For anyone else that attempts this, all the videos I saw damaged the Fuel Pocket, either the edges got warped from prying or holes were drilled, so I thought the Fuel Pocket was just sacrificial and ordered that along with the Lock Actuator, but I tried something a little different to see if I could get the Fuel Pocket out without damage and it worked! The Lock Actuator was the broken part for me, so I just used pliers to pull on it and that pulls out the left side of the Fuel Pocket with enough space at the edge to slip in a pry tool to keep it pulled out, then using my hand/fingers along the top edge, I just kept pulling out the Fuel Pocket left to right, a little at a time, until it was free. None of the clips broke. This was done on a 2015 s3, and your milage may vary if you are too rough with it, but it does need strong enough yanks to get it free, just nothing crazy.

Hey man, thanks for that tutorial. I've just got it replaced today on A6 C7.5. Took me maybe 15 minutes and I'd score difficulty to 2/10. The actuator cost was £13 and trim tools £3.99 out of Amazon.

Awesome video, it’s basically the same on the A1 except the trim is circular rather than a rectangle. Thankyou very much

Great job have the same thing going on our audi A6. I’m going to do the same thing audi. Little did I know that the orange cable for the emergency release was actually broke when I went to try it. So I have to feed that through. I took out all the interior on the right side of the trunk to get at it. This way is much easier. Thanks man again greatly appreciate it.

Thank you man. Saves me 300 bucks at the garage.

Thanks it was excellent tutorial

Thanks for the video. I was going to order an actuator but sprayed some WD40 on the stem that fits into flap. Overnight it seems to have done the trick. The fuel flap now consistently opens with the remote. If I become stuck again I’ll replace using this method but probably pulling from the stem to avoid damage to the seals.

Thank you, I found the Trim Tools worked well for getting started popping out the main body, this was on a 2010 A4 B8 Avant

R/o bro, well shown nd said 🙌🏽😄 finna do this right now as every usual guy/men we learn from ppl like you much love bro 🖤

Lot of help thank you for going through it step by step aimt many vids of this on yourube

Mine is still locked shut and pull cord dose nothing. Any idea how to get flap open?

Thanks, mine got stuck and only way to get it open is to use my debit card

Awesome video, where did you get the tool kit with all the blue pieces and the hex screw driver ?

Very useful, well done 👍

Why didn't you just pull the red string inside the trunk?, this would open the lid, then just take the fuel cap off, and stick your fingers inside the rubber and pull firmly on the left side (side of the micro switch). If you can't pull, on both sides, from above and below, you have places to insert a small screwdriver that forces internal tongues downward. This will release the part that must be undocked by the left side where the micro switch is.

The corporate 😂

OMG 🥵 USE YOUR BRAIN IF YOU HAVE !!!!!!!!!

👌👌👌👌

Electronics made in Italy, therein lies the problem 😂

The corporate?

its stupid but it is better to just go ahead and poke holes to get the tabs that way you dont complete destroy the seal around the edge like you did. And if you keep the holes small enough you can use a torch to kind of seal the holes halfway back so it doesnt look to terrible. Either way this is a dumb design by Audi and you cant even get to the clips from the back by taking the wheelhouse liner out. They want you to break it and replace it so they can keep raking in the big bucks

Honestly I'd just leave it unlocked, of someone wants to steal ur gas they can pry it open with a screw driver in 10 seconds

Dont do this people.