KTM 390 Adventure | removed resonator box, exhaust component from Ali

No video

KTM 390 Adventure | removed resonator box, exhaust component from Ali

Рет қаралды 16,833

Jaroslav Mihalco

Күн бұрын

removed resonator box from exhaust system
exhaust component: m.aliexpress.c...

Пікірлер: 56

@AlexandruGaal 6 ай бұрын

Nice video showing the procedure. It's one of the best upgrades for the Ktm 390 Adventure

@wfodavid 6 ай бұрын

I did the same but also punched out the cat. sounds nice not too loud and actually runs fine.

@micro_cuts2832 Жыл бұрын

I bought the same one, a little bit loud but not to much, in 4000km i didnt have any trouble with police, i have shorts in my account for those who are curious of how it sounds attached and warmed up

@Daniel-tf5jm Жыл бұрын

Did you get a check Engine Light or something?

@micro_cuts2832 Жыл бұрын

@@Daniel-tf5jm no

@pjmac71 Ай бұрын

What was the goop used at the attachment ?

@pakit0400 Жыл бұрын

I did the same process as in your video, but there is a smell of smoke, but everything is well sealed, I have the following doubt: does there have a gasket or plastic between the engine and the exhaust pipe? Because there was none in mine plastic

@jaroslavmihalco6708 Жыл бұрын

Hi, tighten the lead on the engine head to 20NM. For the rest, I used exhaust mounting paste, as in the video.

@PedroMurilloChaves 4 ай бұрын

Hello. Excellent video. Have you noticed any increase or decrease in fuel consumption after this modification? Greetings from Costa Rica 🇨🇷

@jaroslavmihalco6708 4 ай бұрын

No, nothing 🙂

@19Ander86 5 ай бұрын

Dobrý den, také jsem odstranil rezonátor. Zaznamenal jste prosím nějaký rozdíl ve spotřebě? Nyní jezdím za 3,8 L dříve při stejném jízdním stylu tak o tři deci méně. Nainstaloval jsem ale také FuelX. Průběh motoru je lepší, ale spotřeba je stále i něco vyšší než s origo rezonátorem. Mám model 2022. U mě řezat nebylo třeba, ale objednával jsem trošku jinde na AliExpress, byť díl vypadá skoro stejně. Díky za inspiraci. Zvuk je nyní jako s laděným výfukem.

@jaroslavmihalco6708 5 ай бұрын

Dobry den, ja som hned v jazde spozoroval lepsi zatah v nizsich otackach, samozrejme aj hlucnejsi zvuk vyfuku co mi samozrejme neprekaza. Co sa tyka spotreby tak tam nevidim rozdiel, okresky 3 - 3,5l a dialnica presuny mi obcas vybehne aj 4,5l

@19Ander86 5 ай бұрын

@@jaroslavmihalco6708 Díky moc za odezvu. Určitě je to tak lepší, nějakou váhu to taky ušetřilo navíc zadní tlumič teď není namáhán teplem. Určitě mrkněte na ten FuelX. Nově má zastoupení pro Evropu ve Španělsku, přišlo to do týdne, přidá to taky nějaký zátah od spodního pásma. Já plánuji ještě nějaký filtr sportovní, možná úpravu Airboxu. S pozdravem Tomáš.

@talhagunes91 3 ай бұрын

Hi! Did you manage to fit the cat gasket in? I think I see it on the video, but I was unable to fit the midpipe with the gasket. It is a snug fit without it. Thanks for the video.

@jaroslavmihalco6708 2 ай бұрын

Hi, not if you mean bigger gasket. I used sealing blow paste

@talhagunes91 2 ай бұрын

@@jaroslavmihalco6708 at kzfaq.info/get/bejne/nK9gac6dyrOZn2Q.html you are applying paste not on the original gasket then. The color of that part is same as the gasket with that lightning. Additinonally, if you use spacers and position your midpipe through the middle while tightening, you will have less noise at high rpm range.

@stuartreddiex Ай бұрын

Have you got the link for this exhaust on Ali?

@jaroslavmihalco6708 Ай бұрын

@@stuartreddiex Hi, link is in the description under the video

@alonzoanaya6424 7 ай бұрын

Tanks a lot, please could you explain to me about the 3mm cut, was it necessary to do it? 2:33

@jaroslavmihalco6708 6 ай бұрын

The exhaust parts would not touch each other. There would be a gap at the ALI exhaust elbow joint. -possible leakage, -leakage of exhaust gases

@davemlnr 4 ай бұрын

Nazdar, vo videu ten dolný srôb ako si dal von čo drží rezonátor, lebo mňe to naráža do držiaku stupačky?

@jaroslavmihalco6708 4 ай бұрын

Ked sa sruba povytiahla. Podarilo sa mi ju dostat do takeho uhla, ze sa vysunula cela a nevadil uz drziak stupacky. Najlepsie je odmontovat aj zvod z hlavy motora a demontovat to cele naraz, ako len samotny rezonator.

@deoptographer923 Жыл бұрын

Brois their any problem after fixing this

@WOSBiker Жыл бұрын

Nice video. I also have a KTM 390 Adv. I am very happy with it. What is it and where do you get the “filter” you put inside the new exhaust pipe. Thank you

@jaroslavmihalco6708 Жыл бұрын

Hi, what filter do you mean?

@WOSBiker Жыл бұрын

@@jaroslavmihalco6708 At minute 3:30 you can see a part inside the exhaust pipe.

@AlexandruGaal 6 ай бұрын

@@WOSBikerthat one is the 2nd catalytic converter (not a filter, it burns unburnt fuel). theoretycally it's ileagel in most countries to remove it, or to drill it.

@xy404 7 ай бұрын

what is that paste you are putting in there ?

@jaroslavmihalco6708 6 ай бұрын

it is a standard high temperature paste for sealing exhaust joints

@packfan1946 Жыл бұрын

Where did you get the upper crash bar????

@jaroslavmihalco6708 Жыл бұрын

Hi, is SW-Motech

@juanicoct1 6 ай бұрын

is 100% necesary cut the 3 mm?

@19Ander86 5 ай бұрын

I did the same removal and it wasn't.

@deoptographer923 Жыл бұрын

Is their any engine or pollution issue with this after installing

@abominacja47 Жыл бұрын

Only noise pollution :) Resonator box is designed to cancel out sound waves so the bike is quieter, therefore Euro compliant. Also, since there's less back pressure it may reduce cat efficiency and bike may run hotter since it's already lean on mixture. I would install it along with new fuel mapping just to be safe.

@teddybowker7309 Жыл бұрын

This is not a cat delete ??

@jaroslavmihalco6708 Жыл бұрын

Thank you, video title fixed

@rossi9209 Жыл бұрын

Do i lose my warranty if i change to a full exhaust ? I got The 2022 model

@wildflower7574 Жыл бұрын

Same situation and yes lose warranty. Check with my Ktm dealer

@jaroslavmihalco6708 Жыл бұрын

The warranty on my motorcycle has expired in 04/23

@deoptographer923 Жыл бұрын

Bro i also do the same but it seems very louder how can we reduce the sound

@GMperformanceOWNER Жыл бұрын

You deleted the baffles but want it quieter?

@irideaz390 Жыл бұрын

Nice video! What is the weight savings? Performance improvement? Also what is that blue thing on the exhaust?

@jaroslavmihalco6708 Жыл бұрын

Thank you. Weight saving is possible 2kg. The blue thing is a minimalist protector from Ali

@19Ander86 Жыл бұрын

Ahoj. Zaznamenali jste nějaké výrazné změny ve zvuku a průběhu výkonu? Dík.

@jaroslavmihalco6708 Жыл бұрын

@@19Ander86 Ahoj, lahsie sa rozbieha z nizsich otaciek. Zvuk je hlbsi, ale zase nijak nevadi pri vacsich presunoch

@19Ander86 Жыл бұрын

Super, díky za inspiraci. Uvažuji, že bych do toho po záruce šel.

@avib3799 Жыл бұрын

Did you notice a change in the sound?

@jaroslavmihalco6708 Жыл бұрын

Hi, is a slightly deeper sound

@ghora43 Жыл бұрын

is it catalyst inside?

@jaroslavmihalco6708 Жыл бұрын

Hi, Yes, only the sound resonator is removed

@demonsync57 Жыл бұрын

So, to remove the resonator... you cut to the part where you have spent some time and now there are 2 persons there.. ok.. now i see i have to unscrew a lot of things

@jaroslavmihalco6708 Жыл бұрын

Yes, I didn't expect that either. But it's harder montage