VW Polo 1.2 TDI FULL Service - Oil Air Fuel Cabin Filter

VW Polo 1.2 TDI FULL Service - Oil Air Fuel Cabin Filter - Light Reset

Рет қаралды 51,125

3 жыл бұрын

How to do a full service on the VW Polo 1.2 TDI
Sump plug 19mm - torque requirement 30Nm - washer not replaceable.
Oil filter torque requirement 25Nm
Oil capacity 4.3 litres
Fuel filter Mahle KL778
Air filter Mann C15008
Cabin filter Mann CU26010
Oil filter HU7017z

Пікірлер: 71

@ChandrinKatuwawala 11 ай бұрын

Thank you so much, after 10 years and 310k miles of ownership I will service my 1.2 TDI BlueMotion for the first time.

@SebastiaanvanLuik-pz6di Жыл бұрын

I have started servicing my car for the first time and your videos are extremely helpful. Thank you so much.

@IAMASPANNER Жыл бұрын

I’m very glad to help and well done for doing it 👍

@jasonsimms1219 Жыл бұрын

Great video, just about to service a vw polo (first time), so you’ve saved me a lot of time. 👍🏻

@IAMASPANNER Жыл бұрын

Thanks Jason, glad to help!

@spannerssockets6308 11 ай бұрын

Excellent video! When the oil filter is unscrewed, oil will drain out of the filter housing down into the sump so don't replace the sump plug till after the new filter is fitted. Also, I recommend getting the top of a soap dispenser, pushing a bit of pipe onto the pickup tube and it using to suck the small pool of oil out of the filter housing when the filter is removed. Well done on using Mann filters, excellent quality brand.

@IAMASPANNER 10 ай бұрын

Thank you! I’ve stopped bothering as much with removing every bit of oil because it’s actually nothing compared to what is left in the engine. If you had the sump removed you’d probably find another half litre of oil would drain out overnight.

@_monti142 9 ай бұрын

@@IAMASPANNER perhaps do the oil change just after the engine has been running for a bit, so that the oil flows better

@fredy000 Жыл бұрын

Thank you, I needed this.😊

@janstevenweerstand4737 2 жыл бұрын

Awsome vid , very helpful , big thanx 😁

@IAMASPANNER 2 жыл бұрын

Glad to help!

@damdamdam8346 Жыл бұрын

Clock work service , note as you did ensure the large oil seal is sat in the 3 grove down from the top and Not the top grove.

@alubonilendwanyaza1638 Жыл бұрын

very helpful thank you

@sethboonstra7770 9 күн бұрын

Thanks for the video. Only there is one more fuelfilter under the car

@drickusbezuidenhout 3 жыл бұрын

Thanx man!!!

@SuperSameer333 Жыл бұрын

Thanks man

@busterruff9369 10 ай бұрын

I have just brought a Vw polo 1.2 tdi 2012 ,would this have a dual mass fly wheel ? As there’s a knocking noise on the engine ,but when you press the clutch it stops ,

@IAMASPANNER 10 ай бұрын

It will have a dual mass flywheel, yes.

@brunob97 2 жыл бұрын

Does the car have to be level when you drain the engine oil or can it be on it side because I only have 1 jack ?

@IAMASPANNER 2 жыл бұрын

It doesn’t need to be level, you’ll just need it to be level when checking the level of the oil afterwards.

@rhysgrainger8202 Жыл бұрын

Great vid, do you have to prime the fuel filter or can you just start the car up? Cheers

@IAMASPANNER Жыл бұрын

Thanks Rhys, I have always got away without priming, cycling the ignition a few times works as long as the car has a pre-delivery pump in the fuel tank.

@dinto_louis 2 жыл бұрын

For the cabin filter, the air flow is from the passenger side (left) to the driver side (right)..rit..? Kindly check if the installation was correct..

@IAMASPANNER 2 жыл бұрын

Away from the motor and towards the matrix so that does sound correct.

@bozidarkrunic9505 2 жыл бұрын

What about 2nd fuel filter that is located under the fuel tank, in front of right back wheel? The Volkswagen says it should be replaced every 3rd service, so just want to hear your experience with that? Thanks! PS. Very useful video 👍🏼

@IAMASPANNER 2 жыл бұрын

Hi Bozidar, I wasn’t aware of a second fuel filter? This is the same location as all the fuel filters I’ve done on VW diesels so far.

@dinto_louis 2 жыл бұрын

Maybe the filter location was underneath the fuel tank for the previous gen polo (mk4).. Saw some video..check...

@jackmathias7808 Жыл бұрын

There is 2 one under the tank infront of osr wheel 🤣

@longb1913 3 жыл бұрын

what was that connector on the fuel filter? my one has a similar and i literally cant get it off

@IAMASPANNER 3 жыл бұрын

I couldn’t get it off at all, kept trying and trying. My friend walked over and got it off straight away! It seems the more you try the harder it gets. I hope you got sorted!

@j4nandthegang163 Ай бұрын

You gotta push it like plugging it in then the clips will activate so u can press them and pull it out

@krtolebiohazardcs1.681 2 жыл бұрын

Is it normal for that engine to smoke coming out from oil deep stick ?

@IAMASPANNER 2 жыл бұрын

A little bit yes, there’s always some vapour inside the engine when running.

@imrxnz2531 Жыл бұрын

I have the same car. Did u prime the fuel filter or something before starting it? Seen videos where people have to prime the pump and looks complicated

@ZoubeirsWorld 5 ай бұрын

Yes you have. This guy did not prime it because he is doing things wrong and can damage the filter easily.

@mikeb.395 4 ай бұрын

@@ZoubeirsWorldwhat does „Prime the filter“ mein? Sorry im from germany

@busterruff9369 Жыл бұрын

I was thinking of buying one of these Polo diesels 2013 do you think they are good cars ?

@IAMASPANNER Жыл бұрын

For the most part I don’t think they’re bad at all.

@arsenbaic Жыл бұрын

Hvala

@ted2091 11 ай бұрын

thanks for the video, very informative. are you sure it's actually 4.3L of oil, because i have read that it's 2.8L but that might be for gasoline engines.

@IAMASPANNER 10 ай бұрын

Diesel engines do usually take more than petrol.

@ted2091 10 ай бұрын

@@IAMASPANNER hello again, thanks for your reply. 4.3L indeed seemed to be correct for my own service.

@PolashJH 10 ай бұрын

@@ted2091yes brother 4.3l but don't top up to max. 4.20l is good 👍🏽

@brunob97 2 жыл бұрын

How do you change the 2nd fuel filter ?

@IAMASPANNER 2 жыл бұрын

What 2nd fuel filter?

@yasinmohtube 2 жыл бұрын

Have you changed the spark plugs ?

@IAMASPANNER 2 жыл бұрын

It’s a diesel, it doesn’t have spark plugs.

@yasinmohtube 2 жыл бұрын

@@IAMASPANNER ok how about glow plugs ?

@IAMASPANNER 2 жыл бұрын

@@yasinmohtube no, I was just doing this service for a friend, sorry.

@dimvasileiou974 Жыл бұрын

A good oil for this engine that will decrease the oil consumption

@nicolasch2 Жыл бұрын

Πόσο σου καεί φίλε;

@krtolebiohazardcs1.681 2 жыл бұрын

Engine cover is without bolts?

@janstevenweerstand4737 2 жыл бұрын

Yes indeed

@IAMASPANNER 2 жыл бұрын

Yes! 👍

@sauravroy9108 2 жыл бұрын

How much engine oil to fill in 1.2 tdi

@IAMASPANNER 2 жыл бұрын

4.3 litres

@sauravroy9108 2 жыл бұрын

@@IAMASPANNER thanks a bunch mate!

@angelgruevski 2 жыл бұрын

How is the oil consumption? Mine consumes 1 liter per 10000 km

@IAMASPANNER 2 жыл бұрын

This isn’t my car so I don’t know but to be honest 1 litre per 10,000 km is pretty normal for a diesel, if not even more than that.

@janstevenweerstand4737 2 жыл бұрын

I have the same car , i drive 20000 between service interval , and mine consumes about a half liter of oil on this kilometers , this shoud be pretty normal .