2008 EZGO RXV, Gas - Help! It Won't Move in Forward or Reverse!

Рет қаралды 17,384

Жыл бұрын

Welcome to Kevin's Golf Carts KZfaq channel! We make how-to's, repair and vlog-style videos. Ocasionally, we will have a live stream to answer your questions.
My Site - www.kevinsgolfcarts.com
Affiliate Links: I earn a small commission when you use the links below. These links help support my channel without added cost.
Amazon Store - www.amazon.com/shop/kevinsgol...
Kofi - ko-fi.com/kevinsgolfcarts
PayPal - www.paypal.me/theburns/5
Mattress Insider - goo.gl/rhQLMj
TubeBuddy - bit.ly/2okVnXe
Square - squareup.com/i/KEVINSGOLF
Amazon Links:
Cat LED Flashlight: amzn.to/3s6exNI
DEWALT Grease Gun: amzn.to/3J10osa
DEWALT Goggles: amzn.to/3HnE6Ap
Nitrile Gloves: amzn.to/3ojvuTX
Welding Gloves: amzn.to/3gkguAA
Dremel Rotary Tool: amzn.to/32RlzgE
Gummout Carb Cleaner: amzn.to/3uhkkTn
Compression Tester: amzn.to/35DjMNb
Milwaukee 1/2" Drive Impact: amzn.to/3L1SuAB
Milwaukee M18 Batteries: amzn.to/3gh4NKS
Milwaukee M12 3/8" Ratchet: amzn.to/3AS0jnI
Milwaukee M12 12-Volt Battery: amzn.to/3olztPD
Milwaukee M12 Rivet Tool: amzn.to/3ARdEwz
Mr. Funnel AF3CB Fuel Filter: amzn.to/35EGmVH
Neiko Impact Socket Set: amzn.to/3L529Gi
Neiko LED Work Light: amzn.to/3IZ1g0h
The Ear Buddy Ear Plugs: amzn.to/3scQwVd
Tek Motion Ultrasonic Cleaner: amzn.to/34gSHz3
Voltec LED Light: amzn.to/3rlCFwv
Other Links:
Husky 30 Gallon Air Compressor - go.magik.ly/ml/kqd6/
Camera Gear:
GoPro HERO 10: amzn.to/3okKEbA
ProGrade Digital SD Card: amzn.to/3KZK9NL
ProGrade Digital SD Card Reader: amzn.to/34ig4Iu
JOBY GorillaPod Tripod & Ballhead: amzn.to/3J29Aw2
Manfrotto 496RC2 Ball Head: amzn.to/3HnYUaY
Panasonic Lumix 12-60mm Lens: amzn.to/3GmJTow
Panasonic Lumix 14-140mm Lens: amzn.to/3rmcFBa
Panasonic Lumix GH4: amzn.to/3KYJThQ
Panasonic Lumix GH5: amzn.to/3HrtHDB
Ravelli AVTP Tripod: amzn.to/3Hr3CES
Pixel Wireless Lavalier: amzn.to/3GpQBtE
15lbs Sandbag: amzn.to/3AVrGx3
CRAPHY Softbox: amzn.to/3oo87bF
Disclaimer:
Kevin's Golf Carts cannot guarantee against unauthorized modifications or improper use of this information. Kevin's Golf Carts assumes no liability for property damage or injury incurred as a result of any of the information contained in this video. Kevin's Golf Carts recommends safe practices when working with all tools, chemicals, lubricants, or any other tools or equipment seen or implied in this video. No information contained in this video shall create any express or implied warranty or guarantee of any particular result. Any injury, damage or loss that may result from improper use of these tools, equipment, or the information contained in this video is the sole responsibility of the user and not Kevin's Golf Carts. If you are uncomfortable with replicating the actions used in this video, seek the service of a qualified professional.

Пікірлер: 28

@deborahnickerson500 Жыл бұрын

Kevin, you are awesome! This 67 yr old retired RN, turned full time farmer has now learned to work on 2010 Gas RXV. From troubleshooting ignition system, replace brushes in starter, replace cooling fan and busted shroud, remove and clean carburetor, along with general maintenance, you show me the way! You have saved me money and sanity. Use this cart every day for chores. Thank you!

@BarryWinner2075 3 ай бұрын

I have had the same thing happen numerous times, it is always a relief that it is just the brake drum and not something striped inside the differential. I just put on a new drum and torque it to close to 100 ft lbs

@ressoy Жыл бұрын

Another job done,great content in what to look for.👏🏻

@dcrickerson7611 Жыл бұрын

Nice work! Thanks for the video!

@baggerbenn Жыл бұрын

Super common issue. Good job as always!

@Kevinsgolfcarts Жыл бұрын

It happens way too frequently on EZGOs.

@NickDalzell Жыл бұрын

Spun hubs (especially on EZGOs) are super common. The amount of times someone claims 'the tranny went!' it's always a given the hub is spun. The main cause for spun hubs is the brakes adjusted too tight. A lot of customers want their drum brakes to be disc brakes and expect the same performance so they run the adjuster so tight you can't even spin the wheel and it EOL's the hubs. I'm too old school for those plastic chinesium tools. I have a ton of bad luck with Milwaukee tools (they shut down when you 'work them too hard') so I'm just using a 4-way from the 50s. I also got tons of metal power tools from that time and drills with keyed chucks and that works so much better for me.

@Kevinsgolfcarts Жыл бұрын

I've never had one on a Club Car, one or two on Yamaha, but mostly EZGO. A separate hub and drum would help solve this. I can't say the same for Milwaukee tools. I work mine pretty hard and have not had them shut down.

@NickDalzell Жыл бұрын

@@Kevinsgolfcarts never had a spun hub on anything but EZGO here. the reasoning behind sacrificial hub splines is to prevent people from flying through the windshield in the case of a locked up hub or axle. That's EZGOs word at least but if that were true they would not have made that goofy brake on the RXV

@ericshepherd8466 Жыл бұрын

As usual Kevin! Great Job. New information for me .

@wendydockal1649 Жыл бұрын

Hi Kevin , absolutely love your channel it’s helped so much. Getting ready to purchase parts and was wondering where you normally go. Thanks for everything .

@Kevinsgolfcarts Жыл бұрын

I'm a RHOX dealer and buy my parts and accessories from them. Everything Carts and Buggies Unlimited are 2 good places for consumers.

@lennyleejr7763 Жыл бұрын

@@Kevinsgolfcarts Hi Kevin I got a 2008 ezgo that won’t idle or go slow it will will only move in the higher rpm so I have a carburetor problem?

@ramonhernandezjr 3 ай бұрын

Update to my problem. After lifting the cart on jacks, 3 tires rotate, the one that doesn’t is the rear passenger side tire.

@patricksharkey6203 Жыл бұрын

What if the cart is stuck? Can’t move forward. But when I lift the rear end up the wheels spin in opposite directions

@drewzx3 Жыл бұрын

I've been chasing this problem for awhile now on my rxv with the kawasaki. I've changed the carb with Amazon carb, adjusted throttle cable, new pedal switch, just adjusted valves, new fuel and air filters, and spark plug. It will not crank unless you barely press the peddle. What else could it be?

@TDP-in4hn 2 ай бұрын

HELP NEEDED!!! I have a 2009 ezgo rxv. It will be running fine but everynow and then when i get out to hit the ball and get back in its completely dead🤷‍♂️ i put new battery, solenoid,fuel filter,fuel pump,plugs and it still acting up. It will run if i get a push from another cart🤷‍♂️ some days it runs fine for all 18 holes,then some days it shutdown every dang hole🤷‍♂️ any advice would be appreciated 🤙thanks!!!!

@marcheld Жыл бұрын

Hello Kevin. I picked up an ‘89 gas 2 cycle Marathon off Craig’s list. I’ve been learning about it from KZfaq and Google. I’m so glad I found your channel and am enjoying your videos and picking up lots of tips and tricks. I’ve done a break job, fixed a bunch of little things that crop up. Going to put new shocks, wheels and tires this weekend. One thing that is an issue is I can’t run the fuel down past 1/2 tank. I’ve checked the siphon tube, replaced some fuel lines and filter, but still seems to starve for gas when the tank has some air in it. Is this a sign the fuel pump needs replacement? Keep up the good work!

@Kevinsgolfcarts Жыл бұрын

Make sure you have a vented gas cap. If the tank is creating a vacuum, the pump cannot pull fuel. It is also possible that the pump is getting weak. I would check the siphon tube where it connects to the tank nipple. I have seen them leak very slightly causing air in the line. You could also pull the fuel line off the carb and crank the engine to see if there is fuel flowing.

@peterlivingrooms119 Жыл бұрын

Hi from Puerto Rico 🇵🇷Marc. I had the same problem in my cart and I resolved it with a low pressure electric gas pump from Amazon. It cost me aroud 12 bucks + tax and shipping. It's very easy to install. Put it in the same gas line, one wire to the start switch and the other to ground. Try that and thank me later. Good luck my man!!👍🏾

@marcheld Жыл бұрын

@@peterlivingrooms119 sounds cool Peter. Can you share the link to that Parton Amazon? Cheers!

@ramonhernandezjr 3 ай бұрын

My 2005 TXT Gas cart will start but does not move in any direction. I cannot even push it when it’s in neutral

@aydenchisholm9023 Жыл бұрын

Hey Kevin, I have a Ez go 2001 gas golf cart and everything on the cart runs good besides the rear end. The rear end slowly moves and when I move it by hand forward the opposite side moves in reverse any tips on how to fix this problem besides cleaning?

@patricksharkey6203 Жыл бұрын

Did you figure anything out?

@joeyurban5169 Жыл бұрын

Kevin, by chance is there a good way to reach out to you regarding my 2000.5 Club Car DS?

@Kevinsgolfcarts Жыл бұрын

Unfortunately, I don't offer any type of direct support. I just don't have the time for anything like that. You can ask your questions on here or during my live streams and I, or someone else may be able to help.