Harbor Freight Storm Cat 2 Cycle Generator - First Start and Tips
Рет қаралды 75,047
7 жыл бұрынHarbor Freight Storm Cat 2 Cycle Generator. Rated 700 running watts / 900 peak watts. #69381
Have watched these generators for years finally bought one.
Tips and suggestions:
Before first start remove spark plug and add some 2 stroke oil and a bit of Seafoam into the cylinder. Then spin engine over a few cycles. This will lube the crank shaft, pushrod, and rings.
Use "Pure Premium" gasoline at all times it contains no ethanol.
Use a great quality 2 cycle oil mixed with your gasoline at 50:1. I prefer Mystik brand two stroke oil. Here is what I use...
www.mystiklubes.com/do/produc...
Remove all electrical load before stopping the generator.
Stop the generator by turning off the gas valve and letting the engine run dry.
Store the generator with the carburetor dry. This will keep seals and gaskets from swelling. Will also keep gummy varnish from forming.
If your gas and oil mix will be stored longer than 30 days add 2oz of Seafoam per gallon. This will help stabilize your gas mixture. You can find it here:
seafoamsales.com/sea-foam-mot...
Send me your 2 cycle engine questions.
Visit my site for parts that make your gun run better:
www.sjhardware.us
@jgg204 7 жыл бұрын
i love these things, i just wish they made them like they used to. back before i did emergency disaster prep, i had one of these but the blue top Chicago Electric version (the old one). bought brand new from HF in 2011 for $79.99 and bought the extended warranty for $16.99. enter hurricane sandy....i was caught with my pants down basically. luckily since i have natural gas and a steam boiler (water heater is nat gas too and atmospheric venting)...i was able to keep the heat and hot water on (i wired up a plug the 1st day of sandy and ran an extension cord to the extension cord branch i had coming into the house from the generator. in addition, i had my full size 18 cu ft fridge running off it and a bunch of CFL lights that i would have on throughout the house based on which room i was in at any given time. basically ran it full time on reg gas and supertech 2 stroke oil from walmart for 4 1/2 days. burned through about 35-40 gallons of gas but man it pulled through. a few months later one day i went to run it and it blew out, was replaced under warranty with the new Storm Cat red top one. the Storm Cat cant even handle the compressor surge of my fridge and just trips off. what a shame. now i have a pair of SMarter Tools AP2000iQ gens
@yumann 7 жыл бұрын
Very useful info. Thanks!
@Lanninglongarmmowing 7 жыл бұрын
You put a little bit of 2 stroke in the cylinder for lubricant but run it out of gas and lubricant when putting it away for storage. Next time you start it up, how does it still have lubricant in the cylinder if you ran it out of gas?
@04BlueSmoke 7 жыл бұрын
Thanks for the ??? Once the engine is in a running mode there is always residual oil left on the moving parts (Yes even after storage). A two cycle engine is designed for the gasoline in the mixture to evaporate and ignite and the residual oil that does not evaporate stay behind and lubricate the moving parts. I recommend adding some oil in the cylinder when a two cycle motor is new just to make sure the crankshaft and cylinder walls are lubricated upon initial start up.
@TeamBlindMouse 7 жыл бұрын
the manual for the new Tailgator says to change the fuel oil mix after the 25 hour break in....any suggestions as to what to switch it to ?
@04BlueSmoke 7 жыл бұрын
The manual recommends 50:1
@TeamBlindMouse 7 жыл бұрын
do you clean the inside of the fuel tank for metal shavings first ?
@04BlueSmoke 7 жыл бұрын
No, I did not clean the inside of the fuel tank first.
@MrLeo174 7 жыл бұрын
hey scott can i use trufuel 50:1 mix for it
@04BlueSmoke 7 жыл бұрын
Yes, Trufuel is good. No ethanol. My only complaint about it is the cost.
@hp5man 7 жыл бұрын
You added a little oil and sea foam to the cylinder to provide some initial lubrication to the engine. Would any of that get past the piston rings to get down to the crankcase? I've just bought a similar generator and was thinking about removing the exhaust system to get a bit of oil onto the crank before the first run.
@04BlueSmoke 7 жыл бұрын
I think some oil / Seafoam would make it past the rings to the crankcase. There are intake and exhaust ports near the bottom of the piston stroke that become uncovered during cycling .... And.... I wanted to lube the rings and cylinder walls as well. Scott
@aaronyork6173 6 жыл бұрын
If you turn the gas off and run it dry isn't that starving the engine of oil?
@04BlueSmoke 6 жыл бұрын
No... there is enough oil remaining to coat the moving engine parts. Only the gasoline vaporizes and burns in the engine. The oil remains on the moving parts.
@Dr2009king 7 жыл бұрын
Why over tightening the plug Scott ? .
@04BlueSmoke 7 жыл бұрын
Just needs to be snug. Crush the washer to guarantee a good seal.
@davids9139 7 жыл бұрын
who sells the mystic oil?
@04BlueSmoke 7 жыл бұрын
Hi David, I live in the upper midwest. I get all my Mystic oils at Fleet Farm.
@Dive-Bar-Casanova 7 жыл бұрын
I've seen it at Walmart.
@Dive-Bar-Casanova 7 жыл бұрын
The Home Depot version is now 1000 watt and a little over $100.
@Dive-Bar-Casanova 7 жыл бұрын
Run 4 hours unloaded when new at 35 to 1 gas.
@04BlueSmoke 7 жыл бұрын
I run 40:1 all the time. ..... and exclusively use Mystik oil.
@jgg204 7 жыл бұрын
oh make sure you get the 69381 model version of this, there are two. the 69381 is better made edit: i see you did that, nevermind lol
@ewsconstruction6421 7 жыл бұрын
jgg204 I have the other model. should I get rid of it and get the other one? what's wrong with the other one?
@04BlueSmoke 7 жыл бұрын
No ... I wouldn't get rid of it. How does it run when there is a load on it? If it is smooth with no knocking I wouldn't worry about it. Just run it....
@ewsconstruction6421 7 жыл бұрын
Scott Mueller I am going to test it with a 600 watt heater
@ewsconstruction6421 7 жыл бұрын
Scott Mueller I am gonna pick up a 69381 today selling the other before it breaks on me lol
@ewsconstruction6421 7 жыл бұрын
Scott Mueller Just picked up a 69031 on cl for $40! major quality difference than the 60338.
@waynerhea6649 7 жыл бұрын
these generators are really small and convenient but the problem is it makes way to much noise. if your going to the beach or a campground you'd most likely get kicked out especially if it's a public beach or if there are people near by.
@04BlueSmoke 7 жыл бұрын
Yes, not too quiet. They are great for what they are.
@rogerkerkmann 7 жыл бұрын
a little overkill, $100 generator, $10 seafoam, $10 plug, synthetic oil, it's a throwaway!
@04BlueSmoke 7 жыл бұрын
Hi Roger, I guess it depends on how you define "throwaway." A user I am aware of has over 2000 hours on a two stroke generator like this. Seafoam I have ... for many uses, Plug is $3, you need oil anyway.... might as well use the good stuff... Mystik.
DIY On The House
Рет қаралды 41 М.