Polaris Ranger 500 Replacing all fluids

Рет қаралды 36,827

2 жыл бұрын

In this video I show how to replace fluids for front differential, transmission, rear differential and do a oil change on engine. If you have a 2001-2009 full size ranger of any engine size this is the process of changing fluids. There may be slight physical changes such as the 01-04 has a solid rear axle instead of the independent but the process is the same. Below is list of fluids and amounts you’ll need to do the job. See below for list of models.
AGL 16oz
Demand Drive 5OZ
Angle Drive 18oz
PS4 3qts
Oil filter Polaris 2540086 (Fram PH6017A)
#polaris #polarisranger
Models Covered
Series 10
Series 11
Ranger TM
Ranger 500 2x4 and 4x4
Ranger 6x6
Ranger 700xp
Ranger 700 Crew
Ranger 500 EFI

Пікірлер: 65

@mikechristensen9744 2 жыл бұрын

Out of MANY videos on oil changes, yours was the first to actually show where the engine oil drain was...Thank you! Even the user and service manuals do not show exactly where it is.

@montemania198210 2 жыл бұрын

Thank you. I try to be very informative with my videos.

@rippinlips4543 9 ай бұрын

@@montemania198210I have a question have you ever put a snow blade on your ranger? I have a 2005 snow blade and bought the Polaris 2878011 HD Plow Mount. I’m trying to figure out how to attach a blade to this. Any information would help! Love your videos on these older rangers.

@timothyowen1806 5 ай бұрын

Thanks bro for the video. Excellent job making the video without wasting a lot of time with nonsense. I appreciate you

@clarkgriswold-zr5sb 2 жыл бұрын

Excellent video!! Very well done and informative. I have a new-to-me 2006 500 Ranger that needs fluids changed... I'm ready to get after it now.

@chriscash4118 11 ай бұрын

There is a filter in line behind the sump tank at the bottom where the return line from engine comes in to oil tank that needs to be cleaned every other oil change just remove clean it and replace it no need to replace with new one just keep cleaned out its bad about collecting sludge and block return in that area . Good helpful video thanks .

@sterlingwashburn9355 9 ай бұрын

Great video. Thanks

@blandis7530 Жыл бұрын

Thank you for the well thought out video

@jenkinsc2200 Жыл бұрын

great video ! saved man-hours saved! thanks

@georgeburnett8719 Жыл бұрын

Great job. Super helpful!

@montemania198210 Жыл бұрын

Thank you and you’re very welcome

@alaskauntamed6476 2 жыл бұрын

This is a great video

@lancejernigan7773 Жыл бұрын

Excellent video

@user-tn7pb1qg5y 7 ай бұрын

Thanks it helped me out!!

@lucien-3764 Жыл бұрын

Good show! If I want to check oil pressure, where would be the plug?

@dustoff1472 3 ай бұрын

Excellent. Thank you

@quazorgemash Ай бұрын

There's a backed out bolt on the engine mounting bracket. Visible when you are showing the engine oil drain location.

@jenkinsc2200 9 ай бұрын

great video. I have this exact vehicle. I'm having a hard time getting the engine cover off. I mean the seats and cover all the way to the rear.

@bryansbeef 2 жыл бұрын

Love it!

@maayanelev Жыл бұрын

Hi , I have a 2004 ranger 500 and was wandering what advice you have on making it quieter?

@Chibama Жыл бұрын

Good video, clear and simple. How many hours this ranger have?

@louiscormier12 Жыл бұрын

Thank you so much!

@BadUncleIke 2 жыл бұрын

Good job, you did it properly unlike people I have paid to do this job.

@montemania198210 2 жыл бұрын

Thank you sir. I’ve seen my fair share of bad jobs myself.

@exoditegrayc 2 ай бұрын

Great video! What was that WIX oil filter number? Thanks!

@gman1141 11 ай бұрын

I have an '02 6x6 with 2 rear diffs. Do they both use the same type fluid? Also did you ever show pulling the shift fork shaft out of the old transmission? Mine grinds going to High range and I might try repairing myself.

@briancarvalho222 Жыл бұрын

Good video

@Margaret395 Жыл бұрын

Hi this is Gary is the oil filter for a 500 and a700 the same.

@markusgarvey 7 ай бұрын

Good video. The o ring has 2 sides.

@charlesammons9978 2 жыл бұрын

Great video. I do have a question about fuel filter location and part number and zerk fittings locations. Thanks

@montemania198210 2 жыл бұрын

Thank you. Fuel filter is in-line close to gas tank. I have a video showing how to rebuild fuel system. Unfortunately Polaris stopped using grease fittings which was a stupid move. The only grease fitting on it is at the yoke for front driveshaft we’re it attaches to transmission.

@austinicholas Жыл бұрын

I can't reach the oil drain. I know it's not ideal but on my 2004 6x6 I crank it over a few times to get that extra oil out.

@johndougherty5045 4 ай бұрын

Do you have a link to the gun rack you have in roof ? Thanks

@jongravanti4740 6 ай бұрын

Hello, I picked up a 2003 polaris ranger and looking at the old manuals it says use oil 0 - w40. Is the PS4 5w 50 the correct one? Thanks!

@ryandevendorf2558 4 ай бұрын

What happens if you don’t pinch off the sump after doing the oil? Will the air get out regardless?

@familycatalyst4565 8 ай бұрын

I have a 2009 ranger 500 EFI 4x4 and the Gearcase (Transmission) takes 43.6 oz to fill or two bottles not one. otherwise great video thank you for the help

@KevinBeGood 8 ай бұрын

I just picked up one of these rangers and it has a second battery under the seat right there by the oil reservoir. Is that normal why would it have 2 batteries? Did yours have 2? Do I need both?

@xraykadiddlehopper8067 Жыл бұрын

Attention! It takes almost a full qt to fill to the plug level on that rear diff. 18oz fills 3/4” below the fill plug. I filled mine to the bottom of the plug and it took a full qt. Opinions are 50/50 on whether fill to the bottom of fill plug is bad. Some do it as a rule. Some say OMG you’ll ruin your diff. 😅

@alan-dr8uo Жыл бұрын

Thanks. I just one gave to me

@ronbeers2267 2 жыл бұрын

The video was great best one I’ve seen on. I have a 2005 same as this one but could not find the check/fill plug for the transmission is there a different spot any suggestions

@montemania198210 2 жыл бұрын

Well thank you!!! It’s in the same spot as in my video. It might be filled and covered with dirt.

@tammysadler1311 2 жыл бұрын

You aren't crazy! I have a 2005 and the fill plug is not in the same location as this video. It is an 8mm Allen (same as the drain plug) above on the right side of the transmission. I even looked in the owner's manual and mine is different. So strange.

@ronphillips2541 Жыл бұрын

I have a 2004 model Polaris Ranger 4x4 that is shutting off after I run the machine for a few minutes. Once it cools it will crank up again. Your thoughts on this is appreciated. I've been told it could be the fan not working properly.

@montemania198210 Жыл бұрын

Could be a number of things. However what comes to mind is something electrical is getting hot and shutting down. I would check when it happens the fuel pump make sure it’s pumping and also check for spark, could be pump or coil heating up and shorting out. If both are ok see if she’ll fire off with starting fluid, if it does then that’s a indication the carburetor is vapor locking.

@austinicholas Жыл бұрын

Had the same issue. Under the hood there are 3 black regulater boxes. The small bottom one regulates the fuel and pump. I jumped the outer two wires bypassing it. I installed a fuel pump with two outlets after the pump. One to carb and the other back to the tank which I drilled a hole and installed a grommet. Downside is the pump will always run when key is on. Upside you don't have to pay 250-300 for a used part if you can find it that is.

@offthestreetsandinthecreek7294 2 жыл бұрын

Great video . I love these videos I learn so much Is this the same for the 2004 500 ?

@montemania198210 2 жыл бұрын

Thank you. Yes the only difference is yours has a SRA instead of the IRS. So your rear diff is part of axle housing. Same procedure removing fill plug, remove drain plug, fill to threads of fill plug hole.

@offthestreetsandinthecreek7294 2 жыл бұрын

@@montemania198210 thanks bud . Any plans on making a Patron ? I would like to see more videos sooner . I don’t know if I can wait a week 😝

@montemania198210 2 жыл бұрын

@@offthestreetsandinthecreek7294 lol it’s in my thoughts now.

@ericzinaman2918 2 жыл бұрын

Do you ever get white milky slime under the oil cap?

@montemania198210 2 жыл бұрын

No. Milk on cap is water/moisture in system. If drained oil is milky then it’s either coolant in system or water intrusion from drowning engine in water. (Seen bad oil cap let water in) If drained oil looks fine then it’s breather system in need of replacement. Milky condition is never good.

@mrdickjurgensen 2 жыл бұрын

In my high humidity, moist, summer environment (North Georgia), I've found a bit of milky coating under the oil cap but none in the oil itself. IMHO... little to worry about. It wipes away readily.

@montemania198210 2 жыл бұрын

@@mrdickjurgensen good day sir. That is perfectly normal. Check your breather filter sometimes new one helps reduce it. Other than that it’s normal trust me I know humidity, Houston here lol.

@mrdickjurgensen 2 жыл бұрын

@@montemania198210 I'll check my breather filter as you suggest. I just changed my oil this morning after posting to this thread and my oil was quite dirty and long overdue for changing.... but there was no indication (thank goodness) of moisture in the oil itself. Great video BTW.... very inspiring/helpful indeed! On a different note: I took off my skid plate long ago so I'm careful where I drive my 6x6 Ranger 500. It makes inspections and maintenance on the underside of the UTV so much easier and cleaner.

@MrMan5014 2 ай бұрын

Apparently the Rotella T6 5w40 is superior to the Polaris oil…a lot of guys are using the Rotella and having less problems with their engines…

@PseudonymAliase 5 ай бұрын

14 minutes looks like there was a loose engine mount bolt to frame.

@Rick-nk7pm 2 жыл бұрын

If a filter looks close can I use it even if it is wrong part number? 2917 2017 polaris ranger full size 570efi can I use 10w30????

@montemania198210 2 жыл бұрын

I would use the correct filter, even if it looks same it’s what’s inside that matters. Also do not run 10w30 in a 570. 5w50 or 10w50 only.

@Rick-nk7pm 2 жыл бұрын

@@montemania198210 thanks boo

@waylonmccrae3546 Жыл бұрын

I run T-6 Rotella 5W-40 in mine with never a problem , Castrol 5W-20 Synthetic In the Trans with 3oz. Of Lucas Oil Stabilizer , Mobil 424 in the Demand Drive front pumpkin & 75W-90 Hypoid in the Rear !! Polaris Does NOT manufacture nor bottle their Oil , it's Contracted out !!