23k for a gearbox??? What car

🎉

Sir construction of parts gets change with time and revision , so if you want to buy then buy the latest revision of parts , as new revision usually addresses the issue with the older once

@@yourDIYneeds But will I get original shifter cable ends separately ?

Sir it comes as a set , along with new shifter mechanism

Sir if its opening for the first time then , the clips will be tight

@@yourDIYneeds yes.. i used some amount of pressure but it won't ... I fear sometimes the leather area may tear off..I'll try after few days again as my silicon spray is over ..Need to get a fresh one... another doubt.. this time I used your video and did annual oil and filter change by myself . Thanks for your video.. when jacked up the car, i saw some oil film . The location is the RHS drive axle starting area from gear box. Just before the inner axle boot , there is a cylindrical area, at that area there is a film of oil.. any hints? Thank you..

Chances are either axle boot have a crack from which the internal grease is coming out or , just above that area , there is intercooler pipe which is very prone to leak from joints and seep oil .

Sir are the bushings in good condition ?

Sir its 2014 , Volkswagen polo 1.5 Tdi

Sir , when i did it it was perfect in the first go , all the gears were engaging as they should . And sir it has an electrical assisted steering so it doesn't have a power steering fluid system

Yes , calibration is what you need sir

Sir it can be just adjustment of the gear cables , As it is i did it in the video , if your clutch is not slipping then it can't be clutch . So just perform the calibration once and then proceed

Yes sir most probably it's a calibration issue , if assuming everything else is ok with the gearbox , like lubricant and synchroniser

@@yourDIYneeds Thanks for your reply sir, even the clutch plates and everything were replaced and this problem has raised recently doesnt happen always but all of sudden once or twice after driving for long hours.

sir , battery to chassis and chassis to engine grounds check kar lo ek bar , thoda sa hint mil jaega , or ek bar jab 2-3 din baad start karo to us se pehle battery ki voltage check kar lo , kahi aisa na ho ki battery drain jaldi ho rahi ho

Sir this video which you commented on is exactly the process you need to follow , your gear slots got out of calibration , it just needs re-aligning

@@yourDIYneeds thank you for your prompt reply!

Anytime sir

@@yourDIYneeds It worked like a charm. But I feel my gear handle is bit loose, may be its way out. Thanks Again!

This will solve your issue sir

Sure sir , next 2 videos me se ek wohi hai

Same sir , it needs adjustment

Sir you need to calibrate the shifter , it got out of alignment

Thank you sir

Gear Shifter End

soon , time hi ni mil pa raha 😅

Sir no , i arranged it from a scrapyard , a almost new car which was just 1 year old got totalled due to rollover .

@@yourDIYneeds sir can we do calibration ourselves ?

Yes sir , you can its easy

Sir you need to follow the exact process to calibrate all the gears

Sir OEM shifter knob comes with leather gator attached , its around 6.5k , i have shipped one for a viewer a year back . At that time it was unavailable online

@@yourDIYneeds it's expensive 12k in vw and 7k around on boodmo

Sir yes , last year i got it for 6.5k from my parts supplier

@@vinaykumar6407 did you manage to get shifter

Sir , i showed the process , as my parts were in transit and got late , they can't be swapped due to different sizes and i showed the process of calibration of gear shifter and lever .

Yes sir

Hello

Sir vw jetta 2010 gear lever free ho Gaya h how to repair

Sir gear linkage ki rubber toot gai hogi , sabse pehle to wo check kar lijiye Video hai channel pe , "gear lever loose" naam se

@@yourDIYneeds nahi ok h sir vo to gear bilkul free h

Reply sir

Sir wd40 is a penetrant and rust inhibitor but its not a good lubricant , use a dedicated lubricant spray , it will be much better

@@yourDIYneeds Alright. Thank you so much. Could you please recommend a product? Thanks

Sir there are various grease sprays available online and offline , like castrol and all , you can pick any one of them . They all are decent

@@yourDIYneeds Thank you so much for you help 😊