✅ VOLVO V70 2.4 ECM-6805 Boost Pressure Control Faulty Flow & EGR Remap EDC15C11

Рет қаралды 29,520

3 жыл бұрын

✅ Dyno Tested ChipTuning files individual for You!
✅ DPF, EGR, Swirl flaps, AdBlue Solutions
✅ Stage 1 + ECOtuning
✅ Phone📞+371 29919194 📲WhatsApp
✅ Skype ➡️ Modrix
✅ Mail modrix@inbox.lv
✅ Прошивки для чип тюнинг + Volvo Прошивки DIM + ICM

Пікірлер: 19

@gheorghinacov6008 2 жыл бұрын

On the Euro 3 D5's, as you got in the video, the EGR is electronically controlled by the ECM. The EGR vavle sits over the EGR cooler right next to the exhaust manifold.

@mihaodmojce5103 3 жыл бұрын

Legend, pliz continue with sharing the knowlege in a easy mehanic way! Greets form brick owner

@liamhollin8265 10 ай бұрын

Thanks for sharing this, she'd a light on the subject. I believe these cars are capable of being tuned to beat porche boxers.

@tommyaleks100 2 жыл бұрын

Great video. I don`t get it, why cap off the EGR, just fix the damd thing instead, no problem after this. Clean it or change it, don`t take short cuts. You will also end up with wrong Co2 % on tests. There are a reason for it to exist.

@welle69 3 жыл бұрын

Hey guys, nice solution!!! Can you also show how to delite the software in the egr??? Would be great! 😎👍

@theperkule 3 жыл бұрын

hey what type of diagnostic equipment are you guys using? :-)

@bjoernandersen8287 2 жыл бұрын

So did you need to do any modification with the EGR valve or change it?

@Rockys1989 3 жыл бұрын

I dont get it. Mine does the same thing. You said when egr normaly working there should be nothing coming out so when should egr valve open?

@user-yn1mn8hi3x 3 жыл бұрын

эта ошибка указывает на передув турбины, вся проблема в электромагнитном клапане управления вакуумом, который управляет геометрией турбины

@markostevanovic6539 2 жыл бұрын

Hello,great vid.I have exact problem with my S60 Volvo with 96Kw.Did you close egr permanently?Can you shiw us how you re program ECU?Will i solve problem if only block egr mechanic?Thx for help

@Mohammed-Kamal 2 жыл бұрын

hello, waht's the system scanner and software used in this video ?

@FeatJoZy 2 жыл бұрын

Ja volvo s60 d5 120kw ir nočipots un atslēgts egr ir jāliek tā plāksnīte metāla priekšā tam egr?Man ir tā pati kļūda.

@A.Vasiliauskas 2 жыл бұрын

2bar is to much? I think 1.3 is max

@A.Vasiliauskas 2 жыл бұрын

I gues all you need is to clean egr system and problem will solve it self.

@edepillim 2 жыл бұрын

Hi Modrix. I have XC70 AWD 2006, D5 diesel. I have real problem! My EGR valve has been blocked out and capped off. The cat converter taken out. The car goes really well for 3 miles then l hear a air gushing noise from the engine and when l put on more acceleration the engine hesitates then goes off like a rocket. The problem gets worse as the journey goes on. Several mechanics have failed to cure the problem. In the last few months it has had a new turbo actuator, new inter cooler pipe and inter cooler, née mass air flow sensor. The engine has been properly Serviced including all filters. Six years ago the engine was mapped to boost bower to 215 bhp Any ideas would be greatly appreciated. Andrew

@Sparky_Sct 2 жыл бұрын

On an ECU or electrically controlled EGR, you usually cannot just blank or cap off the EGR without getting it tuned or mapped out of the ECU.

@edepillim 2 жыл бұрын

@@Sparky_Sct The egr has been both mapped out and capped. I did get an after market maf sensor but have been told l have to get the genuine Volvo part. The dash is now showing many warnings including brake failure ( yet everything works 100%). Apparently new wheel speed sensors should fix this.

@warrenatkinson9294 Жыл бұрын

@@edepillim You cannot cap of the egr on the euro 4, remove the blank and drill a 10mm hole in the center to allow some gas exchange. The egr valve is also used to dump boost pressure into the exhaust system.

@edepillim Жыл бұрын

@@warrenatkinson9294 Thank you. I took the car to a turbo specialist. Nothing wrong except that when a new actuator was fitted over a year ago, the parts were not coded to work together. This has been rectified and l no longer get this problem. A fault is detected with the MAF sensor. But this does not appear on the dashboard.