Clearly you are a very professional mechanical engineer. Thanks for the video.. Most people would simply replace. Nice to see a pro clean / repair rather then buy new..Bonus is no reprogramming..💪👍🏻👏👏

Thank you sooo much, it worked but my ring pilers didn't freaking work but I tried freeing the mechanism now it's great!🎉

BINGOOO! Compre un opel astra 2010 y venia con los mismos síntomas o incluso peor y gracias ati pude solucionarlo ojo que no soy mecánico ni nada solo seguía tus pasos pero no exactamente igual use una lija 2000 y papel de cocina e gastado como 5 euros y a quedado de maravilla se siente y corre mucho mejor y el motor se escucha mucho más tranquilo no ise la regeneración ni nada pero me da el mismo consumo que ati una ves que lo e echo espero dure mil grasias desde zaragoza España.

Many thanks!!!

The pump regulator valve does not always fail, more than 50% of the failures are due to the pressure limiting valve that is in the fuel rail, not the sensor, the limiter is a bolt that protrudes from the common rail rail. It remains open and the ramp pressure drops No siempre falla la válvula reguladora de la bomba, mas del 50% de los fallos son por la válvula limitadora de presion que va en la rampa de combustible, no el sensor, la reguladora, un perno que sobresale de la rampa de common rail. Se queda entreabierta y baja la presión de la rampa.

Super 👏👏👏👏👏

Does anyone know the part number for the Astra J 2.0 CDTI 165 hp?

Czy trzeba odpowietrzać układ paliwowy?

Please can you explain which sensor i should spray DPF CLEANER TO CLEAN MY DPF EXHAUST

You don't need calibration of the scv because you only cleaned it right?

👏🏻👏🏻👏🏻👏🏻👏🏻👏🏻

I followed video took off cleaned and installed now car won't start, I did line up the 2 holes with the hole on outside but not starting anymore?

1.7cdti jerking under acceleration and rough idle intermittently. Cleaned EGR, changed fuel filter. No codes but a low reading on fuel rail pressure sensor in live data? Any ideas? Would it be this?

Which scanner can get in to a Vauxhall to reset that

Grazie mille acquistandolo nuovo posso chiederti se serve un reset tramite diagnostica?

Is this the same procedure for 1.6 cdti engine 100kw?(year 2015)

do you need diagnostics-calibration after replacing this valve ??

Mine astra j 1.7cdti 130, jerks cold in first gear going downhill. Could this be the case?

What if I took it out clean put back the same regulator and do the learning process via diagnostic tool, is this good or bad bcs you said only new parts have to be programmed to learn and mine is very strange now it takes more fuel than in average and gas pedal seems to be heavier on the foot, any solution?

Is this the same for 1.7 cdti zafira?