I did this work in western Canada for ten years and have never seen a rig or process like this. Lots of caisson, rock sockets in limestone bedrock or expanded base but this was $out interesting process to watch
@ke6gwf5 жыл бұрын
If you notice the concrete mixer trucks standing by, and then after the auger reaches the bottom it stops, and you see the large diameter hose going to the top of the auger jerking and flipping. That hose is connected to a concrete pump, and so once the hole is bored and the soil removed by the internal auger system, the concrete is pumped in to fill the hole and inside of the auger, so that as the auger is pulled out, there is no danger of the sides of the hole collapsing (which in that sandy or silty wet material would just flow right into the unsupported hole). So when the auger is removed that slurry that you see flowing out the end is the concrete that has been pumped in the hole already. Then the rebar cage is lowered into the wet concrete, and it is done. It is very clever, and pretty much the only way to do it in unstable or wet soil conditions like that.
@26jori5 жыл бұрын
would it work the same way if they are piling on the seabed?
@ke6gwf5 жыл бұрын
@@26jori similar. Usually what I have seen underwater in mud or sandy bottom is that they drive a pipe piling in, and then use a water jet and suction system to empty the sand and silt out of the pipe, and then run a hose all the way to the bottom of the pipe and pump special grout in from the bottom, which displaces the water above it. For applications like bridge piers and such, they may drive sheet piles around the perimeter of the pier, use dredges and underwater blasting to excavate the footings if there is bedrock, and then pump the grout to the bottom and use the sheet piling as a form for the concrete. For underwater use, the cement used is made with special properties so that it doesn't get weakened by being under water, and is carefully pumped in so that it doesn't get turbulent and mix with the water, but it is very similar to this method.
@26jori5 жыл бұрын
@@ke6gwf thanks for the reply, just learned something new
@RobertSzasz5 жыл бұрын
I'm surprised the concrete/grout would let the rebar settle into it. I would have expected something like a polymer or bentonite slurry to be used first, the rebar lowered in, and then the concrete injected to displace the slurry.
@davidruss77025 жыл бұрын
Robert Szasz I think that is actually what was seen. That didn’t look like competent concrete at the top of the shaft. Probably just didn’t film the next step of installing a tremie pipe and placing the concrete.
@bestpollondon4005 жыл бұрын
Perfect Piling. CFA combined with lining pipes.
@DynaPheng4 жыл бұрын
Best pol London yes exactly I think so
@MasterCivilEngineering3 жыл бұрын
Step by step video solutions for civil engineering questions
@rafzibi48254 жыл бұрын
Great video I did LIKE and got subscribed
@baumanagement4043 жыл бұрын
Very successful documentary, excellent work
@madcarew51682 жыл бұрын
No matter how big,how technical,how advanced,there's always nearby a bloke with a shovel!!!
@DynaPheng4 жыл бұрын
Wow good technical progress piling
@mohamedmalkooheji16934 жыл бұрын
Great video. Thanks!
@hami1414 жыл бұрын
What is straight rotary method for piles construction.
@celedonioariascarrion18802 жыл бұрын
excelente trabajo de pilotaje
@biyaheroroadtrips4394 жыл бұрын
Wow a nice equipment.
@CyberMacGyver5 жыл бұрын
i could watch all day 👀
@DynaPheng4 жыл бұрын
Cyber MacGyver yes the same me
@frank548615 жыл бұрын
this is a high pay dirty job👍👍
@selwynnarayanasamy5 жыл бұрын
EXCELLENT WORK
@SS-cj2nq5 жыл бұрын
Very informative
@uGoGop5 жыл бұрын
This Pauselli style machine can save Venice for another 1000 years.
@zaidahmad33843 жыл бұрын
What is the name of this machine which is used for boring pile ? Plzz comment !!
@charanjitsingh80125 жыл бұрын
Nice
@SAURAVKUMAR-co2ke5 жыл бұрын
Good work
@ayrcabral4 жыл бұрын
Sou operador desse modelo de equipamento !
@didinmase67274 жыл бұрын
Good👍👍👍👍
@khansahab-se3om4 жыл бұрын
Why you don't put concrete and cast the pile
@salustianosuay83813 жыл бұрын
Well, I'm not really convinced this system I prefer boring pile using steel casing by Bauer ,Trevi and other compa ies in the Philippines.
@mangeshkumaratram44285 жыл бұрын
very nice
@patriquesavi46045 жыл бұрын
Carambaaa!
@franciscowashington21555 жыл бұрын
Impressionante.
@davidtechjayko78114 жыл бұрын
Cool
@ayogodson97794 жыл бұрын
Inspired I am
@nawrajbhatt92654 жыл бұрын
Which project?
@Shreyanbiswas20152 жыл бұрын
I would like the name of the machine and the setting function of the machine
@statuemorris39704 жыл бұрын
shovel leaning against the track giving me anxiety
@RajaRaj-fm6cz4 жыл бұрын
Kaun sa machine hai
@Rhogzvideo Жыл бұрын
Good job
@celsopavan20542 жыл бұрын
ESSA E A MAQUINA,TOP DE LINHA. SOU SO UM ADMIRADOR DA ENGENHARIA. rsrs.... CELSO PAVAN CUIABA MT
@13queencoffee726 жыл бұрын
cool
@japan-e9j6 жыл бұрын
Excellent job super
@shahinkhan-qk5xo5 жыл бұрын
rong job you are apool...
@WCREngineeringWorks5 жыл бұрын
Please guides for pile foundation work kzfaq.info/get/bejne/ipuDfrOUv728pIk.html
@jawaharlalnehru46233 жыл бұрын
There is no pouring if concrete just shown how cage lowering will be done
@user-sw7jh4ju2i4 жыл бұрын
잘 보았습니다. 화이팅
@surveyingengineeringdesigninfo3 жыл бұрын
V nice
@binansonsihaloho26364 жыл бұрын
I do have...!
@xvfgsdkd96255 жыл бұрын
11:50 what a technique of doing !
@CrustyAbsconder2 жыл бұрын
All I could think of was how many such projects, the workers threw their enemy in the hole.
@mahboobalikhan19924 ай бұрын
Sir is this màchine use ful for digging well and boar for water what is rent
@wrongfullyaccused71393 жыл бұрын
Is there a worm inside the pipe conveying the soil to the top?
@uwewaibel91633 жыл бұрын
it´s called an auger..
@mode1charlie1703 жыл бұрын
This video was brought to you by hydraulics.
@AkshayKumar-pk1jr4 жыл бұрын
what is the name of this machine?
@alexanderkorpach82864 жыл бұрын
It's a Bauer BG rig with Double Rotary Drilling equipment.
@pierre75483 жыл бұрын
Think about ear protection...
@brianjones-gz8te3 жыл бұрын
nice
@birendrakr7276 жыл бұрын
Name of this machine
@iqRashehzad12526 жыл бұрын
BIRENDRA KR BIN ... Hydraulic Drilling Rig
@ramcharanlohar24765 жыл бұрын
🤔🤔🤔🤔🤔🤔🤔👌👌👌👌👌
@ArthurDentZaphodBeeb6 жыл бұрын
Sweet rig.
@fernandogonzalezvicente64224 жыл бұрын
Y a mi me da igual que me devuelvan el dinero y todos 78t 8 años de mi hijo no se puede decir lo
@fernandogonzalezvicente64224 жыл бұрын
Y a mi me gusta el redondel la tarde y me 8dice que dice que te te mando ES EL SEGUNDO SEGUNDO SEGUNDO lugar a dudas la vida de mi parte y me 888iiiiiyúiiiikkkkyhhjhgbkhkjjjjjjn
@fernandogonzalezvicente64224 жыл бұрын
88Cápsulas no le falta nada más QUÉ HABLAR con los Enemigos invisibles un tiempo de 6677777777777777u
@muhdharith27904 жыл бұрын
Wow, that's excavator going another level of duty
@olih274 жыл бұрын
Funny having all that kit, but still relies on one bloke with a spirit level
@timcasalisdepury36014 жыл бұрын
Tried and tested!
@salamuddinudinband20424 жыл бұрын
Oe hayeu tat. Pdud ongkoh kuh sboh tiang
@inwooeee6 жыл бұрын
Good
@muhammadraiz27045 жыл бұрын
Kaya bathhy
@Krizbonz3 жыл бұрын
That cat just hammering the rebar at the end seems to me like it would result in some inaccuracy of the piles you think?
@dhanichannel90472 жыл бұрын
nice vidio 👍 salam sukses selalu bos Lampung hadir bos ku 🙏🙏
@user-bu7fb6nn9k3 жыл бұрын
날림공사네 밑에 진흙 6m 쌓여있는대 철근 그냥 넣으면 콘쿠리트 넣어봐야 하던까지 언 내려감
@gdhebdbdhdh47185 жыл бұрын
Why counterclockwise
@robertnorthrup19145 жыл бұрын
Same driving on left side of road........
@TheLondonForever003 жыл бұрын
Blimey, what the hell is being built their, the Burj Khalifa?
@kolakalyan92314 жыл бұрын
How to calculate the pile quantity concrete
@spectrovision74664 жыл бұрын
Join in class - IX , u'll get it . Thanks for your silly question .
@luongtran-qm1mc4 жыл бұрын
ok
@omygod15904 жыл бұрын
What next?
@todaymovie51203 жыл бұрын
What r the salary of hydrolic pile machine operator salary..
@baishya7753 жыл бұрын
500000 dollars /Hour
@todaymovie51203 жыл бұрын
@@baishya775 chutiya bnane ko main hai mila kya tujhe.. Etna salary to sundar pichee ka v nhi..
@dehilario43144 жыл бұрын
11:50 En Mexico eso no podría realizar, las normas son muy estrictas en ese sentido.
@msto60073 жыл бұрын
Price
@m_a_x_i_m_u_s_s_c_a_t65264 жыл бұрын
2020?
@ManishGupta-st4gq3 жыл бұрын
Me v jali ka Kam krta hu bro agar kam ho to batna me kerLa m karta hu abhi Ghar par hu
@prabhunathgiri6 ай бұрын
Ni safety work
@rontanawat5 жыл бұрын
ดีครับ
@bigredc2225 жыл бұрын
Where did the dirt go that they dug out of the hole?
@ke6gwf5 жыл бұрын
The drill has an internal auger, and you can see it coming out the top of the drill assembly, falling through the telescoping ejection tube into a pile next to the hole, where an excavator pulls it away. Then concrete is pumped in through the large hose you can see at the top of the machine, and the auger is then removed. The concrete has to fill the hole before the auger is removed, to prevent the hole from collapsing since that is wet sandy soil and would just flow or slump in. Then the rebar is lowered into the concrete filled hole.
@bigredc2225 жыл бұрын
@@ke6gwf I'm in construction, I know how it works, I've put up 90' light poles that needed 36" x 25' hole drilled, they pull up a hell of a lot more dirt than is next to that auger, I see the excavator removing dirt, but it must have removed a hell of a lot more than they show.
@ke6gwf5 жыл бұрын
@@bigredc222 I suspect that a lot of the auger still is full of soil, so maybe half of it is still sitting in the drill.
@ke6gwf5 жыл бұрын
@@bigredc222 and I used to be the guy on the excavator pulling the dirt away on bigger holes than you described lol
@bigredc2225 жыл бұрын
@@ke6gwf I think 36" was biggest we ever did, I've probably done hundreds of 18"-24" for parking lot lights, that sonotube is some great stuff. I have a funny story, we were drilling a 20" or so hole for a parking lot light, we start smelling gasoline, we figured it's coming out of the truck, it turns out it's coming from the hole, the dirt in the bottom of the hole was saturated with gasoline, I find the superintend of the job and tell him expecting him to flip out, he just calmly says don't worry about it, I say you don't get it, the site used to be a gas station that actually worked at as a teenager, the tanks must have leaked, he tells me don't worry about it, just fill it with concrete, I was about 24, this was my first big job as an electrical foreman, it was a four story building, I didn't want make waves on my first job, so I did what I was told and filled the hole with concrete. They may have gotten away with it, but the plans called for a small pond with a fountain about 100' from where I hit the gas, I guess eventually gas started leaching into the pond, they ended up having to put some kind of contraption that somehow sucks the gas out of the dirt, it was half the size of a shipping container, they put it right next to the pond in front of this beautiful new building, that was 1984, and that thing is still there.
@josedacara67252 жыл бұрын
Looks like soil cement
@ruiutomy12 жыл бұрын
Health and Safe rules broken.
@ppgtamu98146 жыл бұрын
Esto Drilling Machine hamro Npl ma jatti sakdo xito liyara kam garna paryo Dhani Sahu haru le
@phongdt93855 жыл бұрын
Hỏng bét
@tungtavantung13785 жыл бұрын
504
@phucnguyen9414 Жыл бұрын
Nhap ve
@patrickpat88784 жыл бұрын
Then they will poor ciment into mud , I don’t think it will go down to bottom of the pile. As the ciment will flow down , it will mix with the mud , humm good ciment , first quality...
@kevinbates18635 жыл бұрын
Dark funeral -)
@lahmanlahman68065 жыл бұрын
Hi
@jaidulsekh38833 жыл бұрын
Dada valo a6o pile kajer khobor nai
@anwrhameeda92744 жыл бұрын
Borders piles
@leonelburgostrejo27655 жыл бұрын
Que terreno tan malo para construir
@canaldiversoscomjoelrocha69585 жыл бұрын
Schow muito bom
@asiandesignstudio45922 жыл бұрын
kzfaq.info/get/bejne/aLmPjaRhsa2VgZs.html, ഭൂമി പൂജ : Asian Avenue - Work Started