warning light came on, terrified me, turned out to be a broken brake light switch. 10 days wait to get factory service, half day there, and $300 in fees. I hope this helps out. PS no limp mode occured.
@ErrtuZarathos3 жыл бұрын
My fathers Iveco has the same problem. It comes when driving full out and keeping throttle pedal down. If you keep releasing it up ones in the while about 10-15sec intervals, red injector light don't come up. Now it started to have problems to start. We got new prime pump and tested it out. When turning key to power on, pump starts for 10sec no probs.. we tested pressure form fuel filter manifold and pump gives about 1bar pressure and after pump stops, pressure drops instantly. I don't think it should drop pressure.. isn't there back pressure valve? Or could pressure pump piss pressure through?
@martinakantorisova5035 ай бұрын
thanks fixed very handy video
@morandy88medias5 жыл бұрын
Hi. I had that same injector sign flaring when tried to start.I used startgas a few times and it stat. After that it's start with no problem😀😁
@greaterdriveways92782 жыл бұрын
I have a 2007 iveco daily 50c15 3.0 had an injector replaced will it need coding? As problem is still same, Thanks
@220274mark3 жыл бұрын
I have the mk4 and its cutting out when you accelerate hard. Also blowing shit loads of black smoke. Put it on diagnostics today(sunday) and its come up fuel pressure sensor. Changing that first thing tomorrow morning. Will reply with diagnosis.
@desertrose51604 ай бұрын
My IVECO VAN 2012 35S14 had an EDC light on when the engine lost power, any idea why?
@YANDEX30V4 ай бұрын
Helloooo Anybody here. Just done a carbon clear out Iveco 2005. Injector and key code. Tries to start then dies. Unplugged the battry, and it works OK.. for a short while. Then I'm bck to square one .. eginning to regret tge hydrogen clear out..mechanic was quite brutal revving her up..as soon as a male friend came to watch he'd go fairly gently. I dunno..this Iveco ain't nothing like my 98 tranny
@fazalsubkhan45377 жыл бұрын
hi I had this stupid injector light flashing and all it was a pressure regulator cencer it goes behind the pump on right side of the engine cost new 77 pounds perfect now
@columbaheena33506 жыл бұрын
fazal subkhan Hi, was urs the 2.8?
@jay-hv6mc5 жыл бұрын
hi, ours comes on when the engine gets warm after about 10 mins? was this the same with your or was it permanently on ?
@toffeesvideos7 жыл бұрын
Hey Seb, thanks for your thoughts, it's weird, sometimes mine is fine but then a little mis always at tickover and the engine dies and on comes the flashing light. if i remove the solenoid and plug it straight back in the van starts as normal. i'm hoping now that it could be a sticking injector mainly because i think thats easier than replacing the HP Pump..!!
@Motorhead2you2 жыл бұрын
Take side cover off 3 clips if you haven't unclip cable to injector and reconnect ,it solved my problem I had 400ks of poor performance running on 3 cylinders ,fixed it when I got home after all sorts of mucking around with filter change etc
@jay-hv6mc5 жыл бұрын
Hello Seb, what do you mean by the light not being on permanently? Ours comes on after about 5/10/15 minutes once the engine heats up, but once the engine is off and cooled it starts up fine not in limp mode? Do you have any idea which tip of yours it could be? Thanks
@Truckdriver00074 жыл бұрын
The truck iveco 2006 is not pushing when it gives the gear,
@aidanduffy34073 жыл бұрын
Did you get fixed mate i have same model year?
@stevechandler64535 жыл бұрын
Same problem, stuck on the side of the road, have no idea what to do, lost all speed (in France)
@mikevanvuuren29865 жыл бұрын
Apologies for the ignorant question, but doing a diagnostic test not help in giving a clearer idea of the problem cause?
@mikevanvuuren29865 жыл бұрын
I ask as I've replaced a lot and just wondering whether diagnostic test will help
@matthewcooper95943 жыл бұрын
Did u find the problem in the end as my iveco only does it when hot
@jonathanchipeta36823 жыл бұрын
i lost my keys to my iveco daily 2.3,made and reprogrammed the new key but it has no pulse.do i need to get a new computer and does it come with the key
@ishmaelmwalilino56777 жыл бұрын
I have Iveco Daily 3.0 , 50c15 of 2009, but has really given problem solving it. For everything I have tried but nothing is happening. We changed ecu and bsi but nothing working. What can be the cause
@hesterlarge70266 жыл бұрын
hi did you get your van sorted
@jay-hv6mc5 жыл бұрын
Also, which bit do you put in the fridge ? the bolt or the sensor??? ( sorry if this sounds painfully stupid!)
@tommywagner962 жыл бұрын
Sensor
@neon1285 жыл бұрын
Hello. what is that light right next to the injector light ? the yellow one ,on the right side? it turn's ON when i get over 3000rpm, and I don't know what it is.
@tommywagner962 жыл бұрын
Air filter clogged
@paulstephenson3100 Жыл бұрын
Mine came on tonight managed to get home ,but now won't start
@prettyspring871xd92 жыл бұрын
Fixed mine by pulling the injector relay out of the fuse box, blowing in it and putting it back in again.
@nigelfielder73682 жыл бұрын
Do you have the number location for the relay so I can give this a try and tick it off the list of subjestion
@YANDEX30V Жыл бұрын
@@nigelfielder7368 why does no one answer ..I'm paranoid I've bought 2005 now..its sat 5 months..I'm better with my old 98 smiley..eeek simple but van not start.
@melkelton8 жыл бұрын
Did you get to the bottom of it? I have a similar problem
@plumbteam8 жыл бұрын
Loose injector wires.......
@NaughtyGoatFarm7 жыл бұрын
Sebastian Hibbert thanks for your video. I have just purchased a 2003 Iveco daily 40c13 truck. 2.8L diesel. Seller told me about the injector light coming on a couple of times a year. Atleast now I have an idea what it might be if it happens to me.
@Norfolkgreenlaner7 жыл бұрын
I have similar problem comes on only after 2500 rpm if I release the accelerator pedal it used to be really bad to the point that it would come on after 1500 rpm accelerating but I changed the throttle pedal and now it only comes on when I release the pedal and cannot RE accelerate until revs drop below 2000rpm or 1500 when it's cold any advise gladly received
@NaughtyGoatFarm5 жыл бұрын
I have the same issue. It only happens to me when I am going down hill and revs increase over about 3000rpm (engine breaking). Goes into limp mode unit engine revs reduce then its fine.
@kianshilton100510 ай бұрын
Did you figure this out? Many thanks, Kai
@danzelwasherton1234 Жыл бұрын
I have the injector light come on randomly, no loss of power but the speedo and rev counter both go mental then stop working
@backumanu97934 ай бұрын
What’s was the problem ?
@YANDEX30V4 ай бұрын
Wht was the issue???tia
@Oken-1986-m Жыл бұрын
Здравствуйте горит форсунка машина не заводится мигает до этого на подемах мигал когда нагрузка утром завёл что то застучал выключил после того не заводится.
@user-mw8wp8cw7d8 ай бұрын
hola solucionaste xq a mi me hizo lo mismo
@john812868 жыл бұрын
I can't rev mine past 2500-3000 rpm or it cuts out and the injector light flashes. Thanks for giving me a few pointers.
@adamgibson25975 жыл бұрын
Mine doing this any help
@mikevanvuuren29865 жыл бұрын
Mine comes in and out when accelerating at higher speeds on motorways. Or when pushing over 3000rpm. Already spent so much cash replacing the common problems
@mymckeon2 жыл бұрын
Ever fix this problem ? I have the same
@kianshilton100510 ай бұрын
Did you get a fix? Many thanks, Kai
@grahammason64663 жыл бұрын
Did u sort problem
@michaelhackett3024 жыл бұрын
When replacing a fuse box do you need to have to reprogram it in thanks
@QBallRacing3 жыл бұрын
no
@adriansararu16863 жыл бұрын
when I drive over 60 miles the light comes on and I lose the power. what can be? thanks
@grantbateman35803 жыл бұрын
Crank sensor m8 done loads with symptoms youre saying wont always throw a code up either
@paulhaworth18243 жыл бұрын
I had same injector light come on with it refusing to start/run ended up being engine/immobiliser ECU refusing to recognise key couldn't get key reprogrammed by iveco as van wasn't coded same as iveco records ended up having to replace ECU cost £1400.00 apparently happens a lot after speaking to numerous people that've had same problem
@fazalsubkhan45377 жыл бұрын
hi I a problem were if I'm driving my iveco daily is fine but when I let go of accelerator it looses power and injector lights starts to flash
@yusufsueb51066 жыл бұрын
fazal subkhan I have same problem on my iveco if got got any help let me know plzz
@Lambertkleinjans6 жыл бұрын
Same problem. I got it diagnosed & told I needed to replace all injectors... which is an expensive job, trying to find out whether it could be something else and/or how to replace the fuel injectors myself
@grahammason64663 жыл бұрын
Mine starts on tow start only
@fazalsubkhan45377 жыл бұрын
Hi what is the problem what's it doing
@jacquenoir78767 жыл бұрын
Are these vans worth buying???
@plumbteam7 жыл бұрын
Jacque Noir yes - drives like a car
@merlin13466 жыл бұрын
the 3.0 which is the one I have pulls like empty even when loaded, A1.
@linasauto38863 жыл бұрын
Hmm
@janek21325 жыл бұрын
tere mul sama probleem mis videos vilgub sama tuli kust viga leida mul või millest alustada iveco daily 35s13
@tarmolukk7065 жыл бұрын
Tere Kuidad ta sul käitub. Me ühe probleemse mootorigs korralikult vaevleme.
@tarmolukk7065 жыл бұрын
Mis sümptomid on
@CarlosCashaki38 жыл бұрын
I think I have just bought this van
@plumbteam8 жыл бұрын
Not this one you haven't. I still have it!
@CarlosCashaki38 жыл бұрын
Ah Yeah I figured that out after I posted... but I have just bought an iveco daily luton, and the one thing the seller said as he soled it to me was that the injector needs to be changed, but wasn't too clear about weather it needed just cleaning /new seal, or a new one fitted. And After watching your video i'm guessing that maybe he didn't know exactly what was wrong.
@andypreston15247 жыл бұрын
IVECO.......It Vibrates, Everything Comes Off!
@wantedmdakama45725 жыл бұрын
Andy Preston my iveco gonna miss what things to do
@220274mark5 жыл бұрын
Jesus christ.your video is absolutely frightening.
@liamstewart13916 жыл бұрын
Speak up man
@janek21325 жыл бұрын
otsin ise vastust mul ka vilgub ja käima ei lähe
@janek21325 жыл бұрын
räägitakse mingist klapist kui ise otsin inimest kes oskaks aidata ja kellel on veel selline probleem olnud
@johnmclaughlin1946 Жыл бұрын
Please can you super mechanics help me . I have an 06 daily 2.3 it's starts runs for a minute the injector light comes on and it cuts out but will start no problem again .somethings telling me fuel pressure but this is my first iveco and I'm clueless .thanks for reading