VW Polo GTI Water Pump Replacement

No video

VW Polo GTI Water Pump Replacement

Рет қаралды 17,198

Four Rings Auto

Күн бұрын

Replacing the water pump on a 1.4tsi twin charged polo gti 6R.

Пікірлер: 15

@jwester7009 Ай бұрын

You are missing one crucial step which is the magnetic clutch adaption process (can be done from VCDS). If not done there is a serious risk that the magnetic clutch will start slipping. This very quickly result in so much wear that you would have to replace the water pump again

@tiddybearkush Ай бұрын

No it's not needed...

@dankenney5212 Жыл бұрын

Great video. Thanks so much.

@FourRingsAuto Жыл бұрын

Glad you enjoyed it!

@rahshidrakhoon3252 Жыл бұрын

I have bought a golf 2012 1.4tsi and have done the timing chain but the only issue I’m confused about is that is that waterpump belt meant to spin when the engine is idling or is it just meant to move when the rpms are over 1500

@mattwilk10 4 ай бұрын

Should the supercharger belt turn while the car is idle?

@davidrees5544 Жыл бұрын

I couldn't get the cover on the supercharger free and didn't want to break it. My solution was to put a luggage strap around the tensioner pulley secure it to the R driveshaft and tied it off on the lower suspension arm. Then I used a wedge to push the cover over to make room. put the new belt onto the supercharger pulley and over the coolant pump inner pulley. used a pin punch to align the pump to the block, put two fasteners finger tight to position the pump to the block. then secured all three and finally removed the luggage strap. I hope this helps others.

@bullit2525 Жыл бұрын

Was that to leave the supercharger cover in place? I am soon to be doing timing chain, but think water pump has to come off to get to the bolts holding the timing cover?

@loran740 Жыл бұрын

@@bullit2525 I just removed it with all the sound foam, now makes quite loud supercharging whine 🤌

@davidrees5544 Жыл бұрын

@@bullit2525 there are two clips on the top and the same on the bottom of the supercharger cover. On mine, they were difficult to access and I feared they would snap if I forced them. You will have to remove the two belts on the water pump to remove the timing cover. You may be forced to remove the pump as access is small to non-existent. I removed mine.

@smartbidshop1 6 ай бұрын

Do you need the supercharger cover on ? Can we just remove it

@79johnnykage Жыл бұрын

Nice vid pal. I’m looking to order one for my 2012 polo GTI wound u happen to the the oem reference’s number so I can order the correct water pump/ super charger clutch. Thanks