So informative thank you. I've got this problem after 10 years of completely trouble free motoring. I have kept my tyres in good condition until this current lockdown and I am a nurse so I have continued to work through the lockdown without being able to access either a service or new tyres. My rear tyres have mismatched wear now. West Auckland Hyundai have been good. Thanks for this video. Makes much more sense now.

Had this happen to our 2015 model with 90,000km on the clock last year. Suspect it happened after towing up a steep bank on loose gravel (took a couple of attempts to get up) also had 4x4 lock switched on. Car was six months out of warranty. However, Santa Fe dealership put in a goodwill application on our behalf and all was covered. Cars been like new ever since. Thanks for the great video detailing the problem.

In the previous versions of these vehicles, the CM range, the transfer case was prone to fail if the owner hadn't ensured to make sure the tyres should all be the same size with equal wear as you mentioned. The service book also mentions this. Plus if you need to replace one tyre, and the other 3 are quite worn, you need to replace all 4 otherwise the system will engage the rear wheels on the road and just as in all part time 4wd systems something will eventually brake because the tyres won't slip to relieve the stress on the drive train take care of the tyre wear and the required tyre rotation and you shouldn't have any problems

Thank you for the video; it was helpful; pretty much what I expected. I went to use the AWD and there we were without it, but, my vehicle has 350000km on it, I didn't pay much for it three years ago so it owes me nothing. Probably the coupler was going when I got the car, tire size was well matched and it has done no heavy towing as far as I can determine but it has failed. In view of the cost of a repair, the vehicle isn't worth spending a lot on and I was lucky to find another, again at a very good price and we have checked the drive, and it's tight as a new one. I'll part with the old one as a 2WD. A lesson well learned. Thanks for the information, greetings from Nova Scotia, Canada.

I found out the hard way this past Sunday (2/7/2021) I’m in the Southeast US. 73,000 miles. 2015 Hyundai Santa Fe Sport 2.0 turbo. Hyundai is going to fix it thankfully. It was the front differential like you described.

Yikes! That's an expensive repair Jonathan! Glad it was covered for you! 👍

Just discovered this exact problem with our 2015 Hyundai (108,000Kms; Melbourne, Australia) - 7months out of warranty!! Doh! No idea until the service centre diagnoses it and quotes $3000 for parts. Thanks for the video - nicely put together and clear! Car has been really great until now. Best of luck! Very kindly.

I've got a 2008 Santa Fe, same 4wd system. Last winter the 4wd worked wonders, during the summer months I've had a control arm fail and wear out the front tires just enough that it's noticeable on the inner part of the tread. This winter I've "suddenly" got no 4wd, no warning lights, no sounds to indicate failure, it just doesn't work. Prop shaft does not turn when the car is lifted, but the rear wheels turn when the prop shaft is turned by hand... Seems to be the same issue you had. Thanks for the nice video explaining this surprisingly common fault :)

87000 miles on my 2013, so far no issues with the awd. I drive in snow every year, use good tires and have been very happy with the performance. This gives me pause, however, seems like it might be a weak spot in the system.

Thanks Badger! Will keep this in mind to check when buying our second hand SF

Great video Badger! Could it be people engaging the centre locker whilst having wheel slip, or does the car not let you do this?

Thank you for your video! I had the exactly issue with my Hyundai Santa Fe 2014 when it got 170000 km, no snow or hills only highways. The rest of transmission parts were ok like new ones. As you well said, the point here is to keep the tires and alignment in good conditions. After I exchanged the satellite box part the car is awesome again, with the 4 wheels working in the same time. No other mecanic issue with this wonderful vehicle.

Thanks for that Badger, very helpful. I bought from a dealer, a 2010 IX35 2.0 L CRDI just over 6 months ago, as a tow car for our caravan. Currently under 190 K km. The towing capacity is 1600 kg and the van weighs 1450, so that should be OK. I didn't know about testing the AWD on a hoist and so the 1st chance I've had to experience the AWD was this week, towing the van up a steep gravel driveway. The AWD did not kick in, but the 4WD lock worked after a 2-3 seconds of skidding at a bit above idle speed. 1 does this seem to be the same problem, just that it has not deteriorated fully yet? 2. should it be covered under the CGA as the 3 month dealer warranty period has passed? 3. other online forums talk about the viscous coupler, is that the same thing? Thanks

I just bought a 2012 Santa Fe GLS AWD with 3.5L V6 and only 17,800 miles. I'll keep my fingers crossed.

saw your post about a year ago when trying to figure out what the hard clunk was when driving in reverse. bought the car used from a private owner with 95 k miles on it and it was like brand new and had it checked out and all was fine. was driving in the rain when pulling uphill when i noticed no traction and just the front wheel slipping. Put it up and exactly what you said no drive shaft spinning. was debating fixing it with a used unit for $700 us plus $900 labor and fluid but, the car has the 2.4 theta engine which burns oil so idecided to just drive it in 2wd as its not worth repairing.too bad the privious owner wasnt up front because this could have been repaired under the original owner warranty for free. only bought it as i couldnt find any cars available when my like new honda crv was rear ended and totaled by the insurance company last summer. buyer beware and thanks for the posts. will be purchasing only hondas and toyotas as they are pretty much trouble free .

Excellent vid n educational. Hyundai SF has this problem all over

Thanks for your advice 😎

Thanks a lot for this message, I got the same exact problem and the car is fairly new

Hello. Great video. I have a 2013 Hyundai Santa Fe sport 2.0t and today in the snow my awd warning light was coming in intermittently when slipping and fighting for grip. I can’t find much info on it. Was wondering if you would have any opinion on it. Thanks cheers

Great video and very helpful. We've got a 2012 Santa Fe 224k has been very reliable until now. We use it to shuttle kids up and down the ski hill roads in NZ and handled it with ease over the last 5 years or so. Last week The car lost traction on a section of road that it would normally be a problem and the 4wd light started flashing. looks like we might be up for a new diff? CVs are up for replacement too.

Tks. Well Done. our 2009 Santa Fe, AWD coupling failed of course, right after warrantee expired. Now we are at 148K with good tires never towed anything and we have the thumping again, sounds like we are getting hit in the back. Thoughts? Thanks again

That is a huge flaw. I'm glad that it was under warranty for you.

Bought a 2015 Kia Sorento in December 2019. With just over a month left on the warranty, transfer case went. I had a feeling something was up. Had the dreaded clunk sound (feels like I actually hit a brick wall when it happens) when reversing, not every time though for some time before it went belly up. Also at times when taking a corner from a standing start, I'd get the dreaded rumble feeling and sound from the rear of the car. Long story short: I dodged a bullet. The repairs were roughly half of what I had paid for the car to begin with. Luckily covered under warranty, a month before it was out of warranty. Transfer case, coupling and rear diff replaced. Rebuilt gearbox (or so I understood), as well as new side shaft (again what I understood). The dealer that did the job was fantastic. The master tech that did the actual work, was absolutely excellent. Likely to sell it now though, as this scared the crap out of me. Looking for a Paj or Paj sport now.

Had a transmission front seal leak on my 2012 - got it repaired. Took the Santa for a test drive of 4X4 and noticed no power to back wheels. Given that the prop shaft does not spin when diff is locked - I suspect its the same issue as you had here. Also, given that the transmission has JUST been put back together, I'm loathed to have them dismantle it again, and was wondering if it isn't a better idea to leave this alone until my next transmission service in four years' time (it'll give me time to save up for parts and labour). Do you know if I am subjecting my car to further damage by not addressing this immediately? The fact that you said you've been driving around with this issue unaware for some time suggests that this issue wont cause further damage to the car. Thanks for your great vids - I've learnt so much from them!

Hi, we have a 2012 Santa Fe 3.5L Elite that needs a gearbox repair after we noticed reverse was not responsive as usual and jerky and then a series of quick jolts or misses driving the motorway. 105kms, tyres are different make after we got two new tyres that were different to the existing two to pass a WOF (Typer Power tech said this was ok). Also tyre size (mags) bigger than originals (as we bought like this). Could this have been the likely cause of issues we are now facing? Hyundai service centre has changed the inhibitor Switch and Transmission fluid has been changed to see if that would fix the issue but it hasn't. Thanks

I’ve got a 2013 model which has just lost AWD, no warning 120k on the clock. It’s Out of warranty now too, eek!! We’ve already had the transfer case replaced in 2019 after a failure and now this. It’s my wife’s daily driver, never been off-road. Had the aircon fail 3 times, electric park brake fail once. Eats tyres and we’ve always made sure they’ve been rotated by a 3rd party company because our dealer service said they don’t rotate the tyres during a service. Absolute lemon of a car but when it works it’s a real nice drive

Any way to weld that together? ive seen on trucks people weld rear diff Gears together with success.

I have a 2014 Hyundai Santa Fe, 59,000km. Description of issue: Road tested and confirmed noise. Took sample of rear diff oil and found to be very contaminated with metal fragments. Also removed the RHF drive shaft and found corrosion inside the transfer case and shaft. Excessive movement in differential to transfer case. Is this the same issue? We have been to the OFT / looked at Consumer Guarantees.

2013 13500k mine did the same thing. Haven’t had it fixed yet. 2wd is good for now. Full service history.

that's crazy that those splines stripped out, good thing for warranty

I purchased my 2013 Highlander as 2nd owner, 5 mths later front diff transfer case gone with $7000 for repair , it had had every scheduled service always at Hyundai 106000 kms, this is a severe manufactures defect! Hyundai have offered to pay half for the parts only $3000, I am now taking the dealership I brought it from (not Hyundai)to VCAT for the rest of the repair!

I own a hyundai santa fe 2010 AWD and had an issue with turning my wheel all the way to the left when the caar wouldn't move forward and stayed stuck. Then I pressed the gas and it made a loud jerk noise that lashed the car forward. I took it to a hyundai dealership in Milwaukee, WI and they reported rear diff leak in cuppler and housing unit. Everything else works well but whenever I turn the wheel is when the car doesn't accelerate forward anymore. I tried my warranty but unfortunately doesn't cover it. What is the best fix and option at this point?

If I had a Santa Fe I'd watch this twice. :)

2015 model, mine had same problem back in mid 2020 and had it replaced as you did with a “good will” contribution from dealer. Now the AWD “Lock” suddenly engaged and no light indicator on the dash. Can’t get it to disengage so had to get it towed to North Harbour Hyundai. Awaiting their diagnosis now :(

I have a 2015 Santa Fe. 100k + Miles. Recently had an engine problem that required it to be removed. After the engine was removed, this issue was discovered with these gears worn out. I am having difficulty finding the parts. B7t if I were to put it back together as is. Will my main issue be no rear wheel drive? Will the front wheel drive still be ok? Chances are that is how it has been driving for a while now anyways. How can I check for warranty coverage?

My brother has had two Santa Fe, he had exactly the same problem with both of them. He lives at the top of a big hill, and as soon as it snowed the problem soon showed up. He also had problems with the dual mass flywheel in both of them too, both falling to pieces at around 30 to 40k. He now has the equivalent Mitsubishi, and he went auto too. It's now done almost 100k with NO issues at all.

My 2013 Santa Fe has just been diagnosed with this problem but it still drives the rear wheels at this stage. There is a loud clang/clunk as I reverse up my steep driveway. It has done 180K and its previous owner was a rural person who had probably done a lot of towing and I do my share of towing too. Dealer has quote $6500 to repair. It should be better than this; there must be some sort of misalignment to cause this level of wear!

Thank you for the explanation! Could you provide the part numbers for the precise parts you had replaced? We have an automatic 2015 Santa Fe with the same diagnosis. I’m having problems tracking down the parts however. Thanks again for your expertise.

We purchased our 2015 with perfect dealer service history and at 63k we have been told that the transmission needs a full replacement. Have you experienced this with any of your work vehicles? we are also worried about this issue!

Thanks for Video, yes I currently have this issue and suspect it is the transfer case unfortunately I don't have $4K plus for a repair, and this morning the nut dropped off the shaft on the Turbo and then shattered the impeller $1K for a second hand turbo plus labour etc... Our Santa Fe is a 2013 has now done 247,000 kms

I have a 2013 SF Sport (Canada) that just rolled over 200000KM and had it in the dealer service as I had an engine light go from being on to flash. Dealer service said it was related to the engine recall issue and replaced it under warranty--my shop quoted me an estimate of $5K for a rebuilt engine, so I was glad not be out of pocket money. Whilst in, I was informed I need a new transmission I had to ask what the symptom was and was told AWD is not working on only 2WD--which sounds like the problem you identified in the video. I don't know how long this was the case but the quote for replacing a transmission given the age of the car is disappointing ($4.5K). I'm getting rid of it for a new SUV that is not Hyundai/Kia.

Common problem. Front Tranafer in 2014 blew at 45km under warranty. 110km the 4wd Coupler blew and warranty was denied. I have driven the car for another 50,000kms as a feont wheel drive. I have taken Hyundai to VCAT and they have capitulated 2 weeks befpre the hearing and will now replace the coupler under Warranty. If you get denied take them to Court. They know this is a problem and will try to avoid it. Call them out. It is a Disgrace.

Thanks man,that's my problem now!

I had the exact same problem. Mine presented a large noise under reversing. Presumably the splines slipping. It was £2500 all in and unfortunately not under warranty. However the vehicle had done 80k miles. Very good video explaining the fault

Do you know if a 2010 Santa Fe 2.2 diesel manual can be driven with the propshaft removed, the central 4 wheel drive shaft?

hello i have a santa fe 2001 4WD V6 right hand drive, i got a problem with it. the gear are not shifting. and on the dashboard when i put the gear to drive or (D) it shows (D and gear 3) at the same time. Do you have any help?

We have 2012 santa Fe, only used for school runs, never been off road, regularly serviced, last year we had to replace the engine, earlier this year we had to replace the gearbox, now we have a clunk from the transfer case and mechanic says it will fail any day now. Should have got rid of it after engine but mechanic said that was the big one you'll get years out of it now, then I argued to get rid of it after the gearbox, "but we'll end up with someone else's problems" Overall lemon of a car, I'll never touch Hyundai again

Hey Badger, thanks for the video. Mind tossing me some thoughts on an issue i have. I own a 2012 Santa Fe AWD 2.4l. When switching from D to R back to D and such, there is an aggressive thump that can be heard. When going under the vehicle you can pretty much pin point it to the transfer case. I have already replaced all 4 motor / trans mounts before hand. Also when accelerating there is a almost reliable thump from the front of the car as i accelerate. There is no slipping or RPM loss when the thumps occur. I am aware of the TSB 12-DS-002 and will be changing those out soon. I don't believe that has much to do with the thump when shifting from D to R to D. Any input would but highly appreciated. I was considering changing the Transfer-case fluid before taking it to a shop. Hoping to avoid paying an arm and leg if im able to replace a gear or seal in the transfer case.

I have a 2010 Kia Sorento with 205,000km on it. We had the same thing happen to us. The only indication something was wrong was when the car was in reverse occasionally it would make a loud clunk. Went to tow the caravan up over a kerb one day and it started skidding. Its in the shop right now getting the transmission reconditioned and the transfer case replaced. The agent said 9-10k to fix, however I am getting it for roughly 5k from my mechanic. I will be switching cars as soon as I can to get something better for towing. It's a shame really as they drive so nicely and towing is a breeze.

Also this exact problem with 2015 Santa Fe Highlander 107,000 Kms Sunshine Coast. Over 3 years out of warranty. No towing ever but recently had the 2nd of 2 punctures a year apart on the Bruce Highway and needed to drive one Km on a flat tyre on both occasions to exit the freeway. Could this have caused the splines on the transfer shaft to shear off? Been quoted $6.5K to repair. Would I be better to just leave the rear wheels disconnected and operate the vehicle as a front wheel drive only from now on?

Today it happened to me. 2015 Santa Fe 2.2 diesel 78000 km Drive shaft not turning when front wheels are. Drive shaft can be turned by hand when the car is stationary on the ground. I will disassemble it to make sure, but it looks exacly like the problem you had. Did anyone found a better replacement for the OEM diff carrier? Aliexpress?

2017 Grand Santa Fe (German), 200HP Diesel. AWD was still working, but driving fast on twisty roads (right corners), the car was shaking. Diagnose from Hyundai-Dealer, defective Differential. Whole drivetrain was replaced (warranty / 58000km). No Trailer or heavy loads. 4 matching Wintertires, Not old and equal on Profil depth

2007 Santa Fe with AWD indicator flashing and ESC off since January 2022. No error codes on scanner have not taken to dealership for inspection.

Hello i have santa fe 2009. Do you know is it a limited slip diferential or no? Im confused about oil replacment. LS oil or regular gear oil ?

Just had 2016 Santa Fe Turbo Sport coupler replaced. 81,000+ miles on it, always had matching tires. Baffled on why this happened.

I brought 2013 my14 santa fe elite 3 weeks ago, notice clunk noise just once every time when reversing up slight hill, took back to place i brought it, and needs new diff, so im wondering if is the same problem, like to put on hoist to see if all wheels turning before take it to get fixed, and then after they fix as well.

What are those 2 bits called as I need to order them for my 2014 Santa Fe please thanks

Hi great video thank you. How can I lock my 2014 Hyundai Santa Fe into AWD and how do I release it back to two wheel drive. I assumed it did that automatically. Regards Geoff from Oz

Excellent video only a Kiwi could give a subjective explanation. A lot of Auckland cars end up in Turners Christchurch

My Hyundai Tucson 2011 has a different problem, while on hoist the one side rear and front driver side spin but non of passenger side spin. What’s your opinion?

I have a 2015 Hydundai x35 (has done 160K) and during a service they discovered I the AWD wasn't working (Front Dif Drive Splines stripped. I couldn't tell any difference when driving it, I've had it since 2015. My question is could I just get the oil drained and replaced (to remove any metal bits) and just drive it as a 2 WD? I don't really want to spend $3K on what is probably a $10K car now.

Hello I have exactly like this problem but my car is Tucson not santa, when I press the diff lock button it shows in car engine screen that is turned on but there is no action form the car just the front tires rotates and the rear tires does not move, what can I do?

We bought a 2013 Santa Fe new. Always serviced at Hyundai. Had the same problem at 50,000km in 2017. Checked under the car after a service, and found the prop shaft could be turned by hand. Repaired under warranty. Strangely I had never used 4WD. Never knew it wasn't working until I checked and hand turned the prop shaft. It must have destroyed the splines by just turning the prop shaft itself!!

do you know where the breathers are on the transmition and diff are?

i initially thought not too much of the video warning as a small number of most brands have horror stories...which is rare and bad luck but after reading the comments i might steer clear of the Sante Fe....it reviews very well and I imagine its a great car otherwise.

Yup! My 2014 Hyundia Tucson

I've got my old beater version of this car with this self same issue. I'm half tempted to weld this joint together.

I have a 2014 been a great car to I got this problem. I noticed the problem at 90k could have happened earlier on. I have 22” tyres on mine and they said that could caused the problem. My warranty ran out so I been quoted 6k for the job.

I'm sure it's been asked before but please can anyone tell me what type of oil is used to refill/ change the old one in the 4wd actuator?

2013 Sante Fe 80,000KM EXACT same issue.. Limited towing, tyres always rotated and replaced at same time cost more than 4k to repairer at dealer.

Argh! We have just found this issue with the 2013 model we purchased 6 months ago. We are in NZ too and wondering if Hyundai will repair?? Was yours outside the warranty period?

I have a question I have a 2010 Hyundai santa fe limited edition awd 3.5l v6 and the viscose coupler is f**ked on it what happened if u still drive it

Thank you for the overview! Have just been told by Hyundai my transfer case has failed and the spline on the drive shaft possibly stripped. I have not seen any photos yet and we have had no sign of leakage. Always serviced with Hyundai Melville (AU) since new. They mixed up their service schedule this year and missed the 96month service. Looking in the records no sign of transfer case fluid checks or replacement to date. Milage is 107k in km. Car always driven light, never off-road nor towing anything. Hugely disappointing but hope Hyundai Australia will come to the table given low milage, loyalty and service bungle. Any suggestions most welcome.

I was thinking of buying a new Santa Fe soon as I can’t see myself doing any serious 4wding. Do you think I should steer clear and get a Pajero Sport or MUX instead? Thanks in advance

Great video. I have a 2017 santa fe diesel 2,2 (115,000ks) , Took it in for a service and they came back with a report saying the diff coupling needed replacing as leaking oil. Does the coupling actually contain oil, if so and leaking cant the leak be sorted and oil refilled. If its not leaking from the coupling could it be the diff. They produced a lovely photo and yes there is evidence of oil leaking . shame I cant upload it. Its an expensive exercise so any comments or feedback appreciated. Thanks

Discovered that I had a complete failure of the transfer box at about 90,000km. Thankfully Hyundai covered the parts bill - $8,000. Always had matched tyres, no heavy towing and limited off-road driving.

Most AWD units dont engage all the time just when needed. Seems you wouldn't use the AWD much. Looks like a lot of soft metal on the splines.

I own a 2014 santa fe and its been nothing but trouble for the past 4 years. I don’t understand how car websites keep mentioning it as a reliable vehicle. I agree its good value for options they provide, but reliability is garbage.

I have one those 2013 Santa fe sport with the same problem and I have a cuestión. this is inside that transmition or transfer case?

I have a 2014 SF only done 89,000km had since almost new. Exact same issue with mid TF case and also parts in Trans. Quoted by my mechanic $7,000! It has just been shipped of the a Hyundai Dealer in Auckland for them to inspect. Spoke to Hyundai NZ, first question was about the tyres. This is a dodge the issue excuse from them. If decent quality the tyres would not cause this. Anyway tyres are new and to factory spec and rotated. So sorry Mr Hyundai. Will advise updates. But to me regardless of age it is only 6 years old with low K’s, it should not fail. My old 1996 Toyota Surf had done 300,000k’s and had a hard life, no engine or running gear issues.

It happened to mines. I had no warning ⚠️. However, when I took it to the dealer they notice oil settled in the splash guard under the engine. What I noticed was when I put the truck in reverse it took time to catch the gear then kick in reverse.

Good to hear from ya. Thanks for the info, think I will stick with a Jeep if I go 4 wheeling. Happy Motoring and off roading.

2013 hyundai santa fe. Owned since new, only dealership serviced, never towed anything, never been off road. 110 000km same failure. Total heart break.

Mine actually cracked the differential carrier in three places that you have in your clip.One part dislodged when examining it.I have approached my local NZ agent.Possibly some assistance $$ from Hyundai . Carrier splines not worn but transfer case spline was.

Good job you had warranty buddy

Our 2014 Kia Sorento AWD (same as Hyundai really) looks to have done the same thing. One big shudder through the drive when accelerating from intersection, a few more small ones, then all quiet. Got it to local dealer who found fault codes relating to transfer and no drive at all to rear. The slipped the shaft out, stuck in a magnet and got a lot of metal on it. This was a 5 year warranty model, but they are going to put a case to Kia Australia for me - fingers crossed. Pretty ordinary for a vehicle that's never been off a sealed road and travelled only 116,000km.

What ever happened to the audi head i was looking forward to that series

Yep 2015/16 model out of warranty. 61k on it. Made a small noise when going from park to gear. Made a large noise one day on a hill. Week later total awd, failure makes the exact noises.. might push it down a hill.

Hi.. I'm concerned as I had to tow my 2010 hyundai sante fe. I forgot to tell the Tow Operator it was all wheel drive. He towed it about a half a mile to a mile, before asking...??? I feel HE should have known, as an Operator....‽‽‽ Seems ok right now. Should I be worried??? And what would I need to look out for to know if it had, indeed, been ruined. Been driving it for a few months, now, after tow. Not really noticing anything abnormal at this time...

You can end up with a lemon on the 2016 Tucson as well. They could never fix the dual clutch transmission and finally bought my car back at the original cost, taxes and insurance.

Same thing happen with my edge. Thousands of other edge owners complained to. There’s some lawyers that say their going to do a class action lawsuit against Ford since so many complaints. $1700 later traded it in after 6 more months of driving. I want a sante fe but I see the same problems as the edge. Ok. Get one and trade it at 80k

Stay clear of 2017 santa fe sport and various other models as well. EGR recall due to excessive rod bearing ware. Instead of replacing the engines Hyundai designed a more sensitive EGR and a software update. One year later rod bearing failure and only 28,000 miles on the it. Goes in next week for new engine, getting rid of it as soon as I get it back!

my 2011 has this now. was hoping to get used bits of a damaged vehicle to replace it as it needs a clutch slave cylinder as well.

I have just had this happen on my MY14 plated Santa Fe, bought new (ex demo), at 120000ks, Always replaced all 4 tyres at once with good quality tyres, don't take it off road, never been under heavy towing, mostly school pick ups and long highway drives. Still under the after market extended warranty but dealer has told me they will only cover up to $1000 per warranty claim, there estimate is $4220. I will be fighting them.

how old is your santa fe? A friend of mine has one, Hyndai dealer in sweden says they never heard about the problem.

It looks like a heat treat quality control problem. I bet the replacement parts are better.

I was willing to buy a 2015 one with a diesel manual but now I think I might pass

Would be this the same problem in Tucson? I have a Tucson with no rear wheels working, but it shows in the cluster the "4WD problem" light

In my Santa fe 2007 4wd wont work, push the 4wd, it is show on the panel like is on but no traction on 4 wheels just the 2 in front, look like this is electronic can you show how to fix it ?

Anybody know If this was rectified 2016 2017 when there was a face-lift?