MK7.5 Golf R : Bleeding and Flushing Brake Fluid (Fluid Replacement)

Рет қаралды 20,924

EVERYTHING cpo (@Vaarticus; @go.fast.r)

2 жыл бұрын

This is the final video in this three part series. This is the last thing we need to do before going on a test drive and bedding the brakes, which I covered in part one.
Here is the Motive Power Bleeder I am using:
amzn.to/3lCe5DQ
Unfortunately, the cool trucker pee bottle is sold separately:
amzn.to/2Z5Mymw
Here’s that neat little brake checker tool: amzn.to/3E0VYzL
Here are the rear brake pads I installed: www.fcpeuro.com/products/audi...
Here are the rear rotors I installed:
www.fcpeuro.com/products/audi...
Here are the rear hoses I installed:
www.fcpeuro.com/products/audi...
Here is the fluid I am using:
amzn.to/3BYZdFY
Here are the carrier bracket bolts I replaced:
www.fcpeuro.com/products/audi...
Here are the front brake pads I installed: www.fcpeuro.com/products/audi...
Here are the front rotors I installed:
www.fcpeuro.com/products/audi...
Here are the front hoses I installed:
www.fcpeuro.com/products/audi...
Table of Contents:
#motul
#zimmerman
#ferodo
#stoptech
#brakes
#golfr

Пікірлер: 38

@Zakw17 Жыл бұрын

This is the best bleeding/flushing video I have ever seen. I did this for the first time in my wife’s car last year and had questions mid way I found myself search for, you answer them all in this.

@thomaschung9310 2 жыл бұрын

I subscribed. I can't believe how awesome ALL of your videos are. Keep them coming!

@shawnoen1029 2 жыл бұрын

Always remove as much old fluid as possible from the master cylinder reservoir before adding clean fluid. Makes the flush much faster.

@jasonriesbeck3165 2 жыл бұрын

How much fluid did you require to complete the flush? Great video, thank you!

@GTiz4Ever 2 жыл бұрын

Super vids on braking. Quick question. On the Ferodo info page it states that street driving may cause certain vehicle platforms to squeal. Have you experienced this? Thanks so much.

@TheDsantander Жыл бұрын

This was useful today!

@mjk6152 Жыл бұрын

Great video. Where would I find the directions for a mk7.5 gti? For what brake to start at and finish at.

@ohhgee3234 10 ай бұрын

dam you just saved me so much money thank you man!

@EVERYTHINGcpo 2 жыл бұрын

Sorry. I noticed I made a mistake when I said I was “starting with the front right”. I was at the front left, actually. I clarified this soon after, but thought I’d throw a comment in here.

@game4alaughman Ай бұрын

Should you not also do the clutch slave at the same time ??

@GamerplusMore Жыл бұрын

where do you get your manual? im guessing thats not the regular owners manual because it doesnt have that detail like what side to start on or pressure needed

@aysmen89 Жыл бұрын

Hello, with what pressure need to bleed?any ideea the values from the manual?

@Superduperloopo Жыл бұрын

Where did you find in what order the different calipers need to be bleeded?

@zumik83 Жыл бұрын

There are 2 VCDS BASIC SETTINGS in regard to this procedure. 1. Brake bleed 2. Fill/bleed brake system Are those irrelevant ?

@Avram42 Жыл бұрын

Where did you find the bleed order? I assume it'll be the same order for a mk7.5 GTI but I'd rather see it in print. 🤔

@DubbaDaveski Жыл бұрын

Oh boy, my experience with that motive bleeder has been hell. First it was leaking at the gauge. Had to figure out how to create a tight seal since tightening it more did nothing and it nearly sheered the back nut. Then once I fixed that leak, it held consistent pressure. Once I put the fluid in and pumped it up to 30 psi, not 2 min into checking if all is good, it busts the line off the cap and it's spraying brake fluid all over everything. Had to get some hose clamps and wash the car on jack stands immediately to hopefully mitigate any damage to my paint.. Finally got it done. But it was a multi parts store and large cleanup endeavor.

@DubbaDaveski Жыл бұрын

Your guide def helped and I appreciate your thorough steps. Just wanted to head some caution on the Motive bleeder.

@ryantornai5753 Жыл бұрын

lmao damn man that sucks. Next time don't put fluid in just pressurize with air and add fluid when the level starts to get low in the MC. Much less messy.

@xDoyle514 5 ай бұрын

15psi is the max recommended pressure for bleeding the brakes with the motive. After doing a corner pump it back up to 15.

@Drinksfromtap 2 ай бұрын

⁠@@xDoyle514 the VW service manual specifically says to use 29 psi and the motive manual says not to go over 20 psi “unless specified by your service manual.” So for this car 29 is the right number and consistent with both VW requires and Motive allows.

@thomaschung9310 2 жыл бұрын

Have you thought about doing the brembo macan caliper upgrade. I know it's not a true BBK, but you can get 2 piece Rotors and the macan calipers are inexpensive

@EVERYTHINGcpo 2 жыл бұрын

I have. I just haven’t looked it to it far enough to make a decision. So many other things in the works right now! :-)

@hoselrocket2001 3 ай бұрын

Since this works through a pressurized system, is it necessary to keep the car level? I was considering just removing one wheel at a time and using one jack stand.

@bretgtimk7968 Жыл бұрын

how many bottles did you use?

@AlanCooney 2 жыл бұрын

Great video Sir! But 30 psi sounds a bit high? I note your instruction manual says 2 bar, but worry this might cause master cylinder to blow?? I always thought you should not exceed 15 - 20 psi??? Any more thoughts on this?

@raymondphan3806 2 жыл бұрын

Not higher than 10 psi

@dopiaza2006 2 жыл бұрын

@@raymondphan3806 The VW manual says 21-29 psi. They probably know what they're talking about.

@coryjordan2368 Жыл бұрын

@@raymondphan3806 2bar for bleeding < see abs pump. its in the manual. it does not require vcds or obd-11 actuation but needs to see 29-30 psi to ensure all air is out from the ABS pump.

@johnsandy6976 2 жыл бұрын

Can anyone please confirm to use 10 PSI or 30 PSI. I am doing a bleed tomorrow and replaced pads and rotors. Not lines. Is 30 PSI still necessary? Thanks!

@EVERYTHINGcpo 2 жыл бұрын

I may be a little biased since this is my video but I recommend 30 psi for the reason I stated in the video. Not sure where you heard to do 10, but 30 worked for me without issue.

@tysoncolley8110 2 жыл бұрын

Is it possible to do this without removing all 4 wheels?

@Michael_Crist 2 ай бұрын

It is not necessary for all 4 wheels to be off the ground for this, you can do 1 wheel at a time. But you do want the car level to be sure you don't have too much or too little brake fluid in the reservoir.

@msntung Жыл бұрын

How do you clean that bottle after that?

@Zakw17 Жыл бұрын

Simple green

@caferacers2211 2 жыл бұрын

Hey my man, where did you find the repair manual? I keep trying to find a proper copy of one but I can’t seem to locate a legit VAG repair manual for my car. I have a 2019 GTI se usdm

@MblCJluTEJlb Жыл бұрын

PM me. I have a mk7 (2014 and up, it should work for you as well) service manual i can share.

@andrejbanov1266 Жыл бұрын

@@MblCJluTEJlbHi. It is your manual OK for Golf Variant 7 2014 1.6 TDI?