Makita Li-ion Battery Repair BL1830 Not Charging

  Рет қаралды 58,983

TI Restoration

TI Restoration

3 жыл бұрын

Repairing li-ion battery 18V, disassembly, replacing cells and PCB board, assembly, test

Пікірлер: 21
@Yassn-hp3px
@Yassn-hp3px 2 жыл бұрын
كم سعه الشاحن الذي بيشحن البطاريه 14فولت هل يصلح اشحنه بشاحن12فولت
@TIRestoration
@TIRestoration 2 жыл бұрын
الشاحن من 7.2 - 18V , نعم يصلح و شكرا
@jivko77sz
@jivko77sz Жыл бұрын
hi can you have the exact link from the purchase of your board
@TIRestoration
@TIRestoration Жыл бұрын
The board I purchased was from aliexpress.com, type in the search bar '18v makita bms' and it's the first picture. Good luck
@andrebruscao6120
@andrebruscao6120 4 ай бұрын
My batery is charging but doesnt work.. What do you think could be the problem?
@TIRestoration
@TIRestoration 4 ай бұрын
test the battery with a multimerer to ensure it is holding a charge and inspect the terminals Good luck
@majidshahraeini2236
@majidshahraeini2236 Жыл бұрын
Hi ,thanks for your video Is it need change chip also or no, because I saw U change it
@TIRestoration
@TIRestoration Жыл бұрын
Yes, you need also to change the chip/pcb board otherwise the charger will give a fault and not charge the battery. good luck
@TheEhssan0
@TheEhssan0 2 жыл бұрын
I have BL1840B, do you know that all PCB board are the same?
@TIRestoration
@TIRestoration 2 жыл бұрын
The new PCB boards are compatibel with: Makita 18V BL1830, BL1840, BL1850 and BL1860. Good luck
@TheEhssan0
@TheEhssan0 2 жыл бұрын
@@TIRestoration are you sure? Can you provide me the link for purchasing? Bcz my board are bigger than your board ! Plz help me
@TIRestoration
@TIRestoration 2 жыл бұрын
@@TheEhssan0 Check on 'aliexpress.com' then search for "pcb for bl1840b". Good luck with purchasing
@TheEhssan0
@TheEhssan0 2 жыл бұрын
@@TIRestoration I already did it, 1840 nothing there!!
@TIRestoration
@TIRestoration 2 жыл бұрын
@@TheEhssan0 It's hard to find one exactly like the original because Makita doesn't sell PCB boards, only complete batteries. You can look for one that most resambles the original. good luck
@frodemolland6249
@frodemolland6249 3 жыл бұрын
Hi, aint soldering these cell VERY dangerous? They can explode of the heat?
@TIRestoration
@TIRestoration 3 жыл бұрын
The cells can withstand some heat of the soldering iron, the heat is not that high to cause an explosion, only if there is a short circuit.
@yayanarchy8394
@yayanarchy8394 2 жыл бұрын
It's really overstated. For a half-decent reason I guess. The problem is that if someone attempts it and doesn't use proper flux, doesn't use a nice wise chisel tip to heat it quickly, solder, and move as to not heat the cell itself, then you could have some serious problems. You also want to keep off the center part of the bottom of the cell, since that's where the machine sealed the negative contact to the outside of the cell, and is a weak point.
@Eblanc
@Eblanc Жыл бұрын
@@yayanarchy8394 thanks for this tip. exactly what I needed.
@Novacasa88
@Novacasa88 2 жыл бұрын
Do you know the specs of these cells? I'm trying to replace mine Thanks
@TIRestoration
@TIRestoration 2 жыл бұрын
These are 18650 cells, it depends on which battery you have, the 4Ah or the 5Ah battery has cells with a higher capacity than a 3Ah battery, the minimum cell capacity of a 5Ah battery is around 2500mAh, the voltage is the same around 3,7V for each cell. good luck
@Novacasa88
@Novacasa88 2 жыл бұрын
@@TIRestoration Thank you I have the 3mah older makita battery like in the picture. So I'm guess this means each cell is probably 2000mah at 20amp rating?
Ремонт аккумулятора шуруповёрта Макита
18:21
How I Fixed My Faulty Makita Battery
27:41
Scooby Rolla
Рет қаралды 590 М.
Эта Мама Испортила Гендер-Пати 😂
00:40
Глеб Рандалайнен
Рет қаралды 9 МЛН
顔面水槽がブサイク過ぎるwwwww
00:58
はじめしゃちょー(hajime)
Рет қаралды 83 МЛН
ISSEI funny story😂😂😂Strange World | Magic Lips💋
00:36
ISSEI / いっせい
Рет қаралды 113 МЛН
Repair Makita BL1830 Battery By Making One Good From Two Bad
7:28
Well Done Tips
Рет қаралды 910 М.
Akumulator Makita PA14 14.4V 1.3Ah Ni-Cd
50:21
weryfany
Рет қаралды 88 М.
Repacking Makita 18v Lithium battery with New Cells (Save $$$'s)
10:56
Makita 18V Battery Has Big Problem!
8:40
Well Done Tips
Рет қаралды 440 М.
Makita 18V Akku DEFEKT? Reparieren eines BL1830 - Battery Repair
1:01:32
Claymans Handwerk
Рет қаралды 176 М.
MAKITA RAPID CHARGERS HAVE A HIDDEN FEATURE YOU DON'T KNOW!
9:08
VCG Construction
Рет қаралды 517 М.
Рециклиране на батерия за винтоверт 18V / 3Ah MAKITA
8:24
Акумулаторен център СТАРТ - Варна
Рет қаралды 5 М.
HOW TO REPAIR MAKITA BATTERY WITHOUT CHANGING BMS
9:08
Tools World
Рет қаралды 47 М.
Внутренности Rabbit R1 и AI Pin
1:00
Кик Обзор
Рет қаралды 1,8 МЛН
How about that uh?😎 #sneakers #airpods
0:13
Side Sphere
Рет қаралды 8 МЛН