Mazda Cx5 DPF Problem [Solved]

No video

Mazda Cx5 DPF Problem [Solved]

Рет қаралды 76,526

Күн бұрын

In this video we talk about solving Mazda CX5 DPF problem when the DPF light comes on. The DPF of this car is known to fail at some stage in its lifetime and you will know this by a P2002 error code described as " particulate trap efficiency below threshold bank 1" on your diagnostic tool. Other faults that can be seen are as follows:
P2003 - DPF efficiency below threshold (Bank 2)
P242F - Dpf restriction - Ash accumulation
P2458 - DPF regeneration duration
P2459 - DPF regeneration frequency
P2463 - DPF Restriction - Soot accumulation
In the video we explain the ultimate way which you can solve this problem. a DPF is meant to last the vehicle's lifetime. You dont have to buy a new DPF and when you start seeing these problems it means you will likely continue seeing them even if you purchase a brand new one. In the video we also layout our solution which is much more permanent and cost effective! This solution is available in Zimbabwe. If you are watching this from outside zimbabwe you may want to check legality of DPF off service in your country.
We have also worked on may other vehicles such as Mazda Cx7, Landcruiser Prado, Toyota Rav4, Avensis and many other brands such as Hino, lexus, mercedes, BMW etc. This video will also give you a good guide on how to solve dpf problems on other vehicles as well. You can check our facebook page for these success stories
/ the-dpf-team-203554420...
or visit our website
www.thedpfteam.com
You can also contact us on whatsapp for more immediate response on
+263775071666

Пікірлер: 92

@fuzzylumpkins6034 5 ай бұрын

I am in a different country. I did a dpf delete, stage 2 remap. No dpf- no problems, got an extra 200k miles out of my 2013 mazda 6 tourer. Had I not deleted the dpf, the car would have failed at 150K miles and been stuck in limp mode while fouling injectors, raising fuel cost and ruining the exhaust cam. To all 2.2 skyactiv owners: upgrade your exhaust sensor (it is a manufacturer upgrade and god send if you have scbs lights and other crap popping up causing limp mode,) delete your dpf (this is not testable for emissions and has no inspection other than visual so put weld on top of dpf,) upgrade your front disc and pads to quality parts as this car is so heavy it eats cheap discs and finally swap that awful tom tom headunit/nav system for an android/apple play Kenwood or Sony xav ax series unit that will work with your steering wheel and console controls that is under £200 and a much more reliable up to date satnav stereo that also plays netflix and youtube and whatever else you stream or the kids watch.

@tinashenyamutsamba446 3 жыл бұрын

Not bad wangu .....i will come to you when i purchase this vehicle.

@Jaytecks 2 ай бұрын

I was driving on the highway and error p2458 appeared, then p2463 and the car went into emergency mode reducing power. What do you think is the best place to start looking?

@lorenzojames7009 2 жыл бұрын

How you do the conversion

@cransaftvalve734 4 жыл бұрын

I have the same problem, car do not run over 2600rpm, and car have error DPF.

@danielomondi5611 3 жыл бұрын

The briefing is good but u haven't explained how to remove DPF

@josekamowa 2 жыл бұрын

i guess that's their workshop secret , once they reveal they will be out of business

@user-kr1wr2eo3g Жыл бұрын

Hi Team, My cx5 also having this kind of problem DPF light is on and there are more lights appear on the dashboard. The gear is also coming up and down while driving so please I need your advice

@endyXVII Жыл бұрын

Hi, once mazda cx-5 2013 has been converted to NON Dpf, cannot be converted back to DPF before Mot, is that possible?

@JPEBeard 4 жыл бұрын

Can you do a video on a CX-5 Non-DPF conversion?

@kingRioMw 10 ай бұрын

Mine has the same problem How can we convert it to non dpf?

@vimbaidehwa5379 11 ай бұрын

My 2013 CX5 just stopped without any lights showing on the dash board.

@gee3883 3 жыл бұрын

Hi THE DPF TEAM very interesting video, can you please tell me if the CX5's in Africa that don't have the dpf systems are free from any of these problems ? like no turbo failure head gaskets blowing etc thanks.

@thedpfteam2423 3 жыл бұрын

Assembled in Africa do not have DPF and any of the dpf related problems. Obviously turbo can fail but due to other issues but not dpf as we have seen in some dpf equipped cars

@louvincornibert5532 4 жыл бұрын

I owned a cx5 but after a few months I got a dpf light on my dash so I removed the filter cut out the filter but engine light still on my dash can u please help me solve this error

@thedpfteam2423 3 жыл бұрын

yes. Contact us on our numbers or facebook page

@alessandrobosco-fq8py 5 ай бұрын

Hi, I have a Cx-3 1.8diesel 2019 , can I ask you if this model have problem of software egr remap , after filter removed. I had another Cx-3. 1.5diesel of 2018, but after filter removed, the software process was not good, the guy that did the job told me that specific model was problematic ! Thank you!

@thedpfteam2423 5 ай бұрын

We have a challenge in the market of technicians like that. Only after tempering with the car and when money is in the pocket they start saying it’s difficult. We are almost at a point of no longer accepting jobs from vehicles that have been tempered badly. They usually take time to perfect at a level that we give our usual lifetime guarantee. You can book it through our workshop so that we can have a look.

@alessandrobosco-fq8py 4 ай бұрын

@@thedpfteam2423 hi, thanks for your answer, I would love to bring my car to you, but I’m in Italy, … anyway, sorry for my ignorance, what does it mean tempered car? Thanks again.

@thedpfteam2423 4 ай бұрын

@@alessandrobosco-fq8py what i meant by tempered is altered from its original form

@nthemperor 4 жыл бұрын

Thanks. So, what's your solution for those in Japan. I just bought a used CX-3 a week ago and just today I noticed the i-stop wasn't working after 1 or 2kms. I checked the car info and it said "i-stop unavailable, DPF problem." Should I just send the car back or is it not a big deal in a car I just bought?

@thedpfteam2423 4 жыл бұрын

You can try regeneration. Its a short term solution but should work. A more permanent solution is converting to Non-DPF like we did to the one above. Returning it is pointless because if they give you another you will eventually have the same problem. Here in Africa these dpfs fail mainly due to our fuel quality. Should you keep having issues contact us on the numbers provided above

@nthemperor 4 жыл бұрын

Thanks so much. The conversion is not an option here in Japan. Will take it to a mazda dealership this week. Will keep you updated.

@suniljaggarnath9474 Жыл бұрын

Good night I'm form Suriname I have a Mazda CX-5 and I a lot of problem dpf s on

@theflyingmilkfloat 4 жыл бұрын

Did you remap the ecu after removing the dpf? Thanks

@thedpfteam2423 3 жыл бұрын

Yes Sir

@dylanmacmillan4864 3 жыл бұрын

Is there a similar solution for the newer model (140kw) Mazda CX5? I have this model and notice the DPF burn cycles. I have never had limp mode, but the cycle used to occur every 450km and it now occurs every 250km. I assume it will continue to worsen over time (as the DPF gets more and more blocked). Solution - gut out DPF from exhaust (or get new exhaust without DPF) and then write out the DPF cycle from ECU?

@thedpfteam2423 3 жыл бұрын

definitely there is solution for new cx5

@roxinericketts7246 3 жыл бұрын

I have a 2014 CX-5. The issue is, my DPF light pops up every few weeks and it is so annoying. Initially, whenever the light pops up the mechanic would clear the system… multiple times and the light goes away. That didn’t fix the issue. I found another mechanic who mentioned that the soot needs to burn off. He did that but the issue keeps returning. I noticed that whenever the DPF comes on the vehicle burns fuel RAPIDLY!!! Any pointers???

@thedpfteam2423 3 жыл бұрын

Definitely its going to burn more fuel. This is because its trying to raise exhaust temperatures so as to cook the soot. You have to allow it to finish that process. You also need to ensure you are taking very good care of your vehicle (using good quality fuel and sending it for routine maintance. If you are not taking good care of vehicle the car will generate more soot than normal often prompting it to regenerate frequently (cook dpf thus chow fuel)

@roxinericketts7246 3 жыл бұрын

@@thedpfteam2423 thank you. It is serviced regularly. However, since the pandemic (March last year) I do minimal driving , maybe 2-3 times per week (sometimes no driving) and usually short distances. Do you think that might be a part of the issue, that is, limited driving and for short distances?

@kevinhancock4064 2 жыл бұрын

@@roxinericketts7246 I often try to get on motorway where I can avoid city streets where possible diesel's more so these hate short trips

@roxinericketts7246 2 жыл бұрын

@@kevinhancock4064 thanks for sharing but unfortunately, this does not work. It's an endless battle.

@vinnystevens58 2 жыл бұрын

Hello DPF team I have a Mazda 6 2016 sky active 2.2 Italian model. I have the same problem of white smoke coming out of exhausts typically when I accelerate suddenly to overtake or sometimes during Idling. The Mazda dealer replaced an injector because of engine warning light but still the problem persists. Your video is super helpful, but could you suggest this could be a DPF issue as well.?

@Racmkd Жыл бұрын

Hey did you get this issue resolved? I have a Mazda Cx-5 2013 with the same problem. At acceleration there is a cloudy white smoke behind the car.

@helopi8 Жыл бұрын

@@Racmkd Have the same here with my new CX5 2.2 diesel

@mkatalin09 3 жыл бұрын

I dont know how many km u did for the test drive but from 144331 to 144333 it looks like 2 km to me

@fava7753 Ай бұрын

In Britain most definitely to do dpf or bypass conversion . it is against the law . .

@GLDGTR 3 ай бұрын

I have a problem with my mazda 6 2.2 diesel it keep regenerating every 20-30 km

@thedpfteam2423 3 ай бұрын

Run down you tank and change the quality of fuel you are using. Try go to a service station known for the best quality of diesel in your country. After that replace diesel filter and run regeneration. The reason regen frequency increases could be mainly due to diesel quality issues or filter due for replacement.

@radoslawzacharek8777 3 жыл бұрын

Hi, will the car after removing dpf give much more smoke from exhaust?

@thedpfteam2423 3 жыл бұрын

Shouldnt smoke

@gilbertmuraga7429 2 жыл бұрын

What is the price of removing the dpf in a demio diesel.and if I remove it will fuel consumption increase in my demio??

@thedpfteam2423 2 жыл бұрын

fuel consumption will improve and so will power. Bring it to our workshop for assessment

@gilbertmuraga7429 2 жыл бұрын

@@thedpfteam2423 where are you located?

@michaelOburaOniala Жыл бұрын

Bro, are u facing issues with your DPF?

@truth7687 Жыл бұрын

How do I remove the DPF

@abufirdeen9596 Жыл бұрын

Can i do dpf and egr delete on my 2016 mazda cx5?

@thedpfteam2423 Жыл бұрын

Good day.Yes. Book your car with our workshop on 0775071666. We are located in Hillside, Harare near OK Mart

@papajim2008 2 жыл бұрын

I want to buy mazda cx3 diesel 105 hp ..... Is it worth it or will I run to the garages ??? If I remove or drill the DPF filter .... Will the engine work better? .... Will it be able to pass the pollutant test? .... How many more pollutants will it show approximately ....? If anyone can help me ...

@thedpfteam2423 2 жыл бұрын

Its a brilliant car! As long as its legal in your country you should be fine. You must also ensure its done by well trained technician in this area otherwise you will have problems after removal

@papajim2008 2 жыл бұрын

@@thedpfteam2423 ok ...thanks

@papajim2008 2 жыл бұрын

I am thinking of removing the dpf ..... just my opinion is not to close the egr valve because it helps not to increase the temperature in the combustion chamber ...... of course it will be filled with carbon but with cleaning and operation constant speed ... .it will be cleaned somehow ..... plus it will throw a little less black smoke ..... your opinion?

@kevinhancock4064 3 жыл бұрын

So the UK? If dpf is removed doesn't it affect the emissions for mot? Thanks

@thedpfteam2423 3 жыл бұрын

The vehicle will fail the Mot test. We highly recommend against the removal of the dpf if laws of your countries does not permit it

@kevinhancock4064 3 жыл бұрын

@@thedpfteam2423 th98ghtbas much as emissions output would become higher and a fine can be issued thanks

@arturforever2060 2 жыл бұрын

If you only removed will be not past MOT. when you remove you need remap. Then you will past MOT no problem. Remove + remap is cost £500 thepend of garage

@kevinhancock4064 2 жыл бұрын

@@arturforever2060 ah ok thanks I've read that removal of dof is still illegal though in UK

@rachaelcaitlin1 3 жыл бұрын

Any advice on 2 failed Particulate Matter sensors fault code P24AE is their a fix to stop this happening again. Vehicle still in warranty. Thanks

@kevinhancock4064 2 жыл бұрын

If u have warrantee why aren't they sorting it ?

@ngonds Жыл бұрын

where are you Located in Zimbabwe i want mine modified

@thedpfteam2423 Жыл бұрын

We are in Hillside near OK Mart call us on 0775071666

@Aktik-Cat. 3 жыл бұрын

Uri muzimba here wangu??

@thedpfteam2423 3 жыл бұрын

Hongu. Tiri muHarare

@Aktik-Cat. 3 жыл бұрын

@@thedpfteam2423 ok baba that's good,, so besides kubaka kwedpf light kana rave clogged, is there another way to see if your car is doing regeneration?., ndine mazda6 diesel 2.2 ltr

@thedpfteam2423 3 жыл бұрын

@@Aktik-Cat. It has been programmed to regenerate every few intervals. The problem sometimes is that our fuel isnt of the best quality. What that does is it causes dpf to clog with contaminants rendering regeneration useless

@Aktik-Cat. 3 жыл бұрын

@@thedpfteam2423 so far so good nayo hangu at 65000 kms, l hope im never going to come across that issue😂😂😂,,

@thedpfteam2423 3 жыл бұрын

@@Aktik-Cat. Make sure you use good quality of fuel. Try stick to traditional service stations. If there is fuel shortage in ZW again its better to park the car than force matters by using fuel yevakoman. If you have problem with DPF you contact us

@langatalex8393 3 жыл бұрын

I have the same problem with CX 5 2013

@kevinhancock4064 2 жыл бұрын

What's up with yours may I ask ? Dash light ? Dpf?

@4wheelsAutoRepair-MZ Жыл бұрын

Solution is to remape the ecu and delete dpf and egr system

@michaelperegrino5829 3 жыл бұрын

The tech add too much oil

@itsablackboymadam4936 2 жыл бұрын

Could I please have you contacts

@thedpfteam2423 2 жыл бұрын

+263775071666

@brianpowerhouseturbo 4 жыл бұрын

So all you have done is illegally removed the Dpf rather than fixing the original problem. All you have done is made a car environmentally illegal and given the next owner of the car a massive headache by doing what you have done. It also will never pass any emission tests but you know that don’t you seeing as you have removed the number plate off the car !!

@thedpfteam2423 4 жыл бұрын

I dont think you fully understood. Already here in Africa we are manufacturing similar cars with No DPF or adblue systems. However non-dpf cars are far more expensive to buy here in Africa than ex-Uk or ex-American. So we import and we just convert to Non-DPF. We do not have your emission tests here or emission laws thats why we can do this. Like i said in the video this option is not for people in countries with emission laws. And NO the owner will not have headack but will enjoy increased power and better fuel economy. You cannot do this however bcz of your country laws. Lol

@mwanzie 4 жыл бұрын

@@thedpfteam2423 quality of Fuel also matters imports are meant to run on 10PPM and 50 PPM max, most fuels in africa are high sulphur content. making DPFs and AdBlue irrelevant.

@Myboerewors 3 жыл бұрын

@@thedpfteam2423 This was a greqt service. I currently have the same limb mode problem with my stupid Mazda cx5. I cut out the dpf and now its error after error. Mazda SA asks R31000 for a new dpf. A mechanic said he could fix it fir me for R4500 and he wil remap it to stage 2 for more power and fuel consumption. SA currently has no law stipulating that i must have a dpf. Its stupid and useless. Just have it removed by proffesionals. 😉

@sasacovic 3 жыл бұрын

I understand your point absolutely but...have you ever wonder, when DPF make regeneration (burn all dirt particles) where it all goes?

@BROKENTOOTH0 3 жыл бұрын

@@sasacovic when the system is operating normal, as soon as your particulates filter is below threshold ( is not letting enough air out the pipe) the system goes into a regeneration ( it adds extra raw diesel in the filter to burn the particles) but you need to run the car at enough speed constantly for about 35 minutes) if you stop during regeneration, it will abort and you need to start running again without stopping. once the particulates are burned, they go out the exhaust pipe in a form of white ash that is supposed to be harmless to the environment.