What happens when overfilling the gas tank? Fuel Systems

No video

What happens when overfilling the gas tank? Fuel Systems

Рет қаралды 55,913

7 жыл бұрын

Should you or shouldn't you "top off" the gas tank? Today, Jerry talks about: What can happen if you do...
We all like to get as much into the gas tank as possible right Well, it could eventually create many problems and they are not cheap auto repair. It is a habit for most when the gas pump clicks off that we try to add more gas whether it be a few dollars or cents.
When the pump clicks full Do Not Try to put more gas in the tank. Start a new habit as this is a costly repair that doesn't need to happen!
Set an appointment at theautoshop.co...
Find us on the web: www.TheAutoShop.com
Find us on Facebook: / jerry.kezhaya
Find us on Twitter: / theautoshop
Find us on KZfaq: / theautoshop

Пікірлер: 52

@toddshaffer4807 10 ай бұрын

I've replaced the purge valve 3x,s in less than a year in my 01 Hyundai Accent because of the three times I force-fed my tank when fueling up, not realizing I was the cause of the problem. Thanks for the info. I'm sure that Auto Zone will be happy not having to honor their warranty on purge valves!

@Mr05241948 3 жыл бұрын

Listen to this man and avoid a useless expense . I have a 2006 Chevrolet Impala which I overfilled every time. It took a long time but eventually the gasoline dissolved some charcol in the canister and plugged up the hose to the check valve. When this happens the car will not accept gasoline at all. As I did not know about how this system worked, I found out the hard way. The repair shop started at the wrong end of the problem which eventually cost me $880 and two trips to the shop before it would accept fuel again. Listen to what he says and do not overfill your tank. I don't know why car sales people do not tell you this.

@1Lexicon Жыл бұрын

I have a 2006 Chevy Impala and I just accidentally overfilled it.

@arieldroger5291 Жыл бұрын

First video that explains what flooding your canister presents as. Thank you!

@colty7764 3 жыл бұрын

also, I wouldn't let my tank get below 1/4th full. The fuel pump (very expensive to replace) uses your fuel that it sits in to cool it down from it's motor. If it gets to low, it can heat up more than normal. When you fill it up on or near an empty tank, the thermal shock can possibly damage it. Nearly $1000 to replace (part and labor) if it eventually fails.

@jimpoteet1 9 ай бұрын

volvo is especially true for this...thanks

@claytonroot806 5 жыл бұрын

Me bad! And yes I'm over 70 years old. I top off ALL the time. 10 year old Hyundai Sonata V6 with over 100,000 miles. Never an MIL light and the car delivers the same fuel economy today as it did when new. Ditto on a 2014 Dodge Grand Caravan with over 50,000 miles on it. That sucker will take another $10 worth of gasoline after automatic shut-off. Once again, no MIL lights and fuel economy is the same as when new. I've topped off for over 50 years of driving on Ford, GM, Chrysler, Honda, Toyota, Nissan, Hyundai, and Kia vehicles. Not sure when these canisters were introduced but I've yet to experience a problem from overfilling. Perhaps my vehicles have guardian angels!

@TheSaint135 5 жыл бұрын

Same thing here with a prius. Been overfilling it every single time for 6 years, without a single issue.

@nzchariboy 3 жыл бұрын

same with my Prius C I fill right to the cap, never had an issue.

@joemama8379 2 жыл бұрын

Have a 2017 camry have been over filling since day one. Fill it to the top

@patewilliam 2 жыл бұрын

@@joemama8379 Me too, though mine is a 2011 - 260,00 klms. If it is such a bad thing, surely, vehicle manufacturers have installed a failsafe. Nothing in my vehicle manual telling me not to fill up to the top. Just KZfaqrs.

@takemyshoesoff3350 11 ай бұрын

Me too. I don't overfill to the point to where the gasoline is coming out of the tank but I still pumping some more gas even after the handle shuts off the first. I've always done this since I was old enough to drive and never had any trouble

@ryans413 3 жыл бұрын

The canister collects gas fumes if the canister gets filled with gas the charcoal can’t absorb those fumes and the gas tank could start to have too much pressure build up and that will set a check engine light. Kinda like leaving a gas can in the hot sun without the breather tap pulled. Plus the EVAP system also send some those fumes back to the engine to be burned in with the combustion or vents them out to the atmosphere so you can really mess the system up by overfilling

@bernardhaller3754 3 жыл бұрын

Hmm another person getting it wrong. yes you should not over fill your gas tank, but automotive engineers design gas tanks which will let out gas before the tank is full. gas tanks are designed to be filled to about 90% capacity in the other 10% is the expansion area where the gas overflow and the return line of the charcoal canister. it is almost impossible to reach it unless someone has blocked off the overflow hose or has been tampered with. i don't advise overfilling the tank because it will end up on the ground and that is a waste.

@oldgrandpa1758 Жыл бұрын

Go make a video instead of commenting you dummy

@BenjaminKwakye Жыл бұрын

I have a habit of overfilling my tank even after the pump trips shut. Just as you've mentioned, my engine check light is on. And vehicle diagnostics tells that my EVAP system of "shut". I drive a Honda civic 2016. How do I get this fixed. I promise not to overfill my tank again😁😁😁

@DillonAuto 11 ай бұрын

Interesting choice for demonstration. And I don't mean the old car, I mean what it does. If you are driving on a road trip, or just all day in your car, the expansion cavity will be emptied after topping off long before any problem from heat expansion.

@rickjefferson4367 10 ай бұрын

Exactly! This post does not deal with people on a road trip and not leaving a high fuel level over time in a hot climate.. If you're going to tell a story, tell the whole story.

@ix_bizaytetteh9416 Ай бұрын

Hi please I want to ask if you can over fill a mazda demio 2000s car tank.

@kelly3918 2 жыл бұрын

Grate explanation .I have an old car so am fine .

@sarahalghamdi2290 3 жыл бұрын

I just overfilled my car tank it didn’t stop when it filled and kept got until it overflowed. Now my car is dripping what should I do?

@SuperAn0nymus Жыл бұрын

same thing happened to me. The sensor in gas station wasn't working and it overflowed. Did any damage happen to your car?

@leechjim8023 9 ай бұрын

I have also had automatic shutoff engage when it was nowhere near full.

@patewilliam 2 жыл бұрын

This is most interesting. Why on earth would any, and I mean any, vehicle manufacturer leave such a huge design fault as that on a vehicle ... Hmmmm? Why would even the government allow a flaw like this to exist - that is, something that will destroy emission control and so on. You wouldn't, surely, leave something that is prone to such misuse on a vehicle. The public would not know not to do this. When you buy a new vehicle, you are not warned about this. My vehicle manual does not tell me not to do this. Yet, it seems, that this is a very expensive habit that is going to destroy your vehicle and the only people telling you not to do it is KZfaq people.

@TheAutoShop 2 жыл бұрын

Hi Tim, thanks for the comment. I cannot say why no one else is talking about this issue. What I DO know is that we repair a lot of vehicles with this issue.

@robertt3551 10 ай бұрын

Is the government supposed to tell you what to do and what not to do? Blame the government because you don't want to do anything for yourself, and if the government DOES tell you to do something, you say your rights are trampled on

@shotsfired1106 3 жыл бұрын

Ugh. I always top off my tank. As much as I can squeeze. My car shut off while driving and wont start now... i am thinking rhis may be a good place to check.

@TH3_DON_M3G4 4 жыл бұрын

I hear what you're saying but dont they have a fail safe for us idiots who will continue to do this? I mean the gas runs out if over filled, but it's only at the filler neck. I'm sure engineers have solved the back flow issue in newer cars. I've done it at least 5 times in my jeep and no issues.

@abukondonozorj.4340 5 жыл бұрын

I did that to Nissan Sentra 2018 hundreds times, nothing happened. I did it to Hyundai veloster 2013 one time and the check engine came on right away.

@danielmoore394 Жыл бұрын

2009 sonata v6 done for 10 years no issues

@greeneking77 3 жыл бұрын

But doesn't it shut off prematurely due to all the sloshing and turbulence in the liquid?

@aetreus88 Жыл бұрын

exactly what i was thinking

@takemyshoesoff3350 11 ай бұрын

Yes. Me too. I've always filled up more gas even though the handle stops. Never had any problems

@CollinMac96 7 ай бұрын

@@takemyshoesoff3350because you still haven’t poured enough fuel to cause issues

@takemyshoesoff3350 7 ай бұрын

@@CollinMac96 I've only accidentally let it spill like two times or so in pumping gas

@troywiltshire5272 11 ай бұрын

I always like to fill it until I can see it, and that the only to get accurate gas mileage (which is usually better than what the computer in the dash says it is). Unfortunately my 2019 F-150 has one of those stupid capless fillers and it extremely difficult to fill it past the cutoff, so I don’t go past the next even dollar on that one which means I will never know the true gas mileage on that one.

@bishoprichardson3412 Жыл бұрын

JERRY ! lol it’s bishop

@rickjefferson4367 10 ай бұрын

I own a 2017 Mazda 3 and routinely fill the tank to the brim, without spilling over. Never had a problem. If there is an issue, it's with your car, not with you. This guy must have watched too many of Scotty's videos.

@robertt3551 10 ай бұрын

You're free to ignore advice. It's a free country.

@markbadillo5145 4 жыл бұрын

can you tell me ablout motorcycle, i have an italika dr 200, and i topped it o and gas started to leak alote from the bottom of the bike and it cause some smoke because the gas was dripping on the hot pipes...do you think it will cause damagev this first time i did without realizing ,dum dum me me help

@lazimstudios9189 3 жыл бұрын

Yes maybe

@Crod999 2 жыл бұрын

I did that to ny fiat 500.. and the check engine came on.... still runs ok... my cap isnt loose or nothing... should I just let it ride and once the gas is used up does the check engine light go off ?

@Jvomila 5 ай бұрын

Hello I just ran into this issue today, I see your comment was from a year ago but by any chance could you update with what ended up happening for you

@artyfuffkin7805 9 ай бұрын

It's always a bad to very very bad idea to fill up to the top or even over 3/4 full . Because of what this guy states ,why the 1/4 left empty? Because in a serious wreck fluid doesn't compress , the tank gives way ...out flows 15 gals ? of gas and your trapped or injured