Engine Oil Cooler Re-Seal + Intake Manifold Removal

Engine Oil Cooler Re-Seal + Intake Manifold Removal - 3.0 TDI CNRB

Рет қаралды 1,660

Ай бұрын

One of the most annoying issues with the CNRB 3.0 TDI, is their coolant leaks - lets go over how to knock this job out efficiently so you can get yours back on the road!
Needed Parts:
Intake Manifold Gaskets - bit.ly/4ea8y1N
Engine Oil Cooler Gasket Set - bit.ly/3WUSIBK
Coolant Flange - bit.ly/3UXRDGT
Optional Parts:
Serpentine Belt - bit.ly/3yDBlvd
Vacuum Bypass Valve: bit.ly/3V0n6Is
EGR Delete Video - • 3.0 TDI EGR Cooler Del...
Follow my Socials:
isthatguyty...
wrecklessco...
/ thaguyty

Пікірлер: 28

@sawfishv6565 Ай бұрын

Great video! I have to do the same thing on my CPNB soon plus intake valve cleaning Thank you 👍🏻

@jkon156 Ай бұрын

You werent kidding about everything going wrong all at once. my CNRB touareg at 111k has needed EGR cooler, Water pump, and now i need to do a oil cooler and valley reseal. All within the last 2k miles.

@ThatGuyTyy Ай бұрын

Once it’s done oh man, bullet proof

@jkon156 25 күн бұрын

In the middle of getting the manifold off and I noticed I've got a bad injector seal. Yippee!

@parkerbethke Ай бұрын

What happened to cjaa content? You were my only guy on YT for that! At least, out put all the things I wanted to put on a tdi on one so an inspiration at that

@kdudutse Ай бұрын

check out Josh's Jetta's - lot of cjaa content

@andydelassus2734 17 күн бұрын

I’m in Minnesota, you’re in Canada. I wonder how important that oil cooler *actually* is for us in colder climates. Which leads me to wonder if someone makes a block off plate 🤔 one less thing to leak again

@kdudutse Ай бұрын

thanks for sharing i have a cnrb in Touareg, curently at 185000km and no valley leak yet, but sure it coming

@ThatGuyTyy Ай бұрын

Fingers crossed

@mohammadrezakhalaj9128 Ай бұрын

you had chance to clean the manifold and EGR, Why not covered the engine holes after removing the T, You was lucky nothing fall off into your engine! good job

@ThatGuyTyy Ай бұрын

Low mileage engine, EGR wasn’t that dirty, yes you’re right, didn’t drop anything into my manifold

@bryanshaw382 13 күн бұрын

Brilliant video buddy 🙏. Can i ask what instruction sheet you referred to a few times, thanks

@ThatGuyTyy 13 күн бұрын

ELSA VW workshop docs

@bryanshaw382 13 күн бұрын

Thanks for the response my A7 is suffering from this just now and seriously considering giving it a go myself and your video is the first that has made sense so far. But would love a manual to keep me on track

@ryanmelville6855 Ай бұрын

Did you have a bunch of sludge in the intake to clean out as well?

@ThatGuyTyy Ай бұрын

Just after where the EGR pipe entered the intake yes, nothing too crazy, but a big reason why I deleted my EGR later on as well

@404marc Ай бұрын

What a maze!

@ThatGuyTyy Ай бұрын

It’s a tricky one for sure, but time and patience is key on this one, especially with the manifold

@404marc Ай бұрын

@@ThatGuyTyy for sure.. so a previous video you did the egr delete, but this video you removed then reinstalled the egr? Out of sequence or two different cars?

@ThatGuyTyy Ай бұрын

@404marc out of sequence, I ended up deleting my egr basically a week after doing this video and was just eager to post the delete install haha

@404marc Ай бұрын

@@ThatGuyTyy I have a 14 A6 tdi. My guess is coolant and oil consumption would lead you to believe the gaskets (valley leak) are bad?

@ThatGuyTyy Ай бұрын

Yes, if it fills up enough it will run down the back and the front of the motor as it will spill out of the valley, but it can hold about 4L of coolant in there. And i would say if it’s not mixing in your coolant or vice versa is probably be the valley leak - you can typically see right down to the back of engine oil cooler between the driver side of the HPFP and the intake manifold with the egr cooler still install

@markfreeman2022 Ай бұрын

Are you going weight reduction in the vehicle? What is the driver loses weight too haha! How much do you weigh?

@ThatGuyTyy Ай бұрын

I delete the dpf and exhaust stuff to balance out when I eat a full cheesecake in one sitting 😉

@ThatGuyTyy Ай бұрын

I will be doing the full SCR system save some more weight tho, so yes! I honestly should weigh my dpf and such as well to see how much weight I lost on the car doing the deletes

@markfreeman2022 Ай бұрын

Yes, you should weigh it! 👍👍do you still weigh 177 pounds? Your weight reduction video from 2 years ago

@ThatGuyTyy Ай бұрын

Nah I’m a bit thick now 😂 glad it’s not too noticeable

@markfreeman2022 Ай бұрын

You are a bit thicker now, really? I bet you weigh like 185 pounds now!