5.9 CUMMINS LACK OF POWER and the repair

Рет қаралды 25,143

Күн бұрын

5.9 CUMMINS LACK OF POWER. In this video I share with you about a 5.9 Cummins with intermittent lack of power, the cause and the repair. Turbo and Exhaust manifold repair along with some tech tips.
RING LIGHT
amzn.to/3tTNS6j
FLASHLIGHT HOLSTER
amzn.to/2QYhBfM
OBSERVER TOOLS FLASHLIGHT
amzn.to/3nn4UHu
STREAMLIGHT HEADLAMP
amzn.to/2QXPZaK
AIRLIFT
amzn.to/2TSBebg
Find me here:
linktr.ee/tonennorcal

Пікірлер: 28

@greasee.monkey7224 2 жыл бұрын

That job looks like a bit of a PIA. Thanks for the tips & tricks sir. Every little bit helps. You make great content that helps other mechanics by saving them time and effort. It is most definitely appreciated. 👍👍

@NutsandBoltswithTone 2 жыл бұрын

It was a PIA haha. I am happy to be helping other techs. I appreciate it brotha

@gerryrandolph 3 ай бұрын

I have the exact same thing on a truck I’m looking at buying. Was concerned bout the shear gutless performance and your video has shown me what to check and help determine this trucks issue. Then start beating the guy down on price 😁

@NutsandBoltswithTone 3 ай бұрын

Very nice, they are great trucks when running properly. Good luck and thx for watching

@alridha1810 Жыл бұрын

Thank you very much I had same issue with my truck 05 5.9 Cummins 6spd dually Power loss at top end everything checks good Air filter bunch it up like how you describe it Problem solve Thanks again you are awesome

@NutsandBoltswithTone Жыл бұрын

Awesome, I am happy that is all that it was. Thank you for watching.

@ToolDemos 3 жыл бұрын

Good stuff, Tony. That looks easier than a Duramax, you have more room at least.

@NutsandBoltswithTone 3 жыл бұрын

Oh for sure . Thanks for watching.

@brucerazor5202 Жыл бұрын

I have a 99 Cummins with 185,000 nice and tight, no leaks 5 speed manual. Steering has been supported , new injector pump and lift pump

@NutsandBoltswithTone Жыл бұрын

Ok, is there a problem? If so please message me over on instagram and I can help you out. thank you for watching.

@nosliwttam77 3 жыл бұрын

My boss would have said to glue the mesh back onto the filter and make it work🤣👍

@NutsandBoltswithTone 3 жыл бұрын

Haha crazy. The aftermarket filter was about one inch thinner then oem filter also.

@skinwalker7635 2 жыл бұрын

Hey Tone you mentioned how you could duplicate the acceleration issue, after the vehicle loses power what would you do to reset the vehicle so that it would drive at normal operational specs and start all over again ?

@NutsandBoltswithTone 2 жыл бұрын

Hey bud, in my situation the air filter would suck in and cause the airflow restriction, then when throttle was let off air filter would let up a little. The filter would pull in then release. This vehicle was not going into limp mode or anything it would just have lack of power due to not enough air entering the turbo. Thank you for watching the video I appreciate it.

@richardknight7549 Жыл бұрын

I have a 2006 ford f650 rollback with the 5.9 Cummins. The egr transfer tube just started leaking/hissing, and when it does it seems to have loss of power. It has been doing this same cutting in and out of power under load thing you described in the video. Do you think egr pipe leak would cause the loss of power? I figured that was only exist gas, not boost. Any input you have would be helpful. Thanks man. -Rick

@NutsandBoltswithTone Жыл бұрын

Honestly any exhaust leaks can contribute to a lack of power on a diesel but the kind of lack of power I had in this video was the Turbo getting choked, cannot produce any boost if you cannot breathe. If you message me on Instagram I can try to help you out. Thanks for watching.

@dougmcmurrey7801 2 жыл бұрын

2003 6bta 5.9 marine idles great, when turbo spins up around 2200rpm and higher, tons of power and clean.. on the way to 2200, she smokes and is very slow to speed up … thoughts?

@NutsandBoltswithTone 2 жыл бұрын

That is an odd one. If you message me on Instagram we can discuss this back and forth and hopefully help you figure it out. Thank you for watching.

@deborahbrown7613 2 жыл бұрын

@@NutsandBoltswithTone I have a 2002 Ford F750 5.9 Cummins engine it's a box truck and it's reading stop engine losing power what do you suggest the problem may be?

@fixitallpaul4847 3 жыл бұрын

Should you also straight edge the head?

@NutsandBoltswithTone 3 жыл бұрын

Not really, I've honestly never had an issue with the head just the manifold. If you pull cylinder head u should always straight edge the block though.