Wow!! Just Wow!! The local Mercedes Benz dealer quoted a minimum of $2500 - $4000 to repair the pan roof on my boyfriend's 2003 MB C230 kompressor. They also refused to repair the sunroof recall, due to the pan roof having an open / close issue. I found this video, spent .40 (that's forty cents)and ten minutes, and the repair was completed, tested, and reassembled! Someone buy this man a beer for making this SUPER HELPFUL tutorial on how to repair this issue! A million thank yous!

I was quoted $2660 to fix this. Haven’t used my pano roof in like 2 years. Happened to stumble upon this... bless you sir

You are a life saver! My pan roof finally stuck open today... We are going through a hot dry summer here in South East England, I messed around with this swearing and cursing then found your tutorial... It just started raining as I fixed it! Cheers mate!

Fixed my 03 c230 coupe. Ordered the motor and I don’t even need it anymore 😅 god bless

God bless you for that video! Yestarday in the service told me that it will cost 225 euro to fix this "BIG" problem!!! Today i follow the instructions and now sunroof works perfekt. Thank you!

I just tried this out and it worked. I was very surprised becaue I didnt think it would work on my vehicle. Such an easy fix! Thank you for taking the time to make this video.

Just bought a 2008 E550. Fixed the pano roof in about 15 minutes. Your are the man...... will definitely be getting some grease to keep it working smoothe.

Great write up! My motor noise is all gone. I left the factory plastic bushing on the Torx head, then 5/16” lock washer then 1/4” flat washer. When I removed the assy the SOS button didn’t come off. The biggest challenge for me was re-installing the mirror. As a previous commenter mention, use some sort of lube as its very difficult to load back in. I used hand sanitizer to lube it up but it requires a lot of force to put back in. Especially with the limited space. The SOS button assy should be installed after the mirror to allow for easier push ability when re-installing the mirror.

Great fix, it worked for me. Thank you so much for the video and detailed description. Repair did take less than an hour.

Thanks! I followed your instructions and was able to close the sunroof which was stuck open. The washer didn't make the grind go away, but I was able to crank the motor and close the roof. I noticed that if I pushed up with the screwdriver on the motor crank, it would go in a bit and the grind would go away. But as soon as I let up on pressure, it would pop out again. Also, I couldn't figure out how to make the shades return to closed. Anyway, awesome video! It saved me hundreds!

WOW Can't be more pleased with the instructions to make this repair on my '06-W211 Pano. In my case I used (2) flat washers stacked and a 1/4" dia. o-ring. Not possible to get to the other T25, to much obstruction. Tightened up the other smaller Torx scews.Tested before reassembly and no chatter. Getting the mirror back was tricky. I put a little grease on the socket area & spring ends, worked the spring with a pair of channel locks then had to fix the mirror in place before resetting the control panel. Got the mirror spring & socket in place then pushed with a flathead screw driver to over come the spring tension and it popped/locked in place. Then went the control panel. After all back together "re-programmed the sunroof" and all working normally. MB dealer would have charged a ton of money to do this, SPECIAL NOTE: Be extra careful with ribbon wires while control panel is hanging. THANKS ID Parts!!!

You're amazing! Worked like a charm on my 2008 E320 Bluetec with Panorama and shades. Strange thing happened: car was sitting outside in super cold, and the sunroof tilt motor activated itself and tilted one side partially up. Would not go down and buzzed as in video. Finally was able to follow your steps, with some trepidation as I was afraid of breaking the plastic. A lock washer in the first bolt not completely tight got the sunroof tilted back into position immediately! But the shades would not work. Scratched head. That helped. Looked in owner's manual, thought perhaps they were out of time. Tightened a bit more - and they started working like they should. Big smile. But getting the mirror back in place . . . grrr. Having to go look for a second pair of hands to try tapping it into place while I hold it angled in . . . Thanks again!

Fantastic video. Thank you guys. Fixing the mirror back was easy!!! Just get a dead-weight hammer and a big, long bolt. First fix the control panel back in place for room, put a little grease roundabout the mirror socket and the edges of the spring. Finally set the mirror in place, use the long bolt to hold it firmly with one hand while you use the other hand to hit firmly but gently on the head of the bolt till you hear the click!!!

Congrats to this very good documentation! Is this also applicable to the moonroof of the W251 (R-class)? best regards from Germany, Stefan

Just fixed my E63! Thank you for sharing this information!

Thank you .. we followed this procedure for our c180 and it worked like a charm. Thank you

Great great info. Thanks. Would partially opening of sunroof after closing be of the same cause? Thanks

Fantastic. I was nervous about this but dove into it on my 2005 e320 pano roof. I used 2 M 8 size spring washers on the one screw and it did it. Second screw on the left looked difficult to take out and I then forgot to try. Bought a little MB grease for the rails and all is smooth. Thanks a bunch for the great video.

How do you access the second bolt you mention? The one in the back right under the headliner

Wow, Bro you are the best. I watched another video stating to pull down the roof lining and all sorts to remove the spin disc motor and add a washer on the back of the pink disk, wasted my whole day yesterday, I was so disappointed. Then I saw you video, and thought no way can it be that Easy. Today I went my local hardware store and picked up a couple of washers and was praying for results. 20mins later,,,,,,,, I'm A happy chappie, changed one and got movement no noise at first then it done it again so I added washer to the other side and hey presto a working pana roof, just ordered merc lubricant and oil to complete the job. Massive Thank You. You A legend.

I just fixed mine following your video..... due you're awesome!!! Next part I need I'll use IDParts thanks!!

Man U have gained a subscriber and customer. My 05 e500 did this grinding popping off track thing tonight. I googled “panorama sunroof Mercedes broke” and it took me straight to the video which was the exact same model as my car and the exact same issue. Followed it step by step and works perfect now. Only thing I would add to the video is to mention on the re-install to put the mirror back first because it was a pain for a few minutes to get back in. Thanks for the video and for making it semi professional instead of some kid using his iPhone shaking everywhere and talking for an hour before he got to the main part

I’m so glad I saw this video. The dealership wanted to charge me $3,300 for problem. They told me I needed a new motor and tracks. Followed the steps in this and fixed it for about 12 cents.

Does this go for the 2003 Mercedes e 500 sport the one with the panoramic sunroof? Mine is recently having issues stuck open and grinding when try to close

Its not very clear what your doing to the new bolt and washer. In what sequence are they being placed?

What a money saver you are! Mine stuck open and it was starting to rain! Covered it up and saw your video. Again thanks a million!

For those asking where the washer are sold, I got a set of washers that comes with different diameters and thickness. You'll be able to find one that fits more than likely.

Do you now where is the relay for sunroof on c240 .and ligth around the sunroof . Tks Piro

My sunroof doesn’t open at all, I just her it cranking attempting to open but won’t budge. Will this fix the issue?

This just saved me ab a grand. Went to Mercedes dealer and they gave me grease for free.. THANK YOU!!!!

I had the same problem, did your steps and it worked. thank you so much

nice video ,great job ,does it work the same on the 2006 R350 panaramic roof

This video was beyond helpful! Thank you so much!!

Problems began with grinding noise. Was able to close roof but passenger side wont completely. I replaced the grommet which eliminated the grinding noise and shade screen now opens and closes smoothly. However, attempting to open roof, driver side lifts but stops. I noticed the motor moves and the mall piece rotates. Video he mentions changing grommets on two bolts but on,y showed one. Will I have to remove panel to reach second bolt?

i have duel panaramic roof for 08 e350 the front on works but the rear does not is there anything else i can do or is this also it is starting to sag how do i fix that

How does water leak in the sunroof control area?? I have a g500 and some water dropped onto my transmission shifter after raining.... Are there certain problem areas with the sunroof? Thanks.

what other bolt did you unscrew? That's the only thing I don't understand.

Do you have a video on the regular maintenance that should be done to sunroof? How often, and the grease you to use? Thank you

Is it the same on w221

When it's making the grinding nose, does the sunroof also not work? Mine is stuck open and is now making the grinding noise.

where to buy these washer bolts please sir

So do you use washers for both screws?

I did it on my 2008 E63 and it work, so glad I saved 2k, thanks for the video!

Excellent instructions, fixed mine. thank you for sharing.

Thank you so much for this tuto, so helpful!!!

Small advise, you will be having problems putting back the mirror. It’s a pain in the ass. Put back the mirror first and then the whole pannel, then you will have more space and will be able to see everything.

This video is a lifesaver I will be contacting the dealerr tomorrow and I will be giving him a heads up I know this is the issue because when I put pressure on the panel I got it to close it made the grinding noise and it went slow but it did close I did not reopen it I knew the motor was good but I had a feeling it had something to do with pressure or something being loose because when I would press my hand on the panel hard it would close thanks a lot this was a perfect video

Thanks you saved me money and an uncomfortable summer!

Had the same problem 3 times changed the motor even the rail $6000 wasted money . Recently had the same problem then took the car to repair the motor out side the company repaired it with $100 and works excellent so it’s the motor this video is excellent no issue again smart professional video . My recommendation don’t waste money with dealer any more . The panoramic sun roof always can be repaired.

Hey so I tried this, it got the sunroof working a lot better, no grinding, and it actually closes but still wont open. I think my sunroof may be off track or something jammed?

I screwed up so now I have a permanent sunroof everyday 💩

Hello. Could you please tell me where you recommend getting the washer from. Thanks!! Will this work for 2008 E350.

If I could upvote more, I would. 5 minutes, 56 cents, and a pack of M8 washers, solved my problem. Thanks!

Thx. Is this the same for an R-Class Pano roof as well? Also what size spring washer did you use?

Results from this fix on a w204 c250? Thank you all!

Is there difference about normal sunroof motor and panoramic roof motor? Or is IT the same ?

So helpful! Fixed my issue for less then 45 minutes

Hello i have a problem with a mb c 280 w204 2009 sun roof. Do you think could be the same problem. ?It open and close but by steps meaning push de bottom star open the stop continue the same. When finally you complete opens it grinds or sound horrible Any ideas

Thank you I just fixed my s63 amg sun roof it’s little harder then the e class but I got it done

Can I use any type of grease ?

Can you tell me how to do this on a 2008 S550, thanks?

urgently !! plz where are those washers and bolts sold ????

what size washer?

Greatest YT video of all time

Is the e class the same as the s 350

Now thats good helpful DIY. Thank you!

Tried the procedure that's on your video it worked for awhile and it went back to making that grinding noise again. Do you have to put the washers on both of the screws or jus the one that's bad

THx for the great video... my roof on my '04 kompressor coupe got stuck open and grinding ... the washer solved the problem.. only issue is sunshade will not close .. is it a programming issue?

This 100% worked. Dealer quoted me $5000 to fix! Two random spring washers and 20 minutes.

SORRY, where can I buy this washer?

I tried this and it is STILL making the noise? What size washer is needed and how many per screw?

Hi, my dad has a 1998 Mercedes E320 (W210 base model/4-door sedan). The sunroof won't slide back and makes a clicking noise if someone tries. The sunroof opens and closes up or down, but will not slide back...can you help? Thanks.

Wow thank you so much...saved me a fortune.

i have a problem with front sunshade anyone knows how to dismantle it? the guide that pushes the shade forward is broken. Can anyone tell me about it or even info for the roof model and type

Hello, That was a informative Video. Thank you very much.

Your a Genius! 30 minute to fix on my 2003 C320. Mirror Didn’t Need to be Removed btw. Thank You So Much! :-)

That fixed mine thank you so much !!!!!

Great video, I just experience this today and with pull apart to repair!

can u post a video for the 2004 kompressor Coupe sunroof?

I have the same problem, the rubber is completely gone, do I need to purchase a new one?

What size spring washer should I use?

Thanks I did it like you said works awesome thanks again

mate I start to love my car agin :)))))) thanks

What is a spring washer as you don't put it close enough to the camera to see. Is this a lock washer?

Thank you very much, this fixed my issue

You rock! You just saved me a sh*t load of money!

Hello my friend I'm a Mercedes w 211 also I have a problem with the roof is suspended and is currently open to the top just like your car which is in the scene and I have tried like you did but the key remains rotating but the roof remains open Do you have facebook or watch me send you a scene to see Can you help me

Do u have a shop in ny ??!

Had to try this on my 2005 w211, but it sadly did not work for me :( I feel like there might be a bad grounding somehwere in my car tho, because whenever I click the sunroof button, my interior light dims. But if anyone know's another fix or where to check the grounding for the sunroof/interior lights, please let me know :)

For me sadly but it didint work. I can open the roof just fine but when i need to close it wont work :(

My car is 2006 e55 with the panoramic sunroof doing this. I will give it a try to this fix before buying a new motor!

My Rclass Pano Roof has stopped working altogether 😢

Hi Sir, my sunroof is doining nothing, what can be the problem?

Yay! It worked! Thank you so much ❤💙💜

Excellent job.. top man.. ⭐️⭐️⭐️⭐️⭐️

Try it and work perfect for me , thank you sir

Can't wait to attempt. Been search for over 3 years and I haven't found anything this helpful but again hopefully it works for me as I haven't tried. My issue started when it was able to close. Used the tool to close manually but never worked again and motor made the exact same noise. I have pressed the motor button many times out of frustration. Did I damage the gears?

Thank you for info, I did close my roof, but other side of motor can't fix it, please tell me what to do, also mirror can not put it back, show me trick to do this two things.

Thanks for saving us money.

Thank you, I’ve done it