Sleipner (Side-Power) Bow & Stern Thruster Troubleshooting Guide

Рет қаралды 28,964

Күн бұрын

Imtra's Steve Howd walks you through the troubleshooting steps for Sleipner (Side-Power) Thrusters if your thruster isn't functioning properly. If you have any questions or need more guidance, please reach out to Imtra's technical support team at (508) 995-7000.
0:00 Introduction
0:35 Components
1:35 Motor Components
2:26 Part A: Control panel doesn’t turn on
2:32 Step A1: Battery Power
2:50 Step A2: Thruster Voltage
3:15 Step A3: Harness Voltage
3:49 Part B: Thruster doesn’t run
4:06 Step B1: Jump Test Harness
5:03 Step B2: Jump Test Negative
6:02 Step B3: Check Solenoid Output
7:18 Step B4: Check Thermo Switch
8:37 Part C: Thruster runs on its own
8:50 Step C1: Shut Power Off
9:06 Step C2: Test Solenoids
9:45 Step C3: Test IPC Control Box
10:11 Step C4: Test Joystick
10:30 Step C5: Repeat for Other Joysticks
To find all of our written troubleshooting guides, please click here: www.imtra.com/customer-care/d...
Check out our annual maintenance guide for thrusters here: www.imtra.com/learning-center...

Пікірлер: 21

@martinbring5925 19 күн бұрын

One the best trouble-shooting videos I've ever seen. It made us find a faulty thermo switch. We were so close to buy a electronic interface until we found this. Well done!

@diversgoesdeeper 4 ай бұрын

Tank You with this Video i Fund my troubleshooting. Selonoid must reglementiert.

@tom_steiner Жыл бұрын

Bless you for this video!!!

@scootersanders6313 2 жыл бұрын

Thanks for the troubleshooting. I have the problem with the panel not working. But it have voltage. Now i have to replace it! 🙂

@hosey31 4 ай бұрын

Thanks for this.saved me hrs working out the fault

@imtramarineproducts 2 ай бұрын

That's great news

@COREOO7 Жыл бұрын

Thanks you so much my friend

@DavidLariviere Жыл бұрын

Thx for the troubleshooting , i need to change the temp switch

@quintinperkins83 6 ай бұрын

How did you do that I'm working on one now

@AdamChecketts074 11 ай бұрын

Outstanding info. What I didn't hear is anything about an over charge indication. The yellow and green lights on my converter/ charger are cycling (which from the manual indicates an over charge status). Why would this cause the thrusters to not even turn on?

@imtramarineproducts 11 ай бұрын

We'd recommend you contact our service department (508) 995-7000 so someone can help you troubleshoot over the phone and get into the specifics of the setup on your boat.

@gokhanparlamis6383 Ай бұрын

Did you solve the problem? I have the same problem. What should I check?

@enver1986 4 ай бұрын

What about when sidepower se80 works with constant clicks in both direction and these clicks are followed by blinking light on the control panel in the same rhythm as the clicks. (Let's say 3 in a second). I have huge nee battery and new solenoid and distributor. Thanks!

@G_Zero127 Ай бұрын

Did you ever get a fix for that? I have the same problem solenoid constant rapid clicking when using joystick and even jumping it. New solenoid did not fix, I suspect its the relay(IPC control box)?

@adriangartland2533 Жыл бұрын

Any advice regarding bow thruster fade?

@imtramarineproducts Жыл бұрын

Curious what you mean by fade? Not running at full power when held on for an extended period of time, or losing its overall power throughout the years? If the former, it would likely be related to battery power/voltage. If the latter, it could be worn carbon brushes within the motor, which wear down over time and can be replaced.

@stephengreci 2 ай бұрын

What should you check if you are blowing the fuse in one direction?

@imtramarineproducts 2 ай бұрын

This indicates increased resistance in that direction. Please reach out to Imtra customer service so we can assist you in confirming the source of the problem. Give us a call at 508-995-7000