I agree with others on here I have researched this issue with my 2013 3.5 for a couple months so frustrated with this truck it's hard to even look at it. I'm on my third motor and had to do full timing set $5200 for that and a couple injectors a year and a half after putting the third motor in. This is the best video for diagnosing this under boost p0299 condition. Thank you.
@brandonclay3363 Жыл бұрын
This was the best video on diagnostic on this issue I'm currently dealing with same thing on my 3.5 16xlt thank you I will try all of this before it goes to the dealer
@jeromehaver73312 жыл бұрын
Wish there were more people out there that put some valuable info out there. Kinda glad only this kinda stuff happens to you. Kinda kidding, but so hard to find any videos out there, that maybe you do not think so, but can save alot of us out here time and money. Most videos give you bits and pieces, like you said.
@AD-dw6cb2 жыл бұрын
Gotdamn, what a series of battles. Custom problems there, bro. And hey not many more satisfying feelings than identifying a mechanical issue you’ve never experienced before. Well done 2015 F150!
@_willalexander.882 жыл бұрын
I don't know how many times I said wtf... only to me. They need to design a better gasket. And I'm about to install my hpfp/lpfp to run e85 so I really didn't need this to happen to me. Glad the turbo isn't blown though.
@youcanfindrace Жыл бұрын
I have a 2019 f150 5.0 and I am learning about engines and what not. Some very valuable information you just dropped all over the place there my guy.
@GHOST-ey9ee15 күн бұрын
Man you can tell on your face it was not a fun time lol ..great informative video man ...im having problems with my 2015 2.7 289,000 miles ..but mine is the pressure valve just cant keep a good ole ford down 🤘🤘🤘
@wyomingcowboy5012 жыл бұрын
Great troubleshooting techniques from a power plant tech! The most helpful was when you remove the air intake pipes to the turbos to get an idea if you had balanced air flow being generated going into the turbos. Also, an original owner of a 3.5 eco with 239,000 miles. Only engine issues, water pump @ 175,000 miles, plugs and coil packs. Change synthetic oil ~5,000 miles and these engines will take care of you.
@jghall00 Жыл бұрын
Tell that to my blown head gasket and failing turbo manifold. I blame it on towing. But it's ok. I'm going to upgrade and make it a 550 HP beast.
@tnutty1612 Жыл бұрын
@@jghall00 what were you towing that caused that? Just curious because im looking to get an ecoboost.
@jghall00 Жыл бұрын
@@tnutty1612 A 7k bumper pull travel trailer. Get a warranty. Reliability with Ford is hit or miss. I was told my failure was rare, but there's still the cam phasers and warped turbo manifolds to deal with (not rare). But when it works, it's great.
@planetbern2 жыл бұрын
Whoah great job and great informative video. I want to add this turbo to my 2.7 F150.
@843cuh92 жыл бұрын
Same bro idk tho I hear they start having allot of problems after upgrading turbos
@sarahw78562 жыл бұрын
Man that sucks, It is a lot of work for that repair. I was watching you tube to figure out my 2015 boost issue and found a charge air clamp loose and hose disconnected.
@scottishjohn88672 жыл бұрын
Was you gauge not registering?
@garyrichardson78506 ай бұрын
Appreciate the video dude! I’m having some noise issues with my 3.5 ecoboost when under load usually around 2-3k rpm it kinda struggles on the intake side I believe but now that I seen this video I’m pretty sure my waste gates getting hung up a little bit. Thanks 😎✌️
@jason912055 ай бұрын
Make sure your rear exhaust manifold studs aren’t broken. If it’s “chirping” up acceleration they are notorious for this. Good luck
@user-gr9dd9ui9s4 ай бұрын
In my case, po299 happened to be cleaning the capless gas filler area with silicone lube. That fixes the code. I know how it sounds but that was the issue for me. Such a odd solution😂
@anthonyarrjay36 ай бұрын
Thank you for this video I have exact same problem on my 2017 f-150 2.7 ecoboost. Thank you !!
@StrikeCityDMVАй бұрын
This is happening to me right now , on my 2017 F150 I have no boost, it just came back from the dealer because they had to put a alternator in it and it’s not boosting
@stanleydueck49042 жыл бұрын
Thanks for this video. I have a turbo problem as well on my 3.5 ecoboost 2015. But it's a bit different then yours, I get little boost, then engin light comes on and motor shakes a bit and no boost. Till I ease on gas, and I can drive normally but when going up hill or passing other cars it doesn't have enough boost for that. So I guess I'm gonna start troubleshooting, if any body has a bit of advice I'm all ears!
@JamesJohnson-jk8wk Жыл бұрын
Same problem here, ever figure it out?
@Thomas-pz9qn Жыл бұрын
Same please keep me updated. I'm cleaning map sensor and changing plugs rn
@KrazyWolf61 Жыл бұрын
Same here. I was told the ignition coil #6 cylinder was bad. So I ordered new plugs and coils hope it fixes my problem.
@jeromehaver73312 жыл бұрын
Your right not alot of info about boost, thinkin thats in design and where the shops make the big money. Also this is a terrible video in respects to all mechanics. I cannot thank you enough for showing me and everyone else all the brilliant ways you came up with on doing process of elimination. One of the bests videos that have seen/ learned so much about with my 2014 f150/with being first vehicle of all my years racing with turbos. Thank you,Thank you, Thank you. Great job. If anyone gives you a thumb's down, probably a shop mechanic, by giving away some tricks of there trade, just surprised they would not try to take this video down as quick as they can, if they could. LOL Thanks again. JEROME
@ScottieBMan2 жыл бұрын
Nice find/fix bro, great trouble shooting my friend.
@StrikeCityDMVАй бұрын
Trust me it’s not just you all these issues are making me want to trade my dam truck
@clintmooneyham43402 жыл бұрын
@LETMELIVE Very helpful video. I just had a lot of aftermarket parts installed on a 2012 F150 Ecoboost, two of which were new exhaust manifolds and Garrett Powermax turbos. I’ve probably put 1.5k miles on them and am experiencing basically the exact same thing. Really hoping it may be a high pressure fuel pump and not something impeding the compressor wheel like what you had, we will see.
@jason912055 ай бұрын
Good job. What a pain in the ass to retrieve that small piece of metal. Dealer would’ve charged you several grand for that probably.
@cecilwheeler16707 ай бұрын
Very good explanation thank you
@omelmendoza8114 Жыл бұрын
Tengo una 2017 y no tengo boost voy a chequear el fusible y si no al dealer tiene garantia gracias por tu video👍🏻🤝🏻
@jetboy770371 Жыл бұрын
Did you have any problems breaking loose all the hot section nuts and bolts ? What would be my luck would be a nut galling on a threaded exhaust flange stud. I had a Subaru outback that the dealer did recall work on the exhaust manifold and stripped a stud. I don't know these valves, are they held in by a couple of duct clamps with metal flange seals installed between the duct and valves on both sides ? If so, just like a high stage valve or turbine case cooling valve. I work on Jet engines . Engine valves often have a flat faced flange and the duct flange face has a groove that the round metal flexible seal fits into. Get the seal in the groove and put on the clamp and then do the other side, make sure it all lines up and tap(hammer) and torque the clamps . Leak and ops check it.
@theil62 жыл бұрын
Wow, Brother you figured it out! Still cost you less than Shop Time!
@abu_abdullah8244 Жыл бұрын
Great Job, very helpful video thank you.
@pirihern9329 Жыл бұрын
Great troubleshooting. Saved a bundle
@airmannajera2 жыл бұрын
Holy hell !!!!!
@georgemoomaw22442 жыл бұрын
Wow. GREAT troubleshooting. BUT ……… it is not only you this stuff happens to. In fact, Murphy’s Law is the principal that applies to most DIY mechanics.
@jens2sig2 ай бұрын
I have a Ford F 150 3.5 2019, no boost at all, no lights and no codes. Less power, more gas and very noticeable when driving upp hills. Any suggestions?
@_willalexander.882 ай бұрын
Check all your hose connections
@emotep932 жыл бұрын
Awsome video man!!
@topherwayne4398 Жыл бұрын
What were the symptoms over all? I'm having the same issue
@coreyryckman271826 күн бұрын
That’s crazy bro
@coltongage5872 жыл бұрын
So I have the 2016 3.5 and I feel like mine is doing the same. It just started yesterday and I’m trying to fix it. I was just driving and lost all boost, acceleration went to crap and the most I can get is about .5 psi on my boost gauge while driving. I clean and replaced map flow sensor and like you I have no codes. I don’t believe BOTH turbos would go out at the same time which makes me believe electrical. My next step to try is the bypass valve though my sct scanner is saying I’m getting 13.6-14 volts. I haven’t taken my intakes apart yet to see if they are pulling a vacuum but about to walk out now and try. Do you think I’m having the same issue that you did?
@_willalexander.882 жыл бұрын
It's possible man I was shocked. Easy way is to pull the intake and feel it.
@kalsalhi2 жыл бұрын
Great job 👏
@aspaerialshotphotography89063 ай бұрын
It's a stage two 2 turbocharged
@davidsonpeguero27602 жыл бұрын
What if I’m seeing smoke in between my manifold and turbo?? Thanks for the video
@_willalexander.882 жыл бұрын
It's burning off all the grease and lubricants. Should stop after some time.
@cooperdiffey69732 жыл бұрын
Did any codes pop up at all im having a boost problem with my truck an it’s throwing a wrench up when it does that I have no boost at all but I can’t read the code on a scanner
@marckirby7356 Жыл бұрын
Did u find problem
@ouzeiroubimaliba458311 ай бұрын
Thanks so much
@wadewall78842 жыл бұрын
great job, surprising's fine
@TheOnlySgtRock5 ай бұрын
Good job trouble shooting the issue.
@spartan67242 жыл бұрын
Good job!
@Youstinck552 жыл бұрын
Did the turbo make any kind of grinding noise when you were into the boost?
@_willalexander.882 жыл бұрын
No. It completely jammed.
@omarguzmangarcia2582 жыл бұрын
hello friend I have a similar problem, going up a mountain I pressed the sport button on my f150 2015 3.5 and I lost power now it only reaches 30 miles the autozone diagnosis is insufficiency of pressure super charger code p0299
@_willalexander.882 жыл бұрын
Do a visual check first. Make sure it's not like a wastegate hose or something obvious. Then I would take off the intake like I did and have someone give it throttle while you feel is both sides are sucking air. That should tell you which turbo you have an issue with. Then go from there.
@scottlordjr2 жыл бұрын
Did you have any noise associated with the power loss?
@_willalexander.882 жыл бұрын
No. Acted normal just 0 boost.
@cyllib6952 жыл бұрын
Do you have a catch can installed on your truck? I just got a 2020 2.7 and seeing what's the best option.
@_willalexander.882 жыл бұрын
Yes. I have a video on it.
@Krunch2020Ай бұрын
You don’t need one on the 2020 unless you use crappy fuel and cheap oil. 😅
@fredjohnson688 Жыл бұрын
Oh yeah thanks 👍
@timstavely96772 жыл бұрын
How long does it take you to get the turbos out?
@_willalexander.882 жыл бұрын
Bc I've done it a few times now, 1-2 hrs
@capricetx91192 жыл бұрын
Can you add those upgraded turbos as is or do you have to buy supporting mods?
@_willalexander.882 жыл бұрын
I prob wouldn't without all the supporting mods but you sure can. At a minimum you should get tuned to see some benefit. Wish I did the stage 5 instead of 3 though. I'm kinda at the HP limit for a stock block though.
@843cuh92 жыл бұрын
@@_willalexander.88 can you do a vid on all the mods you did before and after install turbos