Link for part roofmotors.co.u... PDF Guide www.autoelectro...
Пікірлер: 67
@adhartung5 жыл бұрын
Thank you so so much!! You helped me save so much money and gave me the confidence to fix this myself! 😁💪 This USA girl is grateful.
@mrfrankbosh5 жыл бұрын
I was able to clean the commutator and reinstall. Works great lasts along time, I hope. Hold assembly vertical in trunk motor up, rags undernieth. Remove power to motor and unbolt torx screws. You will get some oil spill when separated. Remove motor, keeping pump assembly vertical. Remove power connector from pump bracket. In a clean place unbolt two long cap bolts the pull Bell housing off rotor. The commentator is where the brushes ride. Sand 400 grit until shiny copper then spray contact cleaner and make sure brushes move smoothly. Then reassemble and reinstall.
@mrfrankbosh3 жыл бұрын
The fix lasted a year and oil seeping from pump seal contaminated the commutator again. I am sending pump & motor out for rebuild. The motor is just a symptom of a worn pump seal.
@Melbournerider3 жыл бұрын
Hey mate, hope you were able to get it sorted. Thanks for sharing your comments and updates.
@CraigMansfield2 жыл бұрын
Thank you very much man. I'd also like to mention that the A4 has a hidden tool in the area beside the steering wheel, that allows you to manually wind your roof closed in case of electrical failure. You have to open the compartment in the back seat, pull out some ski cover thing that I don't know it's use. Wind the roof to a point, lower it, then go in the front seat and take out a rectangle of plastic in the roof near the rear view mirror and wind it closed with the tool. Just saved my bacon tonight 👍🏻👍🏻👍🏻👍🏻👍🏻👍🏻
@gregorythoman82816 жыл бұрын
It is actually rare for the motor to go bad. Take it to an audi dealership and the bill will be approximately $2,700. They will want to replace the entire assy and the sensor. Most of the time it is low hydraulic fluid. $12 for Audi fluid. Audi will not tell you it is low fluid.
@Melbournerider5 жыл бұрын
Gregory Thoman I tried that the first time but the level was fine but the brushes were damaged
@palproe6 жыл бұрын
Very good. You are fantastic. Congratulations, everything is done as it should be and you still have the job of making a pdf and a link with the materials. You're the best !!!!!! Thanks for everything
@billbostick492 жыл бұрын
Great help…kept me from breaking bits and pieces or disassembling too much…thanks
@mikescott23563 жыл бұрын
Thats a great video, will have a go this afternoon. Plan for now is to start by putting a voltmeter across the motor cables to ensure the car is trying to run the motor... If voltage is there then I will know the motor is definitely bad and I will then buy the replacement. Don’t forget to ensure those grounds are re connected and your boot storage lever is in the right position.
@Melbournerider3 жыл бұрын
Good luck mate. I hope you were able to sort it out.
@MassimoAllen4 жыл бұрын
Nice Job, Many Thanks for taking the time to produce this video- Cheers Mate!
@lukespencer64596 жыл бұрын
Thanks for saving me $3500! This video was perfect!
@stevenfenton33195 жыл бұрын
Great video. Side trim removal at the beginning, you mention that "up here there's another little plug you've got to remove". Your hand goes in and I hear a click, but then the video jumps ..is it a DC connection or just a clip holding the trim please?
@demiansworld4873 ай бұрын
I moved my brushes. Reconnected and now my windows and interior lights arent working😢, they were working before tho agter i replaced ccm .
@kittykatalm6 жыл бұрын
Great video Nick. Can confirm - I am very happy!!!!
@maurogenovesi27712 жыл бұрын
grazie 1000... congratulazioni per il video
@maurogenovesi27712 жыл бұрын
Hi, first of all thank you for your very useful video to understand the problem of the hood. Unfortunately, replacing the engine did not solve the problem. I bought the engine and it arrived very quickly. Purchase and delivery, all perfect. I mounted the new piece but the hood opens a few centimeters but the rear hood does not open to accommodate it and she does not bend down to get inside. Looking at the hood pistons, I realized that there is one that is leaking liquid, I think it is oil. Is it possible that the problem is that and that the hood is blocked by a sensor that stops the movement?
@geoffhughes28043 жыл бұрын
Thank you mate help me out big time respect
@Melbournerider3 жыл бұрын
You're welcome, I'm pleased that sharing this has been useful to other people.
@Xantylon744 жыл бұрын
One part is missing, you only showed installing the new motor. I there a seal to the oil ? Where and how did you loose some oil? How wet get the air out of the system, is something is not right if we loose even more oil? Thx!
@Bierprofi3 жыл бұрын
No answer from that guy. Such videos should be deleted
@Melbournerider3 жыл бұрын
I am not by any means an expert in this area, I created this video as a bit of a side project/hobby as I found it difficult to find this information online. It's not unreasonable to miss comment notifications from time to time so I would hope the video in isolation remains being helpful and not warrant being deleted due to not responding to a question. My two cents worth since you shared yours.
@everbanol3015 Жыл бұрын
Did u put some hydraulic oil after using the 13mm to open screw from reservoir? It’s just I see u pouring something but u don’t say what exactly that u poured into it?
@TheBoss-dl9ei6 жыл бұрын
Hey man do you know where I can find sebs grave aka moto frogger 😞
@jimmyperini77043 жыл бұрын
Hey mate , Can you test the motor without pulling it? How? With a voltage meter ? Where do you put it and asap please. My top wont go down but i thinks its more to do with the tray assembly so help please
@Melbournerider3 жыл бұрын
Hey mate, I did more of a visual test before pulling it out and noticed the brushes were damaged, this is what led me to pulling it out in the end
@RaqRedOX6 жыл бұрын
Everyone saying they miss SEB Everyone misses seb but it will make people sad to keep knowing that he is no longer here I mean it's not bad but try not to do it too much cause it's really sad but yes everyone misses seb (P.S cool video dude just joined the channel off of the sad sad video)
4 жыл бұрын
Hello, and then, where is the alarm in your cabriolet???
@berengamble18826 жыл бұрын
Mate thanks so much for this. Helps a lot.
@lilblue1016 жыл бұрын
How do u know if the motor is bad & if a person just needs to refill the oil tank ??!!!!?!?!?!?!??!!
@Melbournerider5 жыл бұрын
bLu you fill the oil first, if that didn’t fit it then do this process. Our motor brushes were damaged
@Kim-78f5 жыл бұрын
Mi 7 lle q111
@goonluv Жыл бұрын
any isea why i havnt got the roof light on my dash
@baconbacon3326 жыл бұрын
Hay I am from Melbourne too
@jai54702 жыл бұрын
Thanks, is the motor good for any Audi, mine is an Audi A4 2004 Cabriolet, also is the reservoir comes with the motor?
@Melbournerider2 жыл бұрын
The motor was sold separately and bolts onto the reservoir
@fredericbouchaud60376 жыл бұрын
Thank you very much !
@Saeed_Alshikhy Жыл бұрын
Sir I have a4 cabriolet 2006 and the roof top is burning the fuse do you if there is any solution for it Or how and from where can I get a good roof pump Thank you
@demiansworld48711 күн бұрын
U fix?
@goonluv Жыл бұрын
my roof wontt even open a bit any ideas please
@tattoostudio6663 жыл бұрын
hi yhere! Can you writ down what that european brake fluid is, please? :]
@lilblue1016 жыл бұрын
What do u do if u do hear the motor working ??!!?!?!????÷
@charlien78662 жыл бұрын
Great video. Thanks
@AssinscreedTimmy6 жыл бұрын
Wild guess your Melbourne Australia not Melbourne florida
@ferbau11714 жыл бұрын
Hello. Do you know exactly what type of oil to fill with?
@Davo323103 жыл бұрын
Hydraulic fluid
@everbanol3015 Жыл бұрын
What type just any Audi hydraulic fluid?
@lilblue1016 жыл бұрын
I found the motor on eBay for about the same price
@goonluv Жыл бұрын
hi does any one know the fuse location for the roof cheers
@Putnam11035 жыл бұрын
Thank you Nick, Great Video !
@Melbournerider5 жыл бұрын
putt1103 hope it helped!!
@aaroncrawford34033 жыл бұрын
Where did you buy your new motor from?
@Melbournerider3 жыл бұрын
I posted the link in the description of the video
@andrewarmstrong73105 жыл бұрын
That's the problem! The steering wheel is on the wrong side!
@Melbournerider3 жыл бұрын
Haha! Right hand drive for us Aussies...
@aa1aa2114 жыл бұрын
What year is the car. Does it work in a 2008??
@Melbournerider3 жыл бұрын
2007, can't be sure about the feasibility of other models without doing some research
@jai54702 жыл бұрын
waiting for your response
@liluzi44246 жыл бұрын
Rip Sebastian :(
@aidendavis12406 жыл бұрын
I miss Sebastian
@RaqRedOX6 жыл бұрын
Aiden Davis I just saw the video I cried when the music started playing I am 2 years late but he is riding in paradise man hopefully with other riders :,)
@cptings33965 жыл бұрын
Good likkle business idea, open a garage and fix convert roofs..hmm
@Melbournerider3 жыл бұрын
Haha don't think so... cars are a hobby for me and I did this to save some $ for my girlfriend but otherwise I'm too busy running another business...!
@jacksabbath79863 жыл бұрын
Are you insane? You are trying to impress the KZfaqRS out there with your "Show-off tear-down"....which is total BS & unnecessary. Just add hydraulic fluid folks....and don't even try to disassemble your trunk. You will be sorry, as you end up ruining your top.
@Melbournerider3 жыл бұрын
1. No, not insane 2. Not impressing anyone, simply sharing information to others that I personally found useful 3. Tried the fluid and it didn’t fix the problem, noticed the brushes in motor weren’t working so tried this as the next best option 4. Four years later and the roof is still going strong... best thing I ever did so I am not sorry :)