1.6 HDI Engine oil and filter change

Рет қаралды 263,408

Күн бұрын

1.6 HDI Engine oil and filter renewal
Frequent oil changes are most important preventive maintenance the DIY home mechanic can give the engine, because ageing oil becomes diluted, contaminated and loses efficiency, which leads to premature engine wear.
In this clip I will show you how i change engine oil and filter to my Peugeot 308 1.6 HDI 66kw. This method applies to most of the 1.6 HDI Peugeot Citroen engines.
Disclaimer:
This video is for guidance only, I am not responsible for any damage or injury caused by this operation.
Facebook: / psadiyrepairs

Пікірлер: 131

@romakayak 2 жыл бұрын

Aren't you supposed to push the filter into the engine first making sure the filter plug goes into the hole and then tightening?

@madsilencepers88 4 жыл бұрын

Thank you for the best and clearest video ever! To the point and perfectly set up from the start! Now my Peugeot has new oil thanks to you! 😀😀😀👌

@bestpeter78 3 жыл бұрын

40 pounds

@bordersw1239 3 жыл бұрын

Thank you for posting. Just done the oil and filter on my 1.6 bluehdi Picasso. Used a Pella vacuum pump through the dipstick - that extracted 3.6L. Didn’t have to remove the air filter hose, just remove the 2 front screws and lift out of the way. Whole process took about 30 mins and zero mess.

@tk4270 3 жыл бұрын

To make sure i locate the oil filter plunger in the hole in the oil filter housing correctly, i insert the the oil filter in the housing first and without the oil filter cap. Once inserted, i push the oil filter cap onto the back of the oil filter and turn clockwise to screw down.

@romanslamka7969 2 жыл бұрын

👍👍👍

@felixizzy 8 ай бұрын

I second this, I just did it the way shown in the video and it bent the spigot and the oil light was coming on a low revs.

@balkicroatia 2 жыл бұрын

Thumb up for video. Always make sure that engine is fully hot before draining oil.

@ady_claudio 2 жыл бұрын

Să trăiești, merci din nou 😊

@miladinseratlic4565 4 жыл бұрын

5:32 !!! No, no, no! Most common error out there is putting the new filter first in to plastic cap then placing all together while rotating bcs on some of those filter pin doesn't align into hole on filter seat properly and you get *NO OIL fitlering*. it's always better to put filter first and use little bit more time to put plastic cap but then you are 100% sure everything will be ok.

@jepperasmussen2581 3 жыл бұрын

There is no doubt about the pin hitting the hole because if it does not, the engine will not make oil pressure. And if you do not push the oil filter up into the cup, the oil filter will remain in the oil cooler. And it would run down the gearbox the next time you need to change the oil filter

@fernandostanic2035 3 жыл бұрын

m.kzfaq.info/get/bejne/j7l4nMlmq8rJZ3k.html

@fernandostanic2035 3 жыл бұрын

m.kzfaq.info/get/bejne/j7l4nMlmq8rJZ3k.html

@pecata01 3 жыл бұрын

@@jepperasmussen2581 The last oil change I aligned the pin and put the filter in the housing first and then screwed the cap on and the next oil change the filter came off with the cap. It wasn't stuck in the housing. When you screw the cap onto the filter it still pierces the top and attaches it.

@simonstart2325 4 жыл бұрын

Really great video. I love that you show the sizes of the tools needed for the job

@AdrianDragan 4 жыл бұрын

Thanks :)

@peterkornis5377 3 жыл бұрын

Few suggestions: 1. remove the dipstick while filling the oil, so the air can escape resulting less bubbling and easier filling 2. do not replace the bottom cover/drain cap before making sure there is no leakage 3. clean the bottom of oil reservoir after draining with break cleaning spray, so no dust can stick in the old oil 4. it is advisable to replace the drain plug or at least the copper ring every time you change oil 5. always fill the oil on LEVEL ground, run the engine for a few seconds (20-30) before checking the level on the dipstick

@Simple-dad793 2 жыл бұрын

Shut up

@misu5262 5 жыл бұрын

Bravo Dobrogene complimente !

@brigtottarvalen8484 3 жыл бұрын

A good idea is to wipe clean the lub oil filter cap before inserting a new o-ring

@henryrolt3747 3 жыл бұрын

Makes me love my 2001 Toyota Yaris. An idiot with a spare few minutes and a single 14mm spanner could change the oil and filter on my car. Zero parts need removing or disturbing other than the drain plug and filter. Filter is plonked right on the front of the engine.

@raduflorian7037 6 жыл бұрын

Eu pun prima data filtru in "casuta" lui ca sa fiu sigur ca am nimerit acea gaurica. Si apoi capacul de plastic. In rest treaba foarte buna. Scutul e aftermarket..corect? Faina usa aceea de vizitare.. Cele bune

@missionnad1 5 жыл бұрын

Exact.Prima data se baga filtrul in blocul motor ptr a fi sigur ca se nimerește găurica iar apoi se vine cu capacul de plastic si se insurubeaza.

@fernandostanic2035 3 жыл бұрын

m.kzfaq.info/get/bejne/j7l4nMlmq8rJZ3k.html

@nadiyayudintseva9859 Жыл бұрын

Good job my friend. Thank you so much! I wish you luck.

@AdrianDragan Жыл бұрын

Thanks for your appreciation 🙂

@AdrianDragan Жыл бұрын

Thanks for your appreciation!

@AdrianDragan Жыл бұрын

I'm glad to help you.

@AdrianDragan Жыл бұрын

Thank you for your appreciation.

@firstoriginals 5 жыл бұрын

Good luck friend. The best mechanic on the internet and maybe more

@bomunder Жыл бұрын

الله يرحم والديك

@florinbutucel6859 5 жыл бұрын

Salut acelasi ulei bag si eu suna perfect cu El 🤘👍

@Andrea-vc7hb 5 жыл бұрын

Wait a sec; the oil for the 1.6 hdi isn't the 5w30??

@grahamefreestone5309 5 жыл бұрын

My ford fusion has the 1.6 tdci engine (same engine I believe) and mine takes 3.85 litres of 5w30 fully synthetic. 🇬🇧

@chilman6461 5 жыл бұрын

Your both right

@billmolloy2264 5 жыл бұрын

Really great video production, many thanks

@jamesheath7596 2 жыл бұрын

Not bad video but you didn’t mention that the locating peg on the replacement oil filter should go into the hole within the filter housing.

@kerhy7666 2 жыл бұрын

I mean nice tutorial but you can do this easily even without any disassembly, just loosen the oil filter housing, pull out filter, loosen oil screw - give it back, fill oil, new filter DONE :)

@AdrianDragan 2 жыл бұрын

Yes you are right. But I wanted to show how to do it so as not to be too difficult if you do not have the necessary experience.

@dickclements 5 жыл бұрын

That's a very cool and convenient ramp!

@clintbalzan8926 2 жыл бұрын

Great videos. Any reviews on reliability and what to look for in a peugeot 308 1.6hdi? Im thinking of getting one

@AdrianDragan 2 жыл бұрын

Hello. I am very excited about both the old 308 (2008) and the new 308 (2017). The 1.6 hdi engines are very reliable but on the new generations with Adblue you need a little more attention to these anti-pollution systems. From what year do you want the car to be, how many kilometers, what would be the budget?

@Mr11ESSE111 Жыл бұрын

Is oil filter without notch on it good too for replace!?i ordered from aliexpress and they send me without notch on it

@AdrianDragan Жыл бұрын

Don't install that filter because it's not good. For a maximum of $10 buy a good and suitable filter from the auto parts store.

@Multipleimaging 2 жыл бұрын

Great video, thank you 👍

@dimitriskounatidis3114 4 жыл бұрын

Try replacing the engine mounts i changed mine and there is a huge difference (i noticed allot vibration just from idling )

@AdrianDragan 4 жыл бұрын

Hi! Thanks for your advice!

@davidregan5095 3 жыл бұрын

Very well done video thanks

@telabib 4 жыл бұрын

Excellent video.

@antoniojavier4693 5 жыл бұрын

Good job Adrian .

@dokov 5 жыл бұрын

You should do a sump plug mod - pulling the recess of the plug socket out, this way you can drain the full quantity of the old oil. In the current situation you have left around 300ml of old oil in the engine in the sump, that's why even your new oil gets black immediately. In your case you have metallic shield under your engine and it's safe to fix the sump plug. Check it here: kzfaq.info/get/bejne/l9B2mJB71tHYaKs.html

@bestpeter78 3 жыл бұрын

Recently oil change dosn't matter of 300 ml

@alexciuciu2297 Жыл бұрын

Salut, probabil e o întrebare des întâlnită, dar am bagat anul trecut tot de la total și mi se pare că e cam gălăgios motorul. Anul trecut am luat mașina. Nu pot cumva sa bag ceva de la liqui moly ? 308 1.6 hdi 109cp. Noroc cu videoclipurile tale !!!

@AdrianDragan Жыл бұрын

Salutare! Poti baga si de la alti producatori dar trebuie sa respecte normele specificate de Peugeot pentru motorul tau. Eu merg pe 308-ul din 2008 numai cu Total si masina are 270.000km fara probleme. Schimbul de ulei il fac la 10.000-12.000 km.

@alexciuciu2297 Жыл бұрын

@@AdrianDragan mulțumesc de răspuns , am băgat 5w40 de la total. Am schimbat și combustibilul și merge perfect.

@AdrianDragan Жыл бұрын

@@alexciuciu2297 Totusi masina daca are filtru de particule (FAP) ar fi mai indicat sa folosesti total 5w30.

@chilman6461 5 жыл бұрын

Thanks for the video mate

@Harpreet13013 3 жыл бұрын

Hi I noticed you used Total quartz 9000 5w40 instead total INEO MC3 5w30 that is recommendable by manufacturers. Can I ask reason ? I am from UK

@AdrianDragan 3 жыл бұрын

Hi. INEO 5w30 is recommended for cars with FAP, my car does not have a particle filter so this is why I use 5W40.

@brocky78 3 ай бұрын

Got it Deleted I like 😎👍

@josemanuelrealbetis9867 6 жыл бұрын

Hola Adrian, cuando debo arrancar mi 308 ? Cuando el STOP este encendido o apagado ?, gracias !!!

@ninouninou8225 2 жыл бұрын

سلام عليكم ممكن استفسار عندي سيارة نوع 207 hdi 90ch تكسرلي معيار الزيت la jauge أثناء محاولي استخراجو بواسطة سلك تكسر جزء من السلك وسقط فالكارتير طول 1 ملم صغير جدا هل من ضرر على محرك السيارة

@AdrianDragan 2 жыл бұрын

إذا انكسر الجزء المعدني وسقط في المحرك ، فقد لا يكون جيدًا جدًا. أعتقد أن أفضل شيء هو الذهاب إلى مركز خدمة لخلع حمام الزيت ومعرفة مكان تلك القطعة من القطعة. تصحبك السلامة.

@ninouninou8225 2 жыл бұрын

@@AdrianDragan شكرا جعلها الله في ميزان حسناتك

@Siri_and_Family Жыл бұрын

De ce nu folosesti 5w-30 ? Mecanici din Danemarca si programele lor le arata 5w -30 si nu asta...am întrebat si zic nu 5w 30. Domnul IISUS HRISTOS ,YAUSHUA SA VA BINECUVÂNTEZE

@AdrianDragan Жыл бұрын

Salut! Folosesc 5w40 deoarece masina mea nu are filtru de particule (FAP). Pentru masinile cu filtru de particule se foloseste 5w30.

@beany1987 4 жыл бұрын

Did you line up the oil filter plastic fitting with the hole?? Didn't look lined up correct in the video and no mention of it either.

@AdrianDragan 4 жыл бұрын

When threading the filter cover it will lock into that hole, so it was designed. It's the choice of everyone how he wants to install the oil filter, I think both variants are correct.

@beany1987 4 жыл бұрын

@@AdrianDragan never done it that way before as the end seams abit fragile but if it works then great.

@superbob4058 6 жыл бұрын

I.use 5w30 total quartz ineo better oil

@miguelmarques4405 6 жыл бұрын

Sem dúvida, principalmente com FAP

@kakasvk 5 жыл бұрын

Ineo is for cars with dpf filter (fap). Unless you have car with dpf, using ineo is useless. And 5w40 is better to use in summer.

@brigtottarvalen8484 3 жыл бұрын

And insert the new filter element in the filter housing BEFORE the filer cap. Then you will be sure it fits correctly.

@fernandostanic2035 3 жыл бұрын

m.kzfaq.info/get/bejne/j7l4nMlmq8rJZ3k.html

@christopherdavies9111 2 жыл бұрын

Watch the clip added by Fernando and prepare for an education

@Mateuszlasek1988 Жыл бұрын

Polecam najpierw włożyć filtr :)

@murattaskin4874 3 жыл бұрын

hi mate, 4 liters will be enough?

@AdrianDragan 3 жыл бұрын

Hi. Yes. 3.8 liters for 1.6 hdi.

@murattaskin4874 3 жыл бұрын

@@AdrianDragan thank you

@davideturra6727 3 жыл бұрын

Che bella musichina dark

@vernerstergaard5850 5 жыл бұрын

super

@hberlin836 4 жыл бұрын

Whats the right NM torque for oil plug and oil filter housing?

@AdrianDragan 4 жыл бұрын

The plastic oil filter cover (over the disposable paper element) should be tightened to 25Nm.

@eabad653 3 жыл бұрын

the car is on a ramp and isn't level the old oil cant be fully drained..

@RK-qc6fo 4 жыл бұрын

Hi friend, why not 0w30 ?

@AdrianDragan 4 жыл бұрын

My car does not have FAP, so I use 5w40, it is more suitable for the climatic conditions in my country.

@janklimek7666 4 жыл бұрын

@@AdrianDragan where do you live ?

@AdrianDragan 4 жыл бұрын

@@janklimek7666 Hi, Romania.

@bahadirdogan6208 3 жыл бұрын

I have put 0w20 cheap oil in this car and mys dpf blocked , any one has diesel car make sure put right oil and make sure c1 class or c2 class oil which they are good for cars with dpf

@AdrianDragan 3 жыл бұрын

Quality oil and filters are perhaps the most important component that the user can choose for the engine to run for a long time without problems. My 308 does not have a particle filter, I think it is among the last cars to leave the factory without FAP in 2008.

@lorenzostojanovich3138 6 жыл бұрын

Adi unde este rampa asta?

@AdrianDragan 6 жыл бұрын

Intre Tulcea si Murighiol.

@cabriodersentanrlar6304 5 жыл бұрын

why 5w40 ?

@shanekneeshaw3483 5 жыл бұрын

Ask PSA

@danilogonzalezmx 3 жыл бұрын

Because of mileage or something?

@daiversgarage168 4 жыл бұрын

Неправильно показана установка нового фильтра. Сначала устанавливаем фильтр в корпус чтобы пробка на нижней части фильтра попала в отверстие в корпусе и только после этого устанавливаем крышку. С такой установкой чаще фильтр просто расплющивается в корпусе и НЕ фильтрует масло.

@haithammohammed4407 6 жыл бұрын

Our technician here will lose all the screws

@danutchelner999 5 жыл бұрын

Salut.Nu ai mai folosit pompa de ulei cumparata de la Lidl sa o probezi?

@AdrianDragan 5 жыл бұрын

Salut, Am incercat sa scot uleiul cu pompa dar nu se poate extrage tot uleiul, am reusit sa scot doar vreo 2 litri. In baia de ulei este o ransforsare (tabla) ce blocheaza furtunasul sa ajunga pana pe fundul baii. Urmeaza sa fac clipul in care am testat pompa.

@danutchelner999 5 жыл бұрын

Multumesc,eram curios daca se merita sa cumpar.

@AdrianDragan 5 жыл бұрын

@@danutchelner999 Pentru 1.6hdi si 1.4hdi nu semerita deoarece nu poate fi extras tot uleiul.

@danutchelner999 5 жыл бұрын

Multumesc,apreciez ca esti sincer.Am Citroen C4 1.6 HDI

@alexeiappraiser6017 6 жыл бұрын

Фильтр начинать откручивать надо после слива масла.

@Giermo15 5 жыл бұрын

I have peugeot 307sw 1.6hdi. Yours Peugeot engine has 90 degrees temperature so why my peugeot has engine temperature maximum 82 degrees.

@AdrianDragan 5 жыл бұрын

Hi, Maybe the thermostat is faulty.

@Giermo15 5 жыл бұрын

@@AdrianDragan is it easy to fix?

@AdrianDragan 5 жыл бұрын

@@Giermo15 It's not too easy, I recommend you to go in a car service.

@shalomour 6 жыл бұрын

Is the euro5 the same way?

@AdrianDragan 6 жыл бұрын

Maekuk munslam Yes.

@paul-ne1bh 5 жыл бұрын

can you tell me is it a ford engine fitted in this thanks

@Dennis-rm2oc 4 жыл бұрын

what kind of oil does the 1.6 hdi use

@AdrianDragan 4 жыл бұрын

If your car has a FAP use 5w30, if no use 5w40.

@janklimek7666 4 жыл бұрын

manufacturer says 5w-30, i got 1,6 tdci with out DPF and i am using 5w-40 shel helix diesel ultra for 14 years! i believe that its good

@AdrianDragan 4 жыл бұрын

@@janklimek7666 I have been using this Total 5W40 oil for 12 years and it works perfectly even after 260.000km.

@foroudghasemi4868 5 жыл бұрын

hi. motor oil capacity of peugeot 301?

@AdrianDragan 5 жыл бұрын

Hello, what engine?

@shanekneeshaw3483 5 жыл бұрын

1.6 hdi around 3.5 L

@barkerlee5129 5 жыл бұрын

What the fuck! how hard to change the oil filter on Peugeot 308

@birdcrazy329 5 жыл бұрын

Why would you do the cover of the oil sump without testing for leaks ?? Amateur

@bargaboy1 4 жыл бұрын

He renewed the sump plug with new washer

@birdcrazy329 4 жыл бұрын

bargaboy1 you still need to check it before lowering it and stuff what if it wasn’t on right

@neagustefan3263 Жыл бұрын

Salut , eu la peugeotul meu 1.6 hdi 110 263.00 km ii bag total quartz 5w-30 e vreo problema sau trebuie sa i bag si eu 40

@AdrianDragan Жыл бұрын

Salutare! Din ce an este masina si ce model?

@neagustefan3263 Жыл бұрын

@@AdrianDragan pai e anul 2008 Sw 6+1 viteze dpf

@AdrianDragan Жыл бұрын

@@neagustefan3263 Mergi în continuare fără probleme pe 5w30, are cea mai buna compatibilitate cu acea generatie de dpf.

@neagustefan3263 Жыл бұрын

@@AdrianDragan mersi frumos de sfat . Si daca nu te superi inca o intrebare daca tot avem modele apropiate este vreo problema daca am pus o baterie de 65 ah rombat , cealalta veche era de 60 ah berga cred ca era cea originala

@AdrianDragan Жыл бұрын

Nu este nicio problema.

@alexeiappraiser6017 6 жыл бұрын

Фильтр начинать откручивать надо после слива масла.

@valentinpetrov4906 2 ай бұрын

Это не правда .Почему так решили ? Там есть масло которое не стекает если фильтр не раскручен!