NO SPARK on your Polaris Sportsman? Let's troubleshoot it!

Рет қаралды 13,474

Titaniumman Garage

Күн бұрын

I'll show you how to troubleshoot a no spark or one spark no spark issue and show you how to fix it.

Пікірлер: 33

@ls2005019227 2 жыл бұрын

Thanks for another great video! I've never had/seen this issue (yet) but enjoy watching you troubleshoot/repair.

@Caseusfette 2 жыл бұрын

Loving all the video's. You have given me a crash course on how to fix a lot of Polaris issues, which is a good thing because I have 5 of them in my Garage right now! Thanks so much for continuing to make these. 🙃

@TitaniummanGarage 2 жыл бұрын

Right on!

@donwilder1476 2 жыл бұрын

i have a98 polaris sportsman 500 engine breaking system.put carb.fuel pump,fuel filter ,fuel shutoff spark plug ,ran 30 sec then quit,removed black wire on both cdi and reverse limiter and throttle shutt off switch,still ran for 30 sec then quit,now put ebay cdi on same short run then quit,had spark until it quit,3 carbs and 2 fuel pumps and 3 weeks later , finally purchased used coil would not run tested coils ok used coil had bad coil wire but good boot,mine had good wire bad boot.swithed everything around and now it almost throws you off machine on take off with no hesitations.i watch your videos and have used some of your information thanks for doing these

@TitaniummanGarage 2 жыл бұрын

Awesome. Glad to help.

@The_Native_wolfAK Жыл бұрын

My kill switch is bad. What do I do already tried by passing it, and the cdi is new, my killswitch has bad harness connection and has some cuts on it

@lookoutmountaingarockhunte1300 2 жыл бұрын

Thank you

@donwilder1476 2 жыл бұрын

the spark plug boot has a fuse/resistor which can have intermittent spark or no spark

@paulmuzik4523 2 жыл бұрын

Do you buy cdi box of ebay/amazon or you go for something more solid like Ricks motorsports. I need to buy one so advise is appreciated . Thanks

@TitaniummanGarage 2 жыл бұрын

I dont do either. Unless its polaris. I buy used ones. It a new polaris brand if I can get one cheap.

@mattroberts8806 Жыл бұрын

I am working on a 2001 Polaris Sportsman 500 HO. I am having a no spark issue. I have unplugged the black wire from cdi box and it fires right up no problem so I replaced the kill switch with a brand new Polaris kill switch and now back at ground zero. I have replaced all Components dealing with spark and Still having the same issue. Since then I have put all Polaris Components dealing with spark back on. Any help would be much appreciated thanks.

@TitaniummanGarage Жыл бұрын

If you used the china aftermarket stuff it's more headaches. My guess is it's the cdi. But check your wires going to the kill switch. If they are green by the plugs your gonna have issues. Clean all your grounds too.

@meldeer6253 Жыл бұрын

heres a good one for you .. 2002 polaris 500 ranger.. New cam interminiting spark . but fired up ran like never be for it was scary fast came home backed it in my garage went out the next day no start cranks over NO SPARK!!!! coil show's its grounded replaced it 3 different coil... But crank it over with a probe on coil wire from CDI it flickers like is pulsing ... but no spark ... CHECKED Every wire on the CDI Box NO Power to CDI Box ????? why ... ALL I WANT TO DO IS SELL THIS THING I WANT IT GONE AND WANT MY MONEY BACK ON THIS THING any help would be great...

@JerryLa-jv5dx Жыл бұрын

I am working on 2004 sportsman 50 ho early model A04ch50AC, no spark or very week all ohm and voltages are to speck trigger, stator, igniter coil, all clean grounds. Coil was bad so replaced it.Gets 180 peak vdc from cdi box to coil but crappy spark, all timing marks line up good, 90 psi compression good. Just want to get it to fire up using starting fluid. 1 burned wire coming from ingtion switch just got hot replaced it all other wires good. Finaly replaced every thing stator, cdi, coil, voltage reg, ect. Kill switch checks out good but bypassed it, throttle kill adjusted right. Any help would be good. Also need to know if maybe it is because it dose not have a speedometer in it. I have worked several 400 & 500 never had problem like this!

@TitaniummanGarage Жыл бұрын

Speedo isn't the problem unless there is an issue with the wiring going to it. If your 4x4 didn't work or it didn't light up. That would be a problem with the speedo. To me it sounds like you have hot wires touching somewhere. did you use aftermarket electronics? I have had issues with them. cdi bad after 2 starts. run stop kill switch bad after a week. also do your wires look green when you unplug the kill switch. hard to diagnose without seeing it. Keep in mind power goes to the key first, then the kill switch, the speedo is in the middle somewhere, then to the cdi and rectifier.

@JerryLa-jv5dx Жыл бұрын

@@TitaniummanGarage ok i will retrace power to all switches in that order, had china cdi when i got it did put a second one in, 4x4 wires are not even hooked up the wires have been cut coils test good, i think someone poured a quart of oil in stator housing pretty sure stator was not working right even tho it tested good. Pull start pully and guts were ground in to little pieces. Don't think the crank seal is bad that why i want to get it to fired up incase i need to pull motor and rebuild. There is no speedo in it at all its missing. Where is a good source for parts that is not china junk? Some green in plugs, cleaned all connectors with vinegar and electrical contact cleaner. This thing is mess. Ps your videos are great lots of good info !! Thanks jerry

@TitaniummanGarage Жыл бұрын

@@JerryLa-jv5dx Check out my latest video. Pull the flywheel. I bet the pickup coil or the magnets in flywheel are broke

@SA88D Жыл бұрын

❤

@tom73055 Жыл бұрын

So how much did all the parts cost to repair this Polaris?

@TitaniummanGarage Жыл бұрын

120 bucks

@jaimerosales5281 2 жыл бұрын

I put a stator on my 99 335 and still no spark. Disconnected black wire from switch and still no spark. Waiting on a cdi from eBay to get here

@TitaniummanGarage 2 жыл бұрын

Just beware of the china cdi's I've had bad luck with them.

@jaimerosales5281 2 жыл бұрын

@@TitaniummanGarage I believe it is a china cdi. What was your experience with them like?

@TitaniummanGarage 2 жыл бұрын

They fried right awwy

@danielanaya7813 2 жыл бұрын

I don’t understand you changed all those parts and it’s going to be the kill switch , the stator might have been good and the cdi if fine if it runs without kill switch wire usually (black+white)

@TitaniummanGarage 2 жыл бұрын

I pulled the cdi off a old polaris. It could also be bad.

@TitaniummanGarage 2 жыл бұрын

I tested the stator with an ohm meter. it was shot.

@offthestreetsandinthecreek7294 2 жыл бұрын

99 ranger in background 🤔

@TitaniummanGarage 2 жыл бұрын

Yup. Thats my toy. I like to start off the video with something that says Polaris.

@offthestreetsandinthecreek7294 2 жыл бұрын

@@TitaniummanGarage I got a ole 99 runs great . Hardly use it anymore just sits . Every once and a while I rip it around the house . Needs some brake line work. But I don’t go very fast . Probably one of my most reliable machines

@shadedevold5440 2 жыл бұрын

If you hold over ride button it will spark! If spark is on and off! Got my overtime button is ziped tied down!

@TitaniummanGarage 2 жыл бұрын

@@shadedevold5440 That's funny. I did that once. I think if you pull the black wire on rev limiter you dont have to do that.

@shadedevold5440 2 жыл бұрын

@@TitaniummanGarage I did that didn't make a difference even tryed new cdi boxes and Only way it will run is with rev override pushed in! It's weird! Even replaced rev limiter and regulated! Oh well runs good! At least don't have to hold the rev over ride for 4wd in reverse! Have you ever run into where the front hub seal rubs a groove in the hub sleeve? The fuild leaks out! Ran into alot of that and replace hub sleeve! Got becareful when getting a replacement some are aluminum and need the steal sleeve for magnetic coil to work!