1ZZFE Toyota Corolla Variable Valve Timing Solenoid and Oil Filter 9th Gen

Рет қаралды 226,617

Күн бұрын

This video is to show you what i did to remove the Variable Valve Timing Solenoid and the small Oil Filter that filters the oil to the VVT Solenoid.
The car is a 2005 Toyota Corolla S, 1ZZFE 1.8, 100,000 Miles.
Symptoms: Erratic idle when the engine is at full operating temperature. Idle deeps below 650 RPM when coming to a stop. Engine would vibrate like it had a small misfire.
No Codes.
Injectors Cleaned and Fuel Pressure perfect.
New Spark Plugs.
Coils firing correctly and with a strong spark.
No Vacuum leaks on vacuum lines, brake booster, fuel vapor canister.
Replaced the Intake Manifold Gasket.
I will post an update after driving the car for a few days to let you know if it fixed my problem.

Пікірлер: 162

@MarzNet256 3 жыл бұрын

Really excellent trick with the clip to get the filter out. You can also get needle nose pliers with a 90 deg bend at the tips. I also had a rough idle and pending lean code. Turned out slow oil leak from valve cover contaminated electrical connector on drivers side of engine block (crankshaft position sensor). This caused ECU to get bad data and try to compensate, resulting in lean condition. Cleaned connections, problem solved. Replaced valve cover gasket. 2006 Matrix with 152k mi.

@josesalvadorguillen 5 жыл бұрын

Very helpful video. I am not experiencing a bad idle but i can always do this quick easy check and clean the filter. I have an 05 Matrix with the 1zzfe.

@krazedohc6 2 жыл бұрын

Nice tip on the alligator clip, I've also used a long drywall screw when one was stuck and I knew I would be replacing

@matteh7able 4 жыл бұрын

Fantastic video 👍 thank you!

@shertalk1528 3 жыл бұрын

I had a Yaris 2009 2NZ-FE 1.33 liter. Had exact same problem as you. After cleaning injectors, changing sparks and throttle body cleaning, nothing helped. Changing the solenoid did finally do the trick. My buddy mechanic told me it's 50/50 chance once you get the solenoid out that it might break and need replacement immediately. Long story short, it did fix the problem and I love your video. (FYI, I had the same milage as you lol)

@donmbasela4075 3 жыл бұрын

Thanks very mach for this enducational video now i know were to fined,the oil control filter

@zeth8300 Жыл бұрын

Nice video i think this is part of my problem thanks for telling us

@akhilmuraleedhar 3 жыл бұрын

My 08 corolla had very rough cold starts. The whole car vibrates at start up. The issue was with the throttle body and MAF sensor. Got it cleaned. Works real smooth now.

@cluelessguy1754 3 жыл бұрын

I also got those cleaned twice and made no difference in the dipping rpm when coming to a stop.

@Xanderfied 2 жыл бұрын

Could also be the vvt sprocket needs replacing

@akhilmuraleedhar 2 жыл бұрын

The throttle body was cleaned in place. Using WD 40. MAF sensor was cleaned with MAF quick drying spray. I clean these two every month along with the air filter. The kmpl increased from 8- 14 after doing these for the first time in months.

@MarzNet256 Жыл бұрын

@@cluelessguy1754 You probably need a new intake manifold gasket. If it gets worse as it get colder outside that might be it. Also, using scan tool, check output of coolant temperature sensor to make sure it is reading correctly.

@niklasdanielyu2894 3 жыл бұрын

Thx helped a lot great video

@cscabrera 3 жыл бұрын

Thanks for sharing!

@davidfalgout7304 3 жыл бұрын

well done & good job!

@kgb0070 2 жыл бұрын

POSITIV UND OPERATIV !

@jamesgyasiokyere840 3 жыл бұрын

Thanks it helpful bro

@jackreston8188 2 жыл бұрын

Great tip. Thank you.

@antoniopiloto3661 2 жыл бұрын

Valeu pela dica um abraço

@SUPERNVA-gr4sr Жыл бұрын

I am going to give it a try

@scottrussell3862 7 ай бұрын

Get yourself some snipe nose pliers they have a 90 degree bend in them. Good video bud

@hectorromero3536 2 жыл бұрын

What spray or method did you use to clean out the filter?

@eyyo2561 Жыл бұрын

Awesome video

@coreyholmes2229 3 жыл бұрын

I also found that blowing compressed air into the hole will blow out the filter.

@recklessdrivinginsingapore 2 жыл бұрын

May i know if you had a obd code error when you encountered this issue?

@Nizzwell Жыл бұрын

I have this issue with a toyota BB stalling at lights , rev it well and it stabilises but comes back . Replaced lots of parts but not this one 👍

@Adz_Win 4 жыл бұрын

Thank you .. i will try this.. its all trial and error. Is this the same process for a tsport yaris 1nzfe

@1221Ralph 4 жыл бұрын

If I remember correctly, replacing the pcv under the intake manifold solved this issue on my 10th gen.

@cluelessguy1754 3 жыл бұрын

I replaced mine too at the same time I did spark plugs. The idle was a little smoother but no difference in the dipping of the rpm.

@jhaelportes6883 3 жыл бұрын

@@cluelessguy1754 Try the relearn idle process

@asoomer3947 4 жыл бұрын

Good job

@davidknibbs9646 2 жыл бұрын

I seen a video on showing a norther screen filter under the power steering

@leonardonelson6895 2 жыл бұрын

Replaced the pcv valve? Checked the MAFS sensor?

@TheRealDanNguyen 2 жыл бұрын

thanks

@igorseprak6177 2 жыл бұрын

This is caused by intake manifold gasket being worn or damaged. If you replace it the gasket, make sure the gasket is assembled perfectly.

@davidg5704 2 жыл бұрын

Exactly. Toyota upgraded the intake valve gasket due to issues. I agree this would cause a vacuum leak and rough idle. 👍

@letmethinkv 2 жыл бұрын

It will generate code?

@MarzNet256 Жыл бұрын

@@letmethinkv Only when it gets bad enough, but you can have this problem without lean codes. It's also can get worse as it gets colder outside-indicating bad intake gasket.

@stevenchow5874 3 жыл бұрын

Thanks for the video advised , 1question :does remove vvti solenoid and vvti bolt filter drain oil necessary?

@dinukakathriarachchi4810 2 жыл бұрын

You do not have to drain the engine oil to do this

@orinmangar2333 4 жыл бұрын

Is your throttle body clean? If not clean it.

@asht7321 Жыл бұрын

had the same problem on a rav. temp sensor was the main culprit after changing many attempts

@AnythingEverythingGh 6 ай бұрын

Was your car throwing any trouble code?

@asht7321 6 ай бұрын

@@AnythingEverythingGh I don't think so because the mechanics could not fixed. After a lot of discussion one guy decided to change the temp sensor and fixed the problem.

@soulfreem 3 жыл бұрын

Ξέρεις πως ξεχωρίζουμε την καινούρια γενιά κινητήρων από το 2004 και μετά με τα διορθωμένα μπιστονια;

@RicardoHernandez-xq7hn 5 ай бұрын

Does the 2009 Toyota Corolla also have the filter in the same place?....because in a comment it says that it has it in another place

@macarthurtrim1056 Жыл бұрын

Good day, did it work? I currently have the same problem.

@orinmangar2333 4 жыл бұрын

Did you ever check compression? My vibration at idle was a faulty MAF. No check engine light.

@cluelessguy1754 4 жыл бұрын

Yes. I don't remember the numbers but the pressure was within 5% between the cylinders. Fuel pressure was also good.

@f1346m 3 жыл бұрын

Where you able to silve the problem? I have the same vehicle same engine. I notice my variable valve solenoid is leaking oil rigth from its center. Can this be the issue for my multiple misfire code.

@cluelessguy1754 3 жыл бұрын

I sold the car soon after I made this video. I wasn't able to completely solve the problem. And yes, I would think that the variable valve solenoid not getting the oil pressure it needs would cause misfiring since the valves aren't opening and closing the exact time they need.

@Xiferr 2 жыл бұрын

cleaned mine on 2005 matrix 1zz-fe with 180k miles not a speck in the filter. good i guess! was a bit of a pain inthe ass of a job lol

@Xiferr 2 жыл бұрын

did you fix the problem?

@orinmangar2333 4 жыл бұрын

Rpm would drop down to 500, and vibrate like it was going to stall and then even out. After trying to clean it , I could not get it to rev over 2500 rpm

@McNaught82 5 жыл бұрын

Where did you get the small filter from? Searching on Google isn't bringing back results for my 03 Corolla

@cluelessguy1754 5 жыл бұрын

I just cleaned up my old one. I also couldnt find anything online. I would try your local Toyota dealership

@McNaught82 5 жыл бұрын

@@cluelessguy1754 did you use regular brake cleaner to clean the filter and solenoid?

@cluelessguy1754 5 жыл бұрын

Yes. And you can use a screwdriver to slide the inner part to see if it slides smoothly or it gets stuck.

@elisabetaeross1454 2 жыл бұрын

So did it fix it?

@jannerbugarin3009 3 жыл бұрын

Please help ,,,my car is not in good idle ,,,it will go up sometimes around 3000 rpm then after a minute it goes down around 1000rpm ,,my car undergo with scanning then there is an error ,,camshaft solenoid valve ,,

@raysonhirakawa2943 4 жыл бұрын

Sounds like the vvti is stuck in the on position, i would check if the pin that locks the camshaft is stuck , or if you have a OBD2 reader check if the variable valve timing is on

@treach5196 3 жыл бұрын

My obd says my vvti is on during live data...is it not supposed to be on all the time??? Maybe that's why I can barely get 350 miles per tank??? Please let me know..02 gt auto wahh 😭 I know..ebay cai, muffler delete into 4.5 inch can and a cat delete with slightly ported exhaust manifold..yeah me..to think I had a 86 auto supra, 87 targa turbo 5 speed supra, 93 sc300, and 97 4 cyclinder camry..ahaha life's so ironic..but yeah vvt supposed to be off most of the time??

@hiblendmedia 3 жыл бұрын

I recommend replacing the VVT Solenoid/Oil Control Valve O-Ring/Seal since you'll be taking it out. These o-rings become hard don't hold up to 75k-100k miles.

@pat72396 2 жыл бұрын

Do you know if the vvt solenoid being clogged could potentially make the car not start?

@williammize8270 3 жыл бұрын

I changed off on 03 corolla 1.8 4cyl no change the hose was cracked got new one from Toyota have misfire low idle almost stall but not 225.300 or so just keeps driving though burnt spark plug no 4 or no 1 4cyl coil pack ok thought it was coil pack keeps going though gas miles ok too

@hussamkhaleds5971 4 жыл бұрын

🙏👍

@JFLY28 Жыл бұрын

What if that screen has lost the plastic tip

@user-em6pt4lr2o 3 ай бұрын

how many small filter in the 1zz engine...plz tell me

@johnnymaripacheco6961 5 жыл бұрын

I have the same problem I changed everything. Did it fix the your issue with stalling and low rpm.????

@cluelessguy1754 5 жыл бұрын

Mine was never stalling but the idle is a little better now. I had a surgery after i performed the above steps so i haven't driven the car enough to say if it made a considerable difference or not. What kind/weight of engine oil are you using?

@johnnymaripacheco6961 4 жыл бұрын

@@cluelessguy1754 5w30 Synthetic

@willbleedem5156 3 жыл бұрын

@@johnnymaripacheco6961 did you fix the idle and stalling ? I’m having the same problem

@phoneroni 3 жыл бұрын

JohnnyMari Pacheco did you fix the problem of stalling ?

@callmebackfriday2 2 жыл бұрын

Thanks for the video. Would this fix the lifter noise or tap tap noise on my high mileage 200k Corolla? Thanks so much.

@letmethinkv 2 жыл бұрын

It will

@callmebackfriday2 2 жыл бұрын

@@letmethinkv Thank you so much.

@infoguy1470 2 жыл бұрын

I replace the timing chain tensioner on mine and it reduced the knocking on cold start. But to be fair it might be the timing chain getting stretched since it's never been changed. Rattling noise can also be from serpentine belt tensioner which is weird. Noise happens now n then especially at low rpm. Then it's that also to think about. I'm about to changed my vvti solenoid on my corolla and clean out the filter n hopefully it solves the problem on idle. If not my next step is to test fuel pressure n clean the idle air control valve since they are known to be changed around 80k miles

@callmebackfriday2 2 жыл бұрын

@@infoguy1470 Thanks so much for your information. The list you mentioned really helps. 👍

@AnythingEverythingGh 7 ай бұрын

@@callmebackfriday2 Did it solve your lifter tap tap noise?

@mikan4216 3 жыл бұрын

When i stop at roundabouts it feels no power i clean maf throttle body but still

@maxmilo1219 4 жыл бұрын

γεια σου πάνω έχω ακριβός το ίδιο πρόβλημα στο αμαξι τρέμουλο λες να είναι από αυτό ;

@orinmangar2333 4 жыл бұрын

You have a bad MAF. Go to rock auto and get a OEM Denso for cheap. My car used to do the same thing at idle with gear in drive at traffic light or stop sign. You can also check the resistance in the maf to see if within specs.

@cluelessguy1754 4 жыл бұрын

Resistance was within specs but i replaced the MAF with a denso from rockauto. Problem was still there. Even swapped MAF with another Corolla of the same year, the problem stayed with my engine. The other Corolla did not have this problem, not even with my MAF sensor installed

@orinmangar2333 4 жыл бұрын

@@cluelessguy1754 Did you do all the checks on the VVT. Check voltage on connector. Check resistance on Vvt. Check to make sure no terminal on vvt is grounded to its body. Lastly check that physical movement of vvt is smooth without power. If you did all of this, I would check the coolant temperature sensor.

@mamun740 3 жыл бұрын

hello i have 2009 corolla. it has about 140000 miles. the car really shake when come to stop or going really slow. and I can also hear tearing sounds. it also say cylinder 1 and 2 misfiring. i swtich the coils but still saying same thing. the sounds is really bad the tearing sounds specially when i head the gas. any help is appreciated.

@cluelessguy1754 3 жыл бұрын

So you put coils 1 and 2 to cylinders 3 and 4? Maybe switch the spark plugs as well? Do you have any way to verify if there is actual spark at the tip of the sparkplug?

@lovelycollection100 4 жыл бұрын

Chech the compresión of cilinders

@userwaianae8841 3 жыл бұрын

Is it easy for the filter to fall in thru the whole?

@cluelessguy1754 3 жыл бұрын

No, the filter can't fall in the engine through the hole.

@chee75 Жыл бұрын

my got same problem but i chang camshaft sensor everything good now

@willbleedem5156 3 жыл бұрын

Alright I clean the old sensor reinstalled it. With the old sensor I had a low idle no vibrating in drive. I put the new one inside , I had a low idle and the vibrating returned what do I do? Or what did I do wrong

@cluelessguy1754 3 жыл бұрын

What sensor did you clean? Is the check engine light on? Disconnect the battery for like 20 minutes and then reconnect it. Search on how to relearn the idle for your car.

@willbleedem5156 3 жыл бұрын

@@cluelessguy1754 I changed the VVT solenoid shown in the video.

@willbleedem5156 3 жыл бұрын

Also my engine light is still on I’ve noticed it isn’t misfiring anymore with is a plus. I’ve also changed the oil earlier in the day before replacing the VVT Solenoid. But I’m still experiencing the vibrating and low idle.

@PhonePhone-sf8te 4 жыл бұрын

Your IAS probably needs cleaned. i had similar problems and got that code.

@activyt8151 4 жыл бұрын

Did you just clean the solenoid ? Or did you replace it

@cluelessguy1754 4 жыл бұрын

I just cleaned the filter that filters the oil that goes to the solenoid. It did make some difference but not alot.

@activyt8151 4 жыл бұрын

Panagiotis Marmaras did you end up figuring out what the problem is ? I’m having the same problem with my 03 Corolla

@joesaric1 4 жыл бұрын

@@cluelessguy1754 that was not the problem than.

@Greenrosettas 4 жыл бұрын

Did you ever notice an oil leak from the solenoid or filter bolt? I noticed an o-ring, did you replace it when you cleaned and inspected the part?

@AnythingEverythingGh 6 ай бұрын

@@cluelessguy1754 How do you insert it back in? The notches on the filter placed vertical or horizontal ?

@ayleenvalencia4870 5 жыл бұрын

i was wondering if this actually fixed your issue??? i have a 2013 toyota corolla and is doing the same

@marcosgazamanes6165 4 жыл бұрын

Ayleen Valencia the engine changed completely for your model year, do you have any lights on? Vibration can come across when the motor mounts are worn also.

@JuanSanchez-uo3rp 4 жыл бұрын

I clean the throttle body maf sensor..tried the relearn proccedure.. disconecting the battery for a while ..now i bought the pcv and intake manifold gasket am just guessing but a lot people are having the same issue.. rpm drops at red lights after warm up like if it wants to turn off and it doesn’t just the idle drops to around 600 car shakes and then it goes back to normal..

@noahriedel801 2 жыл бұрын

@@JuanSanchez-uo3rp did replacing your intake gaskets fix the idling problem??

@ayleenvalencia4870 Жыл бұрын

@@noahriedel801 no..i clean the throttle body often but sometimes is just makes a diff for a couple of days..

@orinmangar2333 4 жыл бұрын

How many miles on your car and what year?

@cluelessguy1754 3 жыл бұрын

It was a 05 with 90.000 miles. I no longer have the car.

@hectorramirez9889 4 жыл бұрын

Could that be causing the cold start rattling?

@Hawk011 4 жыл бұрын

Possibly, buy more likely the chain tensioner. I've changed mine and it got a lot better and quiter on cold starts.

@cmte.brazinazzo2061 2 жыл бұрын

@marcosgazamanes6165 4 жыл бұрын

I have an 06 corolla, the idley weird, but a common problem that causes bad idle is the intake manifold gasket

@cluelessguy1754 4 жыл бұрын

Yes, that is the most common problem with them. And make sure you get the updated orange colored gasket. I did that like 5 years ago

@marcosgazamanes6165 4 жыл бұрын

Panagiotis Marmaras yes agreed! I did get the revised gasket. She has about 200 thousand miles now. I am getting a small leak from VVT actuator, thanks for your video it was helpful!

@MarzNet256 Жыл бұрын

You are most correct. It is especially apparent in cold temps. I did mine and it helped a lot.

@IlyushinSPA 4 жыл бұрын

Hi, have you ever found a solution? I have a Toyota Avensis 2008 with this engine 1zz-fe and the same problems that you say, mostly erratic and hard idle. I have made more or less the same diagnostics as you without result. But once I tried a fuel additive to clean the system and while that fuel tank lasted mixed with the aditive, the car run much much better. I think it might be related to the o2 sensor.

@cluelessguy1754 4 жыл бұрын

I no longer have the car but no, i wasn't able to fix it. I did replace both oxygen sensors and it didnt make a difference. And a new catalytic converter and MAF sensor didnt fix it either. I have a fuel injector cleaning kit and cleaned the injectors while they were in the car. I didn't notice any difference. One thing i was going to try if i still had the car would be to remove the injectors and either clean or replace them. I did use a scope on them and the readings were good, so they werent sticking. But there is no way to tell if they were partially clogged or even leaking without removing them.

@XJlover90 4 жыл бұрын

Clean the idle air control valve

@IlyushinSPA 4 жыл бұрын

@@XJlover90 in my car, this 1zzfe engine has electronic throttle body, so there isnt any idle control valve. And I have fully cleaned (twice) the throttle body (without removing so the tps doesnt get disturbed)

@justinross3338 Жыл бұрын

@@IlyushinSPA Did you ever solve this:?

@jonathanmorales6202 Жыл бұрын

I just took mine off and it was so dirty and clogged thank you so much

@marxseet Жыл бұрын

worst case scenarios you might want to check your VVTI timing chain tension

@mikan4216 3 жыл бұрын

I have 1NRFE engine where is this valve

@user-rx3xg6xc1p 3 жыл бұрын

Check idle solenoid.

@dennisdatu6464 Жыл бұрын

The VVT valve is NOT the problem... symptoms point to oxygen sensors going bad. The fault won't show a check engine light or on the scanner right away.

@dameionjames7755 8 ай бұрын

Some times it's a Allen bolt that holds in that filter

@skillzhg9598 3 жыл бұрын

Sounds like you need to replace or clean your IAC (Idle Air Control Valve) Should be on the throttle body.

@yaryar1976 3 жыл бұрын

If it’s anything like the 2003 Camry it doesn’t have an iac. Which is why I’m here-I’m having idling issues as well

@Scotty926 3 жыл бұрын

@@yaryar1976 it does have a iacv, at least my mom in law car did I changed it lol 2004 matrix w/ a 1zz

@TommyboyGTP 3 жыл бұрын

What was the update on this?

@cluelessguy1754 3 жыл бұрын

I no longer have the car but this by itself did not fix the low idle. It's my opinion that the low idle is a result of a compilation of things like the filter I cleaned, the variable valve solenoid, throttle body, spark plugs, oil condition, battery/alternator condition and the condition of negative and positive cables to and from the battery to the engine and the cars body, PCV valve and MAF sensor.

@TommyboyGTP 3 жыл бұрын

@@cluelessguy1754 Thanks for the reply. I'm looking at buying a 2002 Corolla so i'm doing research to see what i'm getting myself into.

@genericusername1365 3 жыл бұрын

@@TommyboyGTP Get a 2004 or above instead. The piston oil passage port problem was fixed by 2004.

@teddyramirez2424 3 жыл бұрын

Mine did something similar. Issue was a Bad Thermostat

@letmethinkv 2 жыл бұрын

😂

@aygwm 4 жыл бұрын

You didn’t look into IACV valve?

@cluelessguy1754 4 жыл бұрын

My car didn't have an IACV. Some 9th gen Corollas do and some dont.

@aygwm 4 жыл бұрын

Correct if you had a car with cable throttle. Some research into this points to a few different things. Air leaks at the intake manifold, tired MAF and tired O2 sensor are some other potential causes. But it may very well be an ECU issue in how they mapped it as well.

@genericusername1365 3 жыл бұрын

Drive by wire started in 2005, so no IAC valve.

@nebulousJames12345 2 жыл бұрын

how much oil comes out of these two things when you remove them? Will a paper towel catch it, or should I put a cup or catch pan underneath?

@cluelessguy1754 2 жыл бұрын

There was very very little oil that came out. Just a paper towel is good enough

@joshuathung2472 4 жыл бұрын

no,its the vvt cam problem

@whitneyyork7850 3 жыл бұрын

Drain the oil first ?

@cluelessguy1754 3 жыл бұрын

Not necessary

@beenwashedup5754 7 ай бұрын

Also replace pcv valve and hose I had a tiny leak bct off end of where leak was and replaced pcv valve puuuuurs

@awati33 3 жыл бұрын

I use an 08 corrola. Ones in a while I experience some noise at the top of the engine and the oil light comes on. When i off the engine and start again it the noise stops and the oil light goes off as well. This happens when i drive for a long distance or speeed a lot. What may be the problem?

@justinbieber3957 Жыл бұрын

What size is the O-ring?

@cluelessguy1754 Жыл бұрын

I'm sorry but I don't know and I no longer have the car.

@simonadson2844 4 жыл бұрын

@brianrae1624 4 жыл бұрын

that behavior is because your PCV valve was clogged I've had two used 1zz cars both came to me running like yours was running and 20$ later it ran perfectly fine with new PCV.

@cluelessguy1754 4 жыл бұрын

PCV valve was replaced twice. Once with one from autozone and the second time with one from the toyota dealer.

@brianrae1624 4 жыл бұрын

@@cluelessguy1754 What year was it? if it was pre 2006 it could have been the aux air valve was clogged up or a dirty throttle plate, or intake manifold gastket failure also

@jannerbugarin3009 3 жыл бұрын

@@brianrae1624 where to find the aux air valve of altis 2005 mdl