DSG Mechatronic 7 Speed Gearbox Hydraulic Accumulator Repair Kit Leak Fix VW AUDI SKODA SEAT Install

Рет қаралды 100,267

4 жыл бұрын

Link to purchase item: x8r.co.uk/audi/dsg-repair.htm...
Symptoms Of Fault
VW 06079 GENERIC P17BF. VAG 006079/10902/10903, P17BF, Hydraulic pump - play protection.
VW 06300 GENERIC P189C. VAG 006300, P189C, Function restriction due to insufficient pressure build-up.P1895, Reduced function because of pressure drop.
Loss of power (gone into neutral), no gears can be selected, hydraulic pump runs constantly, you can see hydraulic fluid bubbling/rising out of the breather, flashing spanner icon where gear number usually shows.
The Fault
The accumulator mounting within the DSG unit fails causing these faults
Within the DSG Mechatronic unit, the hydraulic pump pushes oil through the filter towards the pressure accumulator which provides the system with oil pressure when the pump is switched off.
The cast metal part that the accumulator seats in to is too thin for the pressure exerted, this causes this part to crack and for the system to lose pressure causing the mechatronic unit to fail.
To replace the cast metal part is a very time-consuming job and would only fail again in future.
The Solution
Our unique design repair restores full function to the DSG unit
Our unique repair kit allows you to repair the failed cast block. Our accumulator base mounts to the cast block restoring full function, our improved design accumulator simply then screws in place, providing a full-term repair for this common fault.
For some types of transmission, the repair is possible in situ - provided the mechatronic sump can be removed in situ. Even if this isn’t possible and the unit has to be removed our repair is still far simpler than replacing the cast block which requires complete disassembly of the Mechatronic unit.
No programming is required pre or post installation. After the repair, pressure is restored and normal operation resumes.
Vehicles Affected
The below is for guidance only, please check before buying that you have a DSG7 speed gearbox, any doubts let us know your VIN before purchase and we can look up to be sure.
Compatible with following gearboxes: DSG 7 gearbox models
0AM 325 025 M Z1L
0AM 325 025 M Z2B
0AM 325 025 M Z2N
0AM 325 025 K Z6D
0AM 325 025 K Z6C
0AM 325 025 K Z6T
Associated part numbers:
0AM 927 769 D
0AM 927 769 K
0AM 927 769 G
0AM 325 025 D
0AM 325 025 H
0AM 325 065 N
0AM 325 025 J
0AM 325 065 L
0AM 325 065 S
DQ200 DSG
Please check your vehicle has a DSG 7 speed gearbox.
Audi A1 2008-2011 1.4l 1.6l 7 Speed
Audi A1 (8X) with 7-speed dual clutch gearbox Model Years 2011-2016
Audi A3 (8P, 8V) with 7-speed dual clutch gearbox Model Years 2008-2016
Audi Q3 2011 1.4l 1.6l 1.8l 7 speed
Audi TT (8J) with 7-speed dual clutch gearbox Model Years 2012-2016
SEAT Altea / XL 2009-2011 1.6l 1.8l 7 speed
SEAT Ibiza 2009-2011 1.2l 1.4l 1.6l 7 speed
SEAT Leon 2007-2011 1.8l 7 speed
Skoda Fabia 2010- 2011 2013-2015 7 speed
Skoda Modela 2011 1.4l 1.6l 7 speed
Skoda Octavia Model Years 2009-2015 7 speed
Skoda Superb Model Years 2008-2015 7 speed
Skoda Rapid Model Years 2014-2015 7 speed
Skoda Roomster Model Years 2013-2014 7 speed
Skoda Yeti Model Years 2013-2015 7 speed
Volkswagen Beetle / convertible Model Years 2011-2015 7 speed
Volkswagen Bora 2010-2011 1.4l 1.6l 7 speed
Volkswagen Caddy Model Years 2010-2015 7 speed
Volkswagen Golf / Golf Plus Model Years 2007-2015 7 speed
Volkswagen Jetta / Jetta Wagon Model Years 2008-2015 7 speed
Volkswagen Lavida 2010-2011 1.4l 1.6l 7 speed
Volkswagen Passat Model Years 2008-2015 7 speed
Volkswagen Polo Model Years 2007-2015 7 speed
Volkswagen Sagitar 2009-2011 1.4l 7 speed
Volkswagen Scirocco 2008-2011 1.4l 7 speed
Volkswagen Sharan 2010-2011 1.4l 7 speed
Volkswagen Tiguan 2011 1.8l 7 speed
Volkwagen Touran 2010-2011 1.4l 1.6l 1.8l 7 speed
And other models with a DSG 7 speed gearbox.
You Will Receive
1 x Replacement accumulator (complete with o ring)
1 x Accumulator housing / cast block adapter (complete with o ring)
1x Accumulator spanner.

Пікірлер: 48

@jsanders240782 2 жыл бұрын

Been quoted £600 to replace this but I was told price was high as need special tool but from video looks fairly straight forward also spoke to a gearbox company and they said should take two hours to do

@Xopher222 4 жыл бұрын

Excellent video to use for my college writeup. Thanks a lot guys.

@X8RLtdUK 3 жыл бұрын

Glad it was helpful! - Georgina, X8R Ltd

@ssucharith 2 жыл бұрын

Superb video fixed 2 skoda superbs thanks to this confidently but the product if you get the same fault codes.

@kervinorosco9887 2 жыл бұрын

Hi after refilling is there any other procedures or you could drive the vehicle?

@kykykykykkkkyy250 3 жыл бұрын

Whats the torx specs for the cover?

@AcrylicHD 7 ай бұрын

Hi, what type of grease did you use for the sealing of the O ring?

@kurtdavis6309 Жыл бұрын

My dsg has all the symptoms but I don't see a crack where the accumulator sits. Would it still be the accumulator at fault?

@hantheman_666 Жыл бұрын

Can this cause the epc light to come on after the repair kit has been installed?

@alomar834 9 сағат бұрын

Hello, what is the reason for the oil leakage from this part?

@SamSam-bf6ir 3 жыл бұрын

I have the following fault: P1895, Reduced function because of pressure drop. and the accumulator is constantly running, I can see the hydraulic fluid leaking onto the floor but can't see where from doesn't look to be from the breather at the top. Would this be caused by the housing being damaged or a leak around the mechatronic gasket?

@X8RLtdUK 3 жыл бұрын

It's difficult to diagnose, we would recommend draining dowm the mechatronic unit and inspecting the accumulator and the block near to the accumulator for damage.

@_Pet_Tech 2 жыл бұрын

How to release the pressure inside the pressure accumulator if an attempt to replace is made while the gearbox is still attached on the car? Is draining the oil and disconnecting the battery enough to safely open the gearbox oil pan and unscrew the pressure accumulator?

@X8RLtdUK 2 жыл бұрын

No, it should only be unscrewed if it is clear the accumulator or block is cracked and as such the system isn't holding pressure.

@dontefa4653 3 жыл бұрын

which oil should i use for it?

@sara78130 3 жыл бұрын

Green oil like power steering 1 litter

@a.h7761 2 жыл бұрын

How do you deepressurise the accumulator please

@X8RLtdUK 2 жыл бұрын

Hi there, our kit is only suitable if the accumulator is cracked and therefore already has depressurized (see fault- loss of pressure). - Georgina, X8R Ltd

@dharmendraarya3013 3 жыл бұрын

What is the cost of the accumulator base? I want it for 2009 skoda superb DSG

@X8RLtdUK 2 жыл бұрын

Hi there, we do not sell the accumulator base separately. Please see our website for all our DSG kits here: x8r.co.uk/audi/dsg-repair.html - Georgina, X8R Ltd

@Lincoln1242 2 жыл бұрын

How do I order this kit? And will it fit my 2015 Seat Toledo 1.4 TSI 122HP 7 speed DSG?

@X8RLtdUK 2 жыл бұрын

If you can contact us with your reg or VIN we can check compatibility for you. These are available for purchase here: x8r.co.uk/search/?cat=0&q=dsg

@dasunkrishantha6178 2 жыл бұрын

Hi, Im getting Following two error codes. P279700 - Auxiliary transmission fluid pump performance P17BF00 - Hydraulic pump play protection And my vehicle is Audi Q2. I think my Mechatronic unit is slightly different. I think its DQ200. Do you think by changing repair kit it will eliminate the faults.??

@X8RLtdUK 2 жыл бұрын

Hi there, we recommend taking the sump off your DSG unit and checking the accumulator. If there are any cracks/visible signs of damage, or if there is bubbling from the breather tube then it is likely this kit will solve your issue. - Georgina, X8R Ltd

@farishadju5227 2 жыл бұрын

replace valve body it is better.

@kurtdavis6309 Жыл бұрын

Does this kit work for 2013 vw Cross Polo

@X8RLtdUK Жыл бұрын

Hi there, please send us an email to sales@x8r.co.uk with your UK reg/VIN and we can check if it is compatible for you. - Georgina, X8R Ltd

@batchimed7392 2 жыл бұрын

My car has DQ500 DSG7 transmission. It has been leaking from the seams, so I am guessing it has to do with pressure build up. Does my transmission also have this accumulator inside? Thanks in advance.

@X8RLtdUK 2 жыл бұрын

Hi, we would need a few more details about your vehicle, you can reach us at sales@x8r.co.uk or on 01843 446643.

@user-ol6qs6en4v 4 ай бұрын

I’ve got a code 35494 gearbox drive fine don’t know what the issue can be

@X8RLtdUK 3 ай бұрын

Hi, you are best off visiting a mechanic. It would be difficult to diagnose accurately on the internet. - X8R Ltd

@zsorzs1882 4 жыл бұрын

Hi. How many liters need put into the gearbox?

@X8RLtdUK 3 жыл бұрын

1 litre is required. - Georgina, X8R Ltd

@gawainbrown 11 ай бұрын

What fluid do you recommend @@X8RLtdUK

@rolphbluesky8537 9 ай бұрын

i have no error codes car drives in 2nd and 4th is there another issue

@X8RLtdUK 9 ай бұрын

Hi, we recommend taking off the sump cover and checking for any damage to the accumulator and the housing it sits in. If there is damage then our kit may fix the issues. Although usually error codes will be displayed. - Georgina, X8R Ltd

@rolphbluesky8537 9 ай бұрын

@@X8RLtdUK i cant see any damage but the accumulator wasnt tight and the blue o ring looks rooted i suspect pressure coming past the o ring

@X8RLtdUK 9 ай бұрын

@@rolphbluesky8537 you're more than welcome to order our accumulator kit if you are sure that this is the fault. Without any fault codes or a garage diagnosis it will be impossible for us to confirm if our kit will resolve the issue. - Georgina, X8R Ltd

@Chazebrimbor 4 жыл бұрын

I would like to purchase but cannot find on the X8R website? Please help

@benhodkinson4696 3 жыл бұрын

Amazon

@reymysteri0sucks 3 жыл бұрын

There's recall for this

@elenijasmin 3 жыл бұрын

In the uk?

@nickd2070 3 жыл бұрын

I'm still waiting on the fix for my 2013 Jetta Hybrid. They sent me the letter Dec 2019 but I guess the fix won't be ready until March 2021. Seems like a huge job.

@nickd2070 3 жыл бұрын

@@elenijasmin Not sure about the UK but here in the states I received a recall letter for this in December 2019. Fix isn't available until March 2021.

@HeKuTK0 3 жыл бұрын

In Australia I just received a letter about this recall. Hopefully they will fix it properly, not like in the video they fitted a new accumulator into the old one

@masterguru88427 3 жыл бұрын

@@nickd2070 Is it campaign/recall 34J6? The VIN for my 2013 Jetta Hybrid didn't get included in the recall.

@kervinorosco9887 Жыл бұрын

My car still isn’t working, this worked a few days and then it came right back