DIY Replace a Septic Tank Pump

Рет қаралды 231,337

RMSpeltz Farm - ReefDVMs

5 жыл бұрын

Easy way to Do It Yourself How To Replace a Septic Tank Pump.
/ rmspeltz
/ farminghomesteadingfamily

Пікірлер: 103

@bobcaddock3264 3 жыл бұрын

Nice to see your daughter helping. To me that's the best kind

@SayHelloToOblivion 4 жыл бұрын

Best instructional video I’ve seen so far on this. A lot of smart advice on safety as well. Never go into a confined space without knowing the air quality. Many gases can displace oxygen. You can literally lose consciousness within 2 seconds. Thank you.

@Cat-wl2ub 3 жыл бұрын

Excellent video. Lots of helpful advice.

@jaws2858 3 жыл бұрын

Best helper yet!

@gl35 Жыл бұрын

Great instructional video. And, you had the best of help.

@bradm2116 2 жыл бұрын

Very good video just a couple notes please don't use zip ties I typically see them only last about 5 years before they rot away and cause issues I mock my pumps up with electrical tape than use stainless hose clamps to secure the floats I've always Ben told its bad to spin the pump backwards that's why u put a check valve in we just drill a ¼" "wheep" hole above the check valve to allow the line to.drain back. Also a rope on the pump does help to install and remove but many many times I've seem the rope rot and pump sucks it up killing the pump or the handle rots off and you drop the pump trying to remove it. With basic ¼-½ H.P. pump i lower them down in with the piping. Also never ever install a electric outlet inside the tank so you can just plug the pump in I've scene it burn out pumps on more than one occasion we always instal a water tight elec. Box in the riser of the tank and hard wire the pump using direct barrieal wire nuts. And one more note from my experience pumps that seem to pump more liquid last longer meaning a longer run time each cycle than say a pump with a short throw to the float it seems like alot of starts and stops burns out a pump faster than it running longer

@thousandaire2 Жыл бұрын

Thanks for this info. I'm a do-it-yourselfer and am installing a new pump tomorrow. And the new pump (goulds) has a standard electrical plug, and so does the float switch. I was debating cutting the plugs off and hard wiring them inside the waterproof box like you say vs wire in an outlet. The old waterproof box was how it was done 25 years ago and it lasted that long. Actually my pump is a Myers and it still works but the plastic housing on the bottom is cracked and it sprays water causing the pump to run a long time and eventually trip the breaker from overheating. Apparently they don't make Myers pumps anymore. Hopefully the Goulds holds up.

@truenorthmuskoka9077 3 жыл бұрын

great video. My pump failed the other day due to some sludge getting trapped in the pump and the previous owners didnt install an alarm float. luckily I found out I had a problem when my tub wouldn’t drain. I too have to install a slip joint to remove the pump in the future. My pump is 20 yrs old so thats really good. I just bought a new hydromatic pump also made by Pentair and an alarm float. Will be installing soon.

@marksurface1037 4 ай бұрын

I am in the same boat but sinking. My husband Mark Surface is in a wheelchair and very disabled and we are 64 with 0 family! Had no idea we had a sewage tank pump to the sewer system. I had rocks instead of grass. The workers dug up the opening with 3ft of soil deep On the rocks. I bought a pump for 700!!! And will have to figure it out myself. A neighbor said he would help but that may not be true. Our home is 19 yrs old and we had no idea about the tank! Husband on Dialysis and we are on Social security and barely making it before. No possibility of calling a plumber. The toilet flap was not seating correctly and our water bill is also over 800.! Guess what 6 months ago a water main leak. Thank you for your video . I pray God will help me. 😢

@glmccready Жыл бұрын

That was great. Thanks. I've replaced about 10 submersible well pumps. This looks like a "might can do".

@albo2006 3 жыл бұрын

thanks for the very helpful & enlightening video.

@reelguyoutdoors5536 3 жыл бұрын

Great helper you have there!

@richumbel2977 2 жыл бұрын

Good video. Very helpful. Many thanks.

@SBuchan 4 жыл бұрын

Great tips - thanks for sharing

@bignedu4871 4 жыл бұрын

That's a very nice one. Thank you.

@kirkoneill1387 2 жыл бұрын

I'm from Southern Ontario, Canada. Most places I've visited just use gravity fed to a leech field. So a dual chamber tank and a leech field. There was one with a mound. But it had multiple tanks about two or three with a box coming out of the ground with a red light and an alarm

@swerner4781 3 жыл бұрын

Thank you. This was a big help!

@TheDjacob 4 жыл бұрын

People pay my company a lot for this process usually two pumps on average but damn you saved your self some money just make sure your wire those wires up correctly

@toto83601 2 жыл бұрын

Great video man! Really help, thanks

@aardvark102431 Жыл бұрын

Awesome video. Thank you for preparing it.

@ozzy2753 4 жыл бұрын

Thanks for the video, great video

@timothygregg2734 Жыл бұрын

Good video. It convinced me to call in a pro.

@bryanbatts 2 жыл бұрын

Awesome instructions!!

@jmrandom194 3 жыл бұрын

Great video! My light just came on and my pump is 15 years old so I assume thats the problem. What type of pump do I search for? I assume there is a specific type of pump for this.

@Htown82 2 жыл бұрын

Excellent video

@mx6you 2 жыл бұрын

I recommend testing the pump in a large 5 gallon bucket before installing (even better to have a hose refilling the bucket as the pump runs). Last thing you want is to install a new pump only to find out it is not working.

@undrcvrmn1 4 жыл бұрын

Great video. Thank you for doing it. Should you have tested the pump before dropping it in the hole?

@MrJazzSaxophonist 2 жыл бұрын

No need to test the pump necessary, however, testing the floats before dropping them in is always a good idea

@ronaldkrigin6280 3 жыл бұрын

I work with these. Rubber gloves are a cheep investment.

@JoeRocket-sf6qs 3 жыл бұрын

Gloves are for dirty stuff like in the tank lol

@calebjordan5933 Жыл бұрын

Sissy

@HometownExcavationandSepticSer 6 ай бұрын

Cheap

@martella13 10 ай бұрын

Thanks for the vid!!

@JoeRocket-sf6qs 3 жыл бұрын

That's a baby system,Myers is a good pump.water in these tanks will not freeze, geo thermal keeps it from doing so, unless ur in Antarctica. I installed and repaired these stations for years in cities tho not house septic very often.

@boner69699269 2 жыл бұрын

So I'm wondering if you had any problem with these pump I'm looking at doing mine as well quiet a few people recommend liberty pump but i read reviews on both of these and they are pretty good

@kristentorres8329 3 жыл бұрын

Lucky you had that cute assistant!

@RMSpeltzFarm 3 жыл бұрын

thank you

@tlr8879 Жыл бұрын

Great Job -

@timdiemer2017 Жыл бұрын

I use a small submersible to drain my tank when necessary. If the alarm isn't functioning water can back up into the blower pit and ruin your blower motor.

@timr804 3 жыл бұрын

I am now replacing mine the 2nd time. Both times I have found mostly small pieces of plastic, like wrappers, twist ties, that must have made it through the drains. This caused the pump to fail. I would not use electrical tape for that reason. Just use the zip tyes and hose clamps.

@bradm2116 2 жыл бұрын

Please don't use zip ties I typically see them only last about 5 years b4 they rot away and either the floats falls to the bottom.of the tank and either won't start the pump or worst case won't shut the pump off until it burns out amd the pump can suck up the zip tie and bind it up

@marksimon1963 4 жыл бұрын

My pump just failed. only difference is that it is -29c today. I had the tank pumped out to buy me some time but will need to wait for a break in the cold weather before I can replace the pump.

@Helloreality101 Жыл бұрын

Thank you!!

@michaelorozco8323 4 жыл бұрын

A question is pomp working day and nigth without stopping ??

@kirkoneill1387 2 жыл бұрын

So you just have the dual chamber septic tank, and pump chamber?

@Payton20ADZ 2 жыл бұрын

Our septic tank backfills we do not have any pump to force the water to the leech field. Would that fix the problem?

@theapaigedpt 4 жыл бұрын

How did you determine it was safe to 'drop it in' without entering the tank and attaching the pump to a base? If it is cast iron, will it settle itself? I need a grinder ejector pump replacement but the plumbers near me state they don't do this repair. Smh.

@mrbigtuna240 2 жыл бұрын

Most pumps have little feet and sit fine on the bottom of a concrete tank. I’ve only seen bases in plastic tanks and they just sit no attaching to the base? Would you actually expect someone to enter a septic tank or pump chamber?

@5150mk Жыл бұрын

How did you get the pipe to align with the exsisting out flow pipe when you added that reducer? Didn't it raise the stand pipe? I used a PVC repair coupling the kind that slides like a telescope to get the perfect hight. I also replaced mine. After 19yrs I discovered the small zip ties had cut thru the electrical cord from the vibration of the motor turning on and off. Shorted everything out. I replaced the zip ties wirh 20mil 2in tape. Good thing I didn't have a methane explosion, And please wear protective gloves next time.

@mrbigtuna240 2 жыл бұрын

The floats and pump power wire should be in separate conduit as they are different voltage also there should be a union on the discharge so you can easily replace the pump. No check valve and probably not drilled for airlock.

@jad7306 4 жыл бұрын

What hp do you use?

@tanozVIP 4 жыл бұрын

Exelent video! Tnx!

@johnnycavazos4788 2 жыл бұрын

Is that the whole to get your tank pumped out ??

@josephalsheimer9866 4 жыл бұрын

Can you help. my pump disconnect is 6ft down in hole any idea how to get to it?? Thanks

@darrenturcotte7799 4 жыл бұрын

Joseph Alsheimer Still in a shitty situation?

@thelazyhandyman8581 4 жыл бұрын

Dam this pump! I replaced one last yr and I check today my sewage water was upto the max and my electric box under gross water! Now I have to see why it's tripping my breaker and not running my pump!

@xephael3485 5 жыл бұрын

This is the sort of DIY I'm fine paying someone to do... surprised you didn't use new PVC.

@RMSpeltzFarm 5 жыл бұрын

You know I didnt really think about that, maybe I should have

@xephael3485 5 жыл бұрын

@@RMSpeltzFarm They say 50-70 years, so you're probably fine, and you've added the rope. Eventually the entire field will need to be replaced. I have the habit of installing new whenever it's cheap to do so.

@sandyelliott3350 5 жыл бұрын

Gloves required?

@RMSpeltzFarm 5 жыл бұрын

yes that be good idea, but ignorant farmers lol are quiet the breed lol

@jesscolliflower5531 3 жыл бұрын

Montana bout cold as Minnesota guess them check valves may have caused a field failure??

@truenorthmuskoka9077 3 жыл бұрын

here in Ontario Canada we install check valves. My drain froze up a couple years ago and now I wonder if it was caused by the check valve. Two separate plumbers told me to remove the check valve so the water doesnt freeze between the pump chamber and the drain field. I just wonder if this can cause any damage to the pump.

@j1203n7 4 жыл бұрын

Wear gloves thanks!

@bjg770 4 жыл бұрын

What’s the hp?

@user-kg7sg5uc4f 5 ай бұрын

do you need to have your tank empty to do this?

@ronsmith8434 4 жыл бұрын

Seems like your floats are very low .... mine are pretty close to top of my tank. ?

@ilovefunnyamv2nd 3 жыл бұрын

yeah, I noticed that. I recently replaced a dead pump in my septic, and just decided to replace it the same way as what was in there previously, switch a little above the pump, since I didn't know how it was planned out. I really regret not moving the float, and the alarm floats up another foot or two up. If I can not regret that decision for at least 10 years, I won't complain TOO much

@boxerpop82 8 ай бұрын

Should have drilled a 3/16" weep hole in the discharge pipe to prevent airlock. The weep hole attatched to those pumps are too small and will get clogged.

@shawndunleavy892 Жыл бұрын

Stainless steel clamps, not zip ties. We use Gould’s, I know they are only sold through wholesalers who generally only sell to professional contractors but in my opinion there’s a huge drop off between Gould’s and Myers.

@matthewnovik4050 Жыл бұрын

why the rope.. can you just use the pvc outlet pipe to raise the pump?

@philbert85 2 жыл бұрын

Zipties are the required clamp.

@alkoia 3 жыл бұрын

I want the shit alert too where do i get it at shitmart? pls answer.

@davidfraser4830 5 жыл бұрын

You are lucky it happened now and not in January. Old Murphy usually does these thinks at the worst moments haha.

@RMSpeltzFarm 5 жыл бұрын

you are right its blessing it died now and not in winter

@DavidSmith-jj5pr 5 жыл бұрын

I bet that smelled wonderful ;)

@RMSpeltzFarm 5 жыл бұрын

Yes it does lol

@michaeltucker605 2 ай бұрын

If you’re healthy you can rely a great deal on your immune system to keep you from getting sick from coming into contact with germs. Your immune system needs the practice. However I do recommend rubber gloves.

@undrcvrmn1 4 жыл бұрын

Unions and bushings..........

@paulgajewski5926 Жыл бұрын

How much for that pump

@ttlkamd 8 ай бұрын

4 years later. How is the Myer pump doing??

@RMSpeltzFarm 8 ай бұрын

Been great, I have not had issue with it, very pleased so far

@narcisodelacruz3654 Жыл бұрын

Cómo traducir el vídeo a español

@dereknadeau5843 3 жыл бұрын

You left the pump by the plumbing going down to the pump lol

@narcisodelacruz3654 Жыл бұрын

Traductor a español

@dylanshrader9835 Жыл бұрын

Golds pumps last longer then 11 years , the floats are what will go bad first, you probably replaced a pump for no reason next time unplug the float and just plug the pump in to make sure it runs

@RMSpeltzFarm Жыл бұрын

We did try that, the motor was fried, we actually took it apart and the motor was seized up=(

@chrisbradley3176 6 ай бұрын

Where is your gloves?

@ThanhTran-pv4kl 4 жыл бұрын

My pump just went, this one lasted about 20-30 years, it's a small pump, a 1/2 hp Rigid brand. 15 years ago it stopped working and a friend picked it up from the tank and cleaned/wiped it off and it worked the whole time.. now, i dont know what's wrong but pretty sure i need to replace the pump.. replaced it with 1/2hp Everbilt brand

@theoutlaw2395 4 жыл бұрын

Good service life on that pump.

@stephenwebb921 4 жыл бұрын

Good luck with your new pump. I just replaced mine after 23 years. Just don’t expect any pump today to last that long. The way things are made now as well as the regulations, they just won’t last like they used to.