Thanks! Full video here on my channel 😃 kzfaq.info/get/bejne/g7uZd8tiuLzFg3k.htmlfeature=shared

Thank you 🙏. I do agree, the music is not the best

Thankyou 🙏🤘🥇

Full video kzfaq.info/get/bejne/g7uZd8tiuLzFg3k.htmlfeature=shared

I probably haven’t cleaned enough off but I did sponge a fair bit off as I went so maybe that saved me a bit of cleaning at the end

@@SamDaviesBuilder I was able to clean until I got to row eight. At that point, I used a fibreglass dome to set the bricks, which blocked access to the inside. I then had to wait 24 hours before I could clean the brickwork, by which time it had set like stone. The whole build is on my channel if you're interested.

@@Mike-Diamond I will check out some more of your oven videos! The fibreglass dome sounds like a good idea, I used sand but it was a pain to clear out afterwards

How many bricks did you use?

Simple, lay down a plastic protection

Mix ratio is 1 fondu cement, 2 fireclay and 2 sand (I think!). Ceramic board then firebricks as a base, firebricks for the walls then ceramic blanket to wrap outside of walls. Mesh on the blanket then a few layers of perlite mixed with cement. All the materials I mention will be mentioned in the long version of this on my channel

@@SamDaviesBuilder Thank you dear

The way you suggest is certainly do-able but the sand can compress differently as you place the blocks around it and inside where you can’t see because of your sand you may get steps in the bricks. You’ll only spot those steps at the end when the sand is out. Also you can’t ensure your joints on the inside face are full and tidy until the end when you’d have to get inside, clean off any mortar sticking out and fill the joints that were not full. I use sand at the end of the dome when it gets too steep to get the bricks to hold but it’s horrible climbing inside to tidy all the bricks up once the sand is out and that’s just doing the last few courses. If you did the whole dome like that it would be a nightmare! Hope you can see my points…

@@SamDaviesBuilder It works. I've done 3 of them. Close off the opening then for the final shaping use a little cement with fine sand then it sets. Easy Peasee Lemon Squeezy.

@@brikkijim how do you ensure the bricks are tidy inside as you can’t get to them until the whole lot is finished and you dig the sand out?

@@SamDaviesBuilder I cut each piece extremely close. The fireclay is fairly soft until fired. I scrape clean. I also parge dome with fireclay heatstop 50. I had one that still has parge for over 15 years. Just don't touch it.

@@brikkijim sounds like you do a thorough job!

😄👍 thanks

Full video kzfaq.info/get/bejne/g7uZd8tiuLzFg3k.htmlfeature=shared

I call it the 'indispensable tool'. It is a castor wheel (same as off a trolley) with the wheel part taken off and a piece of wood bolted to it. It can then rotate and give the circular shape

haha yea but where the hell would you find such a thing!@@SamDaviesBuilder

@@tddtv any good DIY store would sell a castor wheel, only around £2

That’s what’s called an ingenious improv tool 😂

@@JesusOnaRampage I like that name too 🤣🤣

Full video here on my channel 😃 kzfaq.info/get/bejne/g7uZd8tiuLzFg3k.htmlfeature=shared

They are half bricks, you have to cut them in half to get the curve. Then there’s angles cut off them as the curve tightens

@@SamDaviesBuilder alright!

Thanks! Full video here on my channel 😃 kzfaq.info/get/bejne/g7uZd8tiuLzFg3k.htmlfeature=shared

Yep you've got it! They work well. One thing to note, when you close the dome in to the very top you want a different shape so the top isn't as much of a curve. A few people have told me this makes the heat distribute better so it's worth looking into. I have just got a fibreglass former to build over and remove after its set for the very top of my next dome

It was roughly 270

🎶🎧😃

Full video kzfaq.info/get/bejne/g7uZd8tiuLzFg3k.htmlfeature=shared

On my channel 😃 kzfaq.info/get/bejne/g7uZd8tiuLzFg3k.htmlfeature=shared

I can’t remember the length of it. You just set it to what diameter you want your oven

And how many brick did you use? You cut them in half? Thanks very much

@@josefslaj6344 yea I cut them in half. Sorry I don’t know how many I used but I’m doing another one in the summer so make sure you subscribe

😃😃 Thanks 🙏

Full video kzfaq.info/get/bejne/g7uZd8tiuLzFg3k.htmlfeature=shared

Are you in the UK? There’s a few suppliers in the UK also on EBay

Silica sand, fondu cement and fireclay

Thanks :)

Thanks 😃🙏

So flatter on the top of the dome and not a even curve is it?

Thanks 😃😃

@@SamDaviesBuilder sama-sama 🙏🏻

Thanks 🤩

Full video kzfaq.info/get/bejne/g7uZd8tiuLzFg3k.htmlfeature=shared

Please see the full video here :) Pizza oven build kzfaq.info/get/bejne/g7uZd8tiuLzFg3k.html

Thankyou 😃

Thankyou 🙏😃

Full video kzfaq.info/get/bejne/g7uZd8tiuLzFg3k.htmlfeature=shared

😃🙏 thanks

Full video kzfaq.info/get/bejne/g7uZd8tiuLzFg3k.htmlfeature=shared

Sorry it’s bad free music

😃🤘

Full video kzfaq.info/get/bejne/g7uZd8tiuLzFg3k.htmlfeature=shared

Yazidi?

This is how we do it in the UK

Это кладочная смесь. Типа универсалки, только печная.

@@user-cp1qq3vd6c yes that's right

😃😃🙏

Full video kzfaq.info/get/bejne/g7uZd8tiuLzFg3k.htmlfeature=shared

I apologise for the music

Apologies

😃