Heat Only On Drivers Side (2003-2006 Chevy Silverado or GMC Sierra) (Diagnoses)

Рет қаралды 92,097

5 жыл бұрын

Пікірлер: 64

@pipez3307 Жыл бұрын

ive been searching for months through forums for this temporary fix and never checked out any videos, i saw your repair video first and then this popped up and you sir are a legend! advanced wanted $154 for the part, the part you got on amazon is down to $26 now!!

@michaelbauermeister8906 4 ай бұрын

Thanks Dustin, you nailed it, my truck is now fixed! Here's a quick test to see if this is your problem. Take the actuator off like Dustin says, then plug it in and turn the key on. When you move the heater control you should see the actuator rotate. If it doesn't, it's dead.

@richardgalli7262 Жыл бұрын

I just repaired my A/C automatic blend motor assembly by disassembling the unit, inspected the gears, inspected the large final drive gear and its copper fingers that slide on the variable resistor pad. I put more tension on the copper fingers and used the surplus lube from inside and applied it to the gears. Reinstalled the unit and started my 2012 GMC Sierra with the A/C on, varied the temp setting cold to hot and back again, IT WORKS! Just my time and no parts.

@wmnlover 9 ай бұрын

Thanks for posting the video!

@JBCPuppydaddy Жыл бұрын

I appreciate the knowledge brother

@ProudPapaw88 5 жыл бұрын

Thanks for the heads up.

@redman1225 4 ай бұрын

Replaced this part on my 06 Silverado 2500, works like a charm

@onlyetm Күн бұрын

Still Useful today. Thought my AC broke when and checked the passenger side Ice cold. Got Cold back on my side till i get the part

@dizzledaw Ай бұрын

I’d love to know how you get that far left screw back in that holds up the plastic shield.

@MrHipp00 2 жыл бұрын

what is the link to the amazon for this product?

@thecuss6817 10 ай бұрын

I had this actuator malfunction on our 1994 Suburban (clicking noise from bad gear, shop replaced). And our 2005 Yukon (clicking noise from bad gear, I replaced). And recently on our 2014 Yukon (no clicking, I cleaned out and re-installed the actuator). I needed a 7mm socket to remove the black cover. And I needed to grind down a 5.5mm socket shorter at both ends or use a cut-down 5.5mm nutsetter and 1/4 inch combination wrench to R&R the screws for the actuator itself. Why I'm posting: for the left-most actuator screw, it was easier to access from the driver footwell, in front of the console; one can actually see that screw from that side.

@VinnietheEnglishKing Ай бұрын

Worked great

@tastethetaco9612 Жыл бұрын

Thank you!

@isaacchavez2276 3 жыл бұрын

Any link on actuator I found the wrong one 😅

@EricBishop_ 7 ай бұрын

The issue I’m having is when a passenger gets in and adjusts the passenger side climate, how do I get it back do dual so I can can control both sides from the driver side?

@astrorapidz5186 11 ай бұрын

Where do I see the part replacement on your page?

@michaelcampos7944 3 жыл бұрын

Thank You!!!

@hll1481 11 ай бұрын

Is there a link on Amazon where you bought item

@willyg.3111 8 ай бұрын

What if you have nothing but ac in the fall/winter?

@marksimmons4428 2 жыл бұрын

Thanks 😊

@louievizuet8438 8 күн бұрын

Thanks ✌️

@alleyratAnderson Жыл бұрын

My Chevy Silverado was doing the same thing, the driver's side was always full hot, and the passenger side was cold. I ordered and put in a new actuator, and the driver's side now works great, but instantly as soon as I put in the new actuator the passenger side went bad and now permanently blows hot.

@lotbello5087 3 жыл бұрын

Do you know the name of the part i going to buyam replace mh self

@terryburgess1657 Жыл бұрын

Ggreat info

@hopelesslyinquisitive9839 3 жыл бұрын

My 2003 Silverado troubles began when #5 fan speed setting quit. Then the control for the dash, defrost, floor etc quit, now I’m having this issue with only hot air blowing on both sides. WTH?

@michialbowers94 3 жыл бұрын

Mov

@teddublon4274 3 жыл бұрын

Is it the same on gmc sieera

@jvducey 5 жыл бұрын

I had this problem on my 05

@a275cmr4 2 жыл бұрын

Do you know the name of that post the actuator sits on? Turned out my actuator works but the post is broken. Thanks

@willkirby3301 2 жыл бұрын

Did you ever figure it out

@eddiesantiago4054 2 жыл бұрын

whats that parts name

@rickygray7767 3 жыл бұрын

Do happen to remember the brand name?

@lotbello5087 3 жыл бұрын

Samw problem in my 06 silverado

@luisfigueroa7990 Жыл бұрын

can i drive without one ?

@RafaelHernandez-kn3bi 3 жыл бұрын

What is the name of the piece you replaced in the video ?

@brianbell504 Жыл бұрын

Hvac blend door actuator

@DEEBLOCCTV 6 ай бұрын

My driver's side is cold and the passenger is hot when running heat! do i change same actuator

@ricardogutierrez8370 10 күн бұрын

No for the passengers side, unfortunately is the inner top actuator, that one if a bit more difficult to replace, whole dash comes out for that one

@drodgers9821 3 жыл бұрын

The plastic shaft on box is broken that goes into actuator

@thomasnoonan1829 4 ай бұрын

I have same issue what was your fix?

@Zobavajaina 3 жыл бұрын

Driver side is not easy to replace

@themaximusone 2 жыл бұрын

I have a 2010 sierra Same issue

@greyhairedmountainbiker116 2 жыл бұрын

I just shut truck off and restart or remove the hvac fuse from side fuse panel (can't change hot to cold if you remove fuse and you have to do it while in cold mode), but since it's so easy... guess I'll fix it. Thanks

@DirtyRice334 11 ай бұрын

Good idea

@ThomasBilt 10 ай бұрын

Worked for me, thx

@santiagolopez-ys5hz Ай бұрын

tanks

@Raider562 3 ай бұрын

Hi everyone my actuator Was broken the main wheel i went to junk and i just get one but works for 10 min and same issue i swap the main wheel and set up Installed and solve the problem Good luck 😅😅

@countryboy5413 Жыл бұрын

My air messes up on the driver side but when I turn my truck off and turn it back on it fixes it. You think this is the problem?

@NJP76 11 ай бұрын

Same thing in my Avalanche. Seems to reset itself each time I start the engine. Sometimes it sets itself to full hot, and sometimes it works normally. Almost seems more like a controller issue that an actuator issue.

@countryboy5413 11 ай бұрын

@@NJP76 I was told it’s the vent door. They gotta pull the dash out to get to it

@ricknelson4793 10 ай бұрын

Someone on u tube may have a fix that you can do manually for summer months and then change back for winter months. Keep searching if you don't want to pay a bunch of money.

@NJP76 10 ай бұрын

@@ricknelson4793 We just replaced the controller unit today. After a couple of recalibrations it seems to be functioning as it should now. All of the actuators are working as well. Pretty easy fix without taking the whole dash out.

@countryboy5413 10 ай бұрын

@@ricknelson4793 sounds good, it went fully out a few weeks ago😂