Little update from me if you can put it back the fillter then take out the to cables with big plugs and its easyer to finish the job. And thank you for the video !!!
@thegamepzАй бұрын
Can you send me link of the repair manual
@daniel-victorconstantin3301Ай бұрын
Oare au rezolvat problema la fusion /mondeo 2020 hybrid?
@fordc-maxplug-inlife9171Ай бұрын
nu cunosc. Pe modele anului 2020 si mai noi sunt deja alte cutii ECVT. Banuiesc ca deja sau luat in calcul si inlaturat problemele pe care le-au avut cutiile de generatii mai veche
@zmfbigblockАй бұрын
Salut la Ford mondeo/fusion 2018 apare problema cu rulmenții? Contează dacă schimbi uleiul la 60k km? Intenționez să cumpăr un mondeo hybrid și mă cam sperie această problemă. Mulțumesc
@fordc-maxplug-inlife9171Ай бұрын
Salut. La fusion e mai bine la acest capitol. Dar nu trebuie sa-ti faci griji, e o cutie simpla. Sunt proceduri elementare de inlocuire a elementelor defecte. Faptul ca schimbi uleiul la 60k e un + considerabil dar nu e garantie ca cutia va functiona fara surprize. Cumva la buna functionare a acestor tipuri de cutii este stilul de a conduce, cu cat mai agresiv conducii (accilerari agresive) cu atit mai repede se vor defecta rulmentii si alte componente interne.
@thegamepz2 ай бұрын
How did you pull out the stators ? Just disconnect the wiring and then tap on the housing ?
@fordc-maxplug-inlife91712 ай бұрын
Yes. Be careful not to damage the copper wires.
@thegamepz2 ай бұрын
@@fordc-maxplug-inlife9171 great thank you. I will do the work this week. For the bearing races I plan on welding something on them and use slide hammer to take ‘em out. Do you have suggestion for proper tool to pull the races out ? I have 4 Fusion / c max vehicles ( 2 plug in 2 hybrid )buying the proper tools will be good investment Thank you for the videos
@Bethox6 ай бұрын
Hello, good morning, which bearings should I change from the transmission of my 2013 Cmax, and which brand of bearings would you advise? Or where I can buy this bearings ? Thank you
@hbaqleh8 ай бұрын
I'm in CA USA how I can be contact with you
@kristalydaniel31138 ай бұрын
Salut, normal trebuie dat jos toata partea aia , o prostie :/
@carlossoto25479 ай бұрын
The most important thing to know Are the parts needed to rebuilt this transmission available ¿
@mmm463810 ай бұрын
Minute 3:15sec that connection. When I took the small generator out the two clear wires ripped out of connector. I repaired it but guessed which is 1 and which is 4 going off of the winding of wires. My question is are they they same? Both ground? 🤦♂️
@user-tq9xk9sc4e10 ай бұрын
Добрый день. Нужен номер шестерни привода маслонасоса
@erict114411 ай бұрын
English transitional please
@rafaelbudagyan427911 ай бұрын
Good evening. Thanks for the video lessons. Can you please tell me the difference between the automatic transmission between the 2018 Ford Fusion Hybrid and the Ford Fusion Energy Plug-in of the same year? Or are they the same and go against each other?
@rafaelbudagyan427911 ай бұрын
Good evening. Thanks for the video lessons. Can you please tell me the difference between the automatic transmission between the 2018 Ford Fusion Hybrid and the Ford Fusion Energy Plug-in of the same year? Or are they the same and go against each other?
@user-br8fr8ve4t Жыл бұрын
Thanks for your video. Could you provide the screw size of the cabin air filter cover and the trunk Side Trim Screw size of the tab? All of these screws were lost after doing an oil change at Jiffy Lube. Thank you.
@user-br8fr8ve4t Жыл бұрын
@@Andy-kf8dc Thank you.
@andreijereghi4408 Жыл бұрын
Buna ziua.unde pot repara cutia un mester bun
@abdellahrouggani3772 Жыл бұрын
Hey, please where can i found my VIN number ford c max hybrid 2015
@beammeupscottsp7952 Жыл бұрын
I have a 2012 Ford Fusion hybrid with 200,000. Very minor issues just doing regular maintenance, never knew the transmission fluid needed to be changed though, should I not take the risk to change it, seems too late. Lmk your thoughts, thanks.
@fordc-maxplug-inlife9171 Жыл бұрын
if there are no noises from your ecvt, then just check the fluid level, add fluid if necessary.
@beammeupscottsp7952 Жыл бұрын
@@fordc-maxplug-inlife9171 none, will just do a drain and fill
@JohnSmith-sw8fr Жыл бұрын
banda aceea cum ai aduso sa apara in fereastra? sau a fc Forscanul totul?
@fordc-maxplug-inlife9171 Жыл бұрын
rotesti jumatatea mobila a acestui element din plastic pana apare banda. NU forta! ea se roteste cam ~4 rotatii in stanga si 4 in dreapta.
@evghenibasarab8388 Жыл бұрын
Te multumesc mult!
@fordc-maxplug-inlife9171 Жыл бұрын
Ma bucur ca videoul a fost de folos pentru tine.
@ColinPopoviciu Жыл бұрын
👍
@tareqzakarneh221 Жыл бұрын
Does the steering angle sensor fault make it and prevent the power steering does not move ?
@mochomo729 Жыл бұрын
Tengo el mismo problema creo q si ese sénsor inmoviliza la dirección
@nicolaecasir18212 жыл бұрын
Salut. Ești din România sau R. Moldova? Îmi spui te rog unde să găsesc fișa tehnică de la FORD? P.S. Merci mult de video. O să am nevoie de el mâine)
@Cafeitaliafortlauderdale2 жыл бұрын
Scanner software name please
@MmMm-sh8dv Жыл бұрын
@@fordc-maxplug-inlife9171 buna
@ksmv.34372 жыл бұрын
Salut, la un Ford Edge am problema cu motoru de la Adaptive Steering, cel care ajuta la virarea volanului, ai idee dacă este greu de calibrat? Eu am un forscan da nu sunt asa sigur saca as putea singur sa fac operațiunea asta schimbând singur motorașul de sub Airbags.
@juanjaht42772 жыл бұрын
I just remplace clock spring with a new one and dind't work 😭😭😭
@fordc-maxplug-inlife91712 жыл бұрын
More details.... wheel buttons? SRS ? No one? You can verify the clock spring with multimeter
@GallowayChicago2 жыл бұрын
Outstanding video on Ford HF35 eCVT transmission. I have just bought a 2014 Lincoln MKZ 2.0L FWD Hybrid with The Hf-35 xCVT trans and it is leaking out about 3qt, but the car drives great. Because of the leak the Transfer-shaft assembly (EG9Z-7H348-A) bearing and cup should be shot, but those parts only cost US $410 right now. Is it possible to put a rebuilt used HF35 eCVT or even a newer Ford 2017-up HF45 eCVT and not have to reprogram the power transfer unit? The only cable that comes out of both trans are the hi-voltage drive/regen motors and the low-voltage data cables (that reads both motors temp and speeds). From what I have read; the HF35 has no brain or need for VIN programming itself. I ask because my locale Lincoln Dealer just quoted me US $10,000+ to replace the HF35, recalibrate the Lane-departure system, and realign the wheels. Since I was not born yesterday and value my family's treasure, I figured I would ask an expert. The car is beautiful and still drives it just need seals and bearings but no trans shop in or near Chicago will touch these eCVTs due to Ford's EV service equipment requirments (an anti-static bay). I have removed FWD trans and replace clutches before and I am thinking of removing and rebuilding my own trans because of inflated dealer costs. Any help you can provide would be much appreciated "for eductional info only... lol". Thank you for your time, sir. BTW: Can you do a trans removal video on the HF35 and HF45? That would be amazing.
@fordc-maxplug-inlife91712 жыл бұрын
About HF45, I can not give you any advice because I have no experience with it. About HF35, YES absolutely. Inside transmission are a few themperature sensors and two resolvers. There is no electronic component that store VIN or serial number of transaxle.
@GallowayChicago2 жыл бұрын
@@fordc-maxplug-inlife9171 Question: On the HF35 trans when replacing a DG98-7000-EC transmission with a "Used" Transmission, there should be no need to reprogram the trans-control-unit... right? I just need to make sure the FHEV 2.57 matches on both trans? My concern is that the HF45 trans has a different timing and is there by incompatible with the earlier HF35 TCU. But putting the HF45 aside, It looks like removing the 175lb HF35 trans from my 2014 Lincoln mkz is as easy as: (1)removing the 12V battery, (2) Pulling the HV disconnect, (3) putting the front of the auto up on jack stands and removing the front tires, (4) draining the trans, (5) removing the HV trans lines from both the trans and the TCU and cover the holes with duct tape, (6) removing the trans cooler lines, (7) supporting the ICE, (8) support the trans with a trans jack, (9) remove both drive shafts, (10) unbolt and drop the trans. Did I miss any steps? My plan is to try to inspect the trans and either rebuild the HF35 eCVT trans or buy a used trans and inspect then install it. The black data connector on the front of the trans that has, what looks like, 26 small wires coming out of it. Maybe I under estimate Ford's ablity to complicate simple data ports. Maybe Ford put a simple ID chip in the connector to limit peoples ablity to swap transmissions. It just seems like way too many wires for two speed and temp sensors. Trying to make it work in Chicago. Thanks
@fordc-maxplug-inlife91712 жыл бұрын
sorry for late answer. On c-max the transmission can`t be removed with engine mounted on frame(lack of space), 1remove transaxle with engine and after transaxle from engine. There is no any chip in connectors. As I mentioned, in hf35 ecvt is only two resolvers and 3 themperature sensors and gear position switch. If your transaxle is in bad condition, by another one with guarantee or if it can not be with guarantee open it and make an inspection to be shore that all componets are in good conditions (if you open it replace filter and pump) also pay attention to pump drive gears. good luck
@raytech14792 жыл бұрын
Im receiving codes c45282 and c42082 what are they please
@alton982 жыл бұрын
Can I get a copy of the rebuild sheets for torque specs?
@Bessy7603 жыл бұрын
Although I do not understand a word of the language this is the best video for showing the replacement of the filter. Because I am in the UK everything is on the other side.
@Keelowat3103 жыл бұрын
Where can I get a rebuild kit?
@costeaspinu13143 жыл бұрын
Salut, eu am obiceiul cand se pornește automobilul (Ford Fusion PLUG IN) pe baterie dimineața să apăs acceleratorul și să pornesc motorul pe benzină. Automobilul e în parking, e bine ceea ce fac? Multumesc anticipat.
@user-qy5xz1bp7d3 жыл бұрын
на русский переведи !!!
@fordc-maxplug-inlife91713 жыл бұрын
а что переводить, как открутить болты?
@a7_delta2 жыл бұрын
@@fordc-maxplug-inlife9171 Подскажите пожалуйста, где Вы раздобыли это прекрасное руководство по коробке, которое лежит в левом нижнем углу на Вашем видео :) Как оно называется?
@catalindumitru37203 жыл бұрын
Buna, am si eu un C Max Plug - In ca si al tau , este din 2015 service facut doar la Ford , are 213000 km din ce am vazut in service - ul masinii , nu are schimbat uleiul in cutia de viteze; ar trebuii sa merg la Ford sa- l schimb , avand in vedere ca ai spus ca sunt probleme cu cutia; ce probleme ar mai putea aparea , la ce sa fiu atent si ce sfaturi mi - ai da ? Multumesc . P.S. Faci bine ce faci , continua .... bravo.
@vladdumitrescu75883 жыл бұрын
ce soft de diagnoza ai folosit te rog? si ai idee daca merge si cu Mondeo Mk4?
@fordc-maxplug-inlife91713 жыл бұрын
forscan-ul cu adaptor ELS27, ucds-ul tot e ok. DA va merge, tot de`o mama sunt facute aceste masini.
@nestorandresramirezorozco35423 жыл бұрын
@@vladdumitrescu7588 Hello, good video, thank you, could you enable the subtitles in English or Spanish?
@MereacreigorCqkcqk3 жыл бұрын
Salutare cine are nevoie de ax și roțile dințate sunați-mă 078370904
@alaojog53523 жыл бұрын
Se poate nr de telefon va rog?
@fordc-maxplug-inlife91713 жыл бұрын
nr. de telefon al meu? ☺️ Pentru ce aveți nevoie de el?
@alaojog53523 жыл бұрын
@@fordc-maxplug-inlife9171 am lincoln mkz doresc o diagnostică
@fordc-maxplug-inlife91713 жыл бұрын
Sunt o persoană privată, nu prestez servicii ce ține de reparația mașinilor. Ce probleme aveți cu mașina? Mai multe detalii.
@alaojog53523 жыл бұрын
@@fordc-maxplug-inlife9171 scrieti-mi va rog adresa la servis,din acest video
@fordc-maxplug-inlife91713 жыл бұрын
Acel service nu e specializat in reparatia masinilor electrice(hybrid).Eu personal mi-am reparat masina. Eu incerc sa va ajut, pentru aceasta descrieți problema. Daca doriti sa schimbati ceva piese pe suspensie daca doriti sa va schimbe bugiile daca doriti sa va schimbe uleiul, puteti merge la ei. Daca aveti probleme cu componentele hybride(bateria de tractiune, cutie, invertor) ei nu sunt specializati in reparatia acestor componente. In postare eu le spun numele: "Profi Service", culegeti, google le stie pe toate.
@pharmercist3 жыл бұрын
Sadly, not in English. Could you re-release with an English language overdub? The video looks useful.
@Vo4ikgros3 жыл бұрын
Interesting and helpful video :)
@alinburnea24593 жыл бұрын
Salut! Cat costa o cutie sh sau reparatia? Un numar de telefon de unde pot cumpara sau unde pot repara. Multumesc.
@cezari223 жыл бұрын
Buna ziua. La mine tot se aude un zgomot anume la motoru pornit pe benzina. Daca problema e pompa de ulei e posibil de schimbat pompa? unde se poate de gasit pompa data?
@fordc-maxplug-inlife91713 жыл бұрын
Buna ziua. Mai întâi trebuie sa va asigurați ca într-adevăr e pompa sursa sunetului nedorit. După cum am menționat si in clip pot fi defecte axul si rotile dintate care pun in miscare acea pompa. Pompa noua se procura din state. Celelalte componente nu se vand separat. Componentele care nu pot fi procurate ca noi se cauta la dezasamblare auto. Sunt si in Chisinau si in Tiraspol cateva.
@cezari223 жыл бұрын
@@fordc-maxplug-inlife9171 unde se poate de verificat de la ce precis e sunetu?
@AA-tt5ok3 жыл бұрын
Thanks for sharing 👍
@cezari223 жыл бұрын
Buna ziua. Unde va aflati? am si eu unzgomot asemanator in cutia de la c-max energi. As vrea sa ma consut.
@mdhossain19893 жыл бұрын
Where did you buy the replacement parts from? I need the oil pump driver gear.
@fordc-maxplug-inlife91713 жыл бұрын
Unfortunately, I couldn't find a new drive gear. I asked a Ford representative and they told me this component is not sold separately. I used an oil pump drive gear removed from a different transaxle.
@Pastado3 ай бұрын
@@fordc-maxplug-inlife9171hello, do you have an email I’ll send you a 30 sec video you might help me to locate the problem, please!
@Vo4ikgros4 жыл бұрын
Om cu maini de aur )
@mrfoodiebear64614 жыл бұрын
Obd code please?
@fordc-maxplug-inlife91714 жыл бұрын
this is a mechanical problem. At this moment you will not have any OBD error code. But, you will hear noise from your transaxle.