LPG leak testing in self build camper van Citroen Relay / Ducato / Boxer / Promaster

Рет қаралды 4,190

2 жыл бұрын

In this video I use a leak detection spray to test my LPG gas installation for leaks and commission the system. You should always have your gas system tested and inspection by a qualified gas safe engineer, but this spray test method will allow you to fix any small leaks saving both time and therefore money, when the engineer is with you as he will not have to do this and can crack on...
The Leak test spray is available from any good plumbers merchants.
Music: www.purple-planet.com

Пікірлер: 20

@sirbrian9404 2 жыл бұрын

Shame it's all coming to the end now me old mucker will miss you and your lad brilliant insight and the little technique you showed us absolutely brilliant thank you stay safe 👍

@wiltshirecustomcamper7203 2 жыл бұрын

Thank you for your comments right from the start. much appreciated. It is far from the end of the channel though as I am currently in negotiation for my first 'commission' to do a conversion for someone. very exciting. A new L4H3 Ducato with similar layout but no LPG or Truma and lots of Lithium Batts to run induction cook top and electric water heater and Webasto diesel heater. watch this space....

@malcolmleick8405 Жыл бұрын

Really useful. I did see another video where someone had their system checked by a gas engineer and they said that copper olives should be used with lpg instead of brass. I’m going to have to check my own as I can’t remember which I used.

@wiltshirecustomcamper7203 Жыл бұрын

Thanks for the comment. I must admit I did not even look at what olives they were, they are just the ones that came in the fittings! it has been a year now since install and all is good and I have checked all the connections again recently with the spray and no bubbles!

@stevebrown6665 2 жыл бұрын

Could I add that I have found leaks that the leak spray couldn’t detect but a manometer did find (got my ACOPS hat on at the moment) Love your videos all the same and your presentation style! I’m not really keen on the 13a socket near a gas fitting though

@zx10rmac84 2 жыл бұрын

Fairy liquid suds same mate, used it many times. On a mark 5 cookset ✌️🇬🇧

@stevebrown6665 2 жыл бұрын

As a trained/qualified gas engineer I’ve always suggested not to use washing up liquid as that can cause corrosion due to the salts it contains

@micathasteings 2 жыл бұрын

Much app for the tip with fernox

@goingmouch3753 2 жыл бұрын

Nice splash back in the galley… Will you be doing the video on installation of that? Thank you

@wiltshirecustomcamper7203 2 жыл бұрын

I did not really film that part to be honest. I simply made a basic frame out of B&Q 34x27 timber to fix it to to it was fairly straight up and that was about it. so there is a gap behind between the red splashback and the solway panel, only a couple of inches....

@leswoods3423 2 жыл бұрын

I've only just started watching your videos very good. Have you done other vans up ? I love to do it do you work to a budget.

@wiltshirecustomcamper7203 2 жыл бұрын

Thanks for the comment. It is my first build but I suspect will not be my last. In regards to budget, yes I did have a budget in mind but I worked out carefully before starting how much all the components and equipment would be so had a very good idea of what the total build cost would be. Would suggest to anyone starting out to do tons of research first and have a spending plan for what you want to install in your van. then add a good 20% to 30% on top for misc expenses etc and your good to go. hope that helps.

@sccobyste Жыл бұрын

Do you think there is space under your van to fit a box to fit a battery as I am thinking of fitting a 400ah lithium but would be great to have i5 underslung

@wiltshirecustomcamper7203 Жыл бұрын

I am sure there would be space although I dont think I would put a lithium battery under the van even if in a box, my concerns would be: wet, damp, dirt, damage from road debris, cold etc etc. You of course do what is right for you and your van but I would not do that. all the best with it.

@camperblackmagic7603 2 жыл бұрын

Great common sense video ,

@wiltshirecustomcamper7203 2 жыл бұрын

Thanks!

@marknottingham1593 2 жыл бұрын

Did you have to route a gas pipe across from one side of the van to the other? I have to do that myself, and I'm not sure whether to run it under the sub floor, or under the van. I would be intrigued to know what you did - if you did! :-)

@wiltshirecustomcamper7203 2 жыл бұрын

Yes, mine goes under the subfloor along with the hot and cold water pipes. i used one continuous length with gentle bends at either end and elbows/joiners in locations where accessible.