Hi Alan I watched this video yesterday and changed my fuel filter on my 2012 Mondeo Really glad I did as I would have probably made a backside of it if I didn't! Took your advice and carefully levered up the fuel filter cover. Let the filter drain, put the new one in carefully bolting it down and then started the car! First turn of the key sprung into life! So thanks Alan great advice! If your ever up in Edinburgh il buy you a pint! Cheers Fella

Was scared of doing the fuel filter having seen loads of people vacuuming fuel lines and what not on this engine. Your video gave me confidence. Took 5 mins all in. Thanks.

Just did the fuel filter on my Focus which has the same engine as the MK4 Mondeo, very easy and this video gave me the confidence to do it myself. My old filter looked like the one in your video. It was in there for ~50,000 km. Had no trouble starting after I was done.

Great video, helped a lot and I like the way you do videos . On notice from my side. There is a Pillips plastc screw on the top of the filter housing. After installation of the new filter put out the screw and fill diesel until the filter housing is completely full. Than the moter starts fine. greetings from Austria

Alan, great. was wondering how best to tackle this job on my C-Max, Job done, thanks to you.... You are a funny guy for sure. thank you

Did as instructed, but went from original Ford filter into an aftermarket cartridge. Learned the hard way that the difference is that the Ford unit has a pipe inside, and it sucks fuel closer to the bottom of the housing, and the el cheapo sucks air above the fuel level initially. That led to four long cranks before the engine finally fired up. It also led to running problems the following day (read: run only five seconds before dying). Solution was to unscrew the plug from the plastic lid and connect a clear hose onto the hole, and suck the air out of the filter housing. Then just start the motor and give it a lot of pedal to keep revs up till it agreed to stay alive. And finally, finish the whole thing with a little bit of sporty driving to get the fuel running and shake the bubbles out.

Good video! 1.8 tdci is a nightmare to start after replacing fuel filter!

Thanks 😁 no problem after replacing. Working On 2014 10dwc mondeo mk4

Done my fuel filter today, same as you did, no issues starting after.. 👍🍻

Great video. Given me confidence to sort mine myself and save a few quid

The cuts in this video are perfect. I need to start learning how to do bits a bobs because I'm about as useful as a chocolate fire guard (MK4 Mondeo petrol with 115k on)

Just done my fuel filter, excellent instructions 👌

Thanks Alan, very helpful and entertaining 😂

Great video. Spent a few quid on turbo fin and epg valve cleaner but it was this that fixed my accelaration problems. Do it Alans way. :)

Alan, I learned a little trick getting fuel up to the filter housing. Look at the housing cover you'll see a little slot for a cross head screw driver. Go on give it a wee turn " leftie loosie" and you know those fellas who suck out the oil through dip stick pipe. Go on get your sucker up to the filter housing... Gently now or you suck more fuel than fill the filter housing 👍

I followed this video, and everything worked fine. But how come bleeding the fuel lines wasn't needed?

Excellent vid. Straight to the point.

Great fuel filter change Alan 👍🏻 Your videos are funny entertaining but more importantly helpful. Shame your cars are red as I’m a Manchester City supporter and can’t stand Man U 😩 😆 Great videos on Mondeos as I’ve got at 54 plate one with 160,000 on it so I’m learning a lot from you 😊 Poor badger 😢 Thanks Stevie.

Worked a treat. Thanks!!!

Very good Alan.

How do you pull that electric plug off, mine doesn't want to pull off and I don't want to break it.

Wish I'd have watched this before I changed the fuel filter as I disconnected the fuel pipes and got an airlock.

Hi Alen I followed your instructions to the T. Everything worked out perfectly. I was pretty proud of myself that I was able to do it. Thanks a lot. But I have another issue. I can see small air bubbles in my fuel lines. Motor runs great. Should I worry about this??

Hi Alan Great video. I did service my Ford Mondeo Mk4 2Litre Duratorq make my life a lot easy with with your video. Any chance you could do video how to replace glow plugs on this? I have checked all KZfaq and can't fine anything.

This was a brilliant video. I loved it and made me laugh out loud a lot!

Hi Alan! This is a great video, but i need a litle help. How can i drain the water if the engine said "water detected in fuel"? I saw a clear pipe go down, but wich tap need to open?

Nice Video ! But how can metal shavings in the fuel filter housing be an indicator for a bad high pressure Pumpe? After the fuel leaves the HP pump and goes trough the injectors, it doesn’t return through the fuel filter. It goes trough that green hose straight in to the tank ? If those shavings really are from the HP pump, they would have to be sucked out of the tank, back in to the filter right ? Cheers 🍻

Hi I have a MK4 from 2009 is this the same set up? It's a 2.0TDCi 140hp, I kept being told it's really difficult to do however if it is the same set up as this then I'll be laughing. Cheers, Luke.

Brilliant video. Do you have video for this car for oil and filter change.

I wondered why there were 2 different fuel filters listed for the Mondeo. Not seen that version before. The badger always wins

Hello, does anyone know how to properly change the fuel filter in Mondeo 2011 with the fuel filter in the back under the car? I know how to change the filter, but I am curious about bleeding... Is the bleeding done through the green pipe which is on the left of the engine?

My 2009 Mondeo tdci 2.0 does seem to have a fuel filter under the bonnet?

Hey Allan - do you reckon the fuel filter will be the same process on the 2.2 tdci mk4 ? Cheers

Hi mate, do you have a video on the 2.2 Tdci fuel filter replacement

Oh my god I really wish u cud of been my mechanic, I'm not sure where I'm ment to message u Alan but here I go, lol. I've been having a diesel leak for ova a yr, I took it too Halfords being my close garage🤪, I knw "wrong thing to do" but they hav changed everything other than the injectors them selves it finally they changed injector NUM 1 an put a bit of tpc tape if that's how u say it 🙈, but ever since that I left the garage 2 mins away stopped to put diesel in an then the car wudnt start again🤯, I've been recovered about 5 times now and they can't figure out why the car won't start once it's hit temperature. But now it seems tobe getting really hot and won't even stay on tick over for more fhan about 15 mins but yet I drove down the motorway 40miles an 40miles bk wiv no issues until I got bk an stopped an wiv in 10-15 mins it was sounding spluttery and wen u rev the car it sounds like a over rev web u release the peddle. I really hope u can just say "well yes it's bec of this" 🤣🤣🤣. No honestly it's destroying my mental health it's all I think about plus carwood changed a poorly fitted crankshaft, from wat Halfords did. And they did an oil change which was thick gooey oil they said may not of been changed for 5yrs. An oil filter cam belt water pump kit so I thought it wud be fixed now but took it from them the other day an the same thing again didn't start after I went too the garage straight after leaving carwood and paying them over £1100 which £300 was from me an the rest Halfords bill for messing the car up. But stil not fixed the none starting once at temp. Plzzz HELP ME 😩🙈

Which make of filter do you recommend?

Hello Alan, do you have any tips, for changing the fuel filter, on a 2008 Mondeo 2 litre diesel hatchback. I have watched some videos on this, and it looks a pain.

Ooo this one is soaked of love and passion for the work at hand... *lol*

thx for the video :) i have 2010 mondeo auto trans. i learned that my cars never changed transmission fluid.its 217000 km now.should i change it?is there any problem after change?

Hello Sr you are very good profesional.I like your videos .Can you explain me where I can find the PCV valve please.I ve brought recently a Citroen Dispatch 2 liter diesel and I want to change the PCV valve.Thank you very much Sr

Hi alan, watch alot of your mondeo videos and are absolutely brilliant, looking to do my fuel filter for a 2013 mondeo, looked on line and are they supposed to be between the 30 to 40 quid price range ? To me seems abit steep for just a filter ? Anyway great videos keep them up

I found metal shavings in my fuel filter, Is this a warning my HPFP is on it's way out?

Is there a video for the mondeos with fuel filter at the rear near tank. These can be somewhat challenging. Have you done one. Apparently it's easier to unplug fuel lines, plug them immediately as you unplug them, remove the whole housing completely, refill with clean filter and clean fuel, reconnect and fanny is your cousins uncle,

The fuel additive tank went dry on my focus cc3. Ford refilled it and reset the dpf but it was 400 quid ouch. How can you tell when this fluid gets low to avoid the engine malfunction light coming on

Your a legend!

This guy îs the Best

Can someone tell me what the two Philips valves and the hose that comes with the fuel housing are for?

Anyone knows by any chance the part number of the metal fuel filter cover/shield with those 3 screws, please 🙏? Mine is missing , and can't find it anywhere 🙁

Is this same proceedure for mk3 focus 2.0 tdci

There are 2 filters? I saw a video and the guy was looking at the back of the car, on the axle

Funniest Video all week 😂😂

Great video ! Is it possible to drain water from that type of fuel filter ? At dealer services where the fuel filter is not replaced, ETIS tells the Ford technicians to 'Drain water, if not renewed - Diesel models (with drain facility)'. Is it done via plastic screw on the top of the housing and if so, where does the water drain out ?

Hi Alan! I own a mk4 2,0 tdci ford mondeo. I've been using it since day 1. I usually use it for longer trips (50-100km at least. I own a petrol car for shorter local trips. The car was manufactured in 2013 and it has around 80,000 kms. I change my oil, oil filter, fuel filter, every 15000 kms, air filter and dust filter around 30,000kms. I usually rely on Autodata information on maintenance. I have a Haynes mk4 Mondeo book as well but i think they suggest maintenance too often. (~7500km/maintenance as i recall) (I know it only hurts my money not the car ;). Can you give me any guidelines what to maintain on my car to avoid as many problems as possible? According to your experience? My family owns two more Ford Galaxies, so we have some 2,0tdci cars around. Thanks for taking the time making these cool videos!

Thanks for showing .does this technique work fo focus 2.0 tech as well as I'm worried about getting an airlock and not been able to start the darn thing .?

Did you have a hangover?

I noticed that the threads are destroyed very easily when you put the screws back

Am I right that there is another type of fuel filter housing for later (or earlier) models - where the top of the housing should be unscrewed? I assume for such matters no other options rather than to unplug fuel pipes from the filter housing, right?

Any chance you have further info on bleeding air from the system? I"ve got the filter changed and car starts but can see there is air in the system which causes it to run slightly off and after sitting overnight can be hard to start. I've not had any luck locating a workshop manual for the 2013/14 models which seem to use this different filter (I have a 2010 model as well which has the filter at the rear).

Cool - thanks man :-)

Hi Alan, as always this video was great. Is this the same engine that I have in my S-max -11. 2.0L Tdci 163 hp? I to want to replace the fuel filter but are a bit afraid och messing up the high pressure pump due to air in the system

Crackin stuff

lol...Good sense of humour!

Fk, i like your style :D I have Mondeo 2010, 2.2tdci 129kw (Peugeot/Citroen engine)... Can you show, please, how to change this plastic, black fuel filter? How to get air out?

Why didn't go the full hog and do a oil change

Yakıt filtresi altta olması lazım yauv

hm..I thought the fuel filter was somwhere in the rear of the car

So you are not doing the comedy anymore Jasper